Weider 245 Support and Manuals
Get Help and Manuals for this Weider item
Most Recent Weider 245 Questions
My Weider 245 Has Some Slack In The Lower Area Of The Long Cable? [part # 69]
I've been looking for almost an hour and a half now, but i have some slack in the lower region of th...
I've been looking for almost an hour and a half now, but i have some slack in the lower region of th...
(Posted by boredom77177 7 years ago)
How Do You Set Up The Weights Portion Of The Machine
(Posted by mydawg1 10 years ago)
Popular Weider 245 Manual Pages
English Manual - Page 1
... are missing parts, we are committed to you. The trained technicians on our customer hot line will guarantee complete satisfaction through direct assistance from our factory. Save this equipment.
CUSTOMER HOT LINE:
1-800-999-3756
Mon.-Fri., 6 a.m.-6 p.m. ®
Model No. WESY19002 Serial No. Write the serial number in this manual before using this manual for reference...
English Manual - Page 2
TABLE OF CONTENTS
IMPORTANT PRECAUTIONS 3 BEFORE YOU BEGIN 4 PART IDENTIFICATION CHART 5 ASSEMBLY 7 ADJUSTMENT 18 WEIGHT RESISTANCE CHART 19 TROUBLE-SHOOTING AND MAINTENANCE 20 CABLE DIAGRAM 21 PART LIST 22 EXPLODED DRAWING 23 ORDERING REPLACEMENT PARTS Back Cover LIMITED WARRANTY Back Cover
WEIDER is a registered trademark of ICON Health & Fitness, Inc.
2
English Manual - Page 3
... a free replacement decal. Keep children under the age of this product.
3 Use the training system only on the training system in the location shown.
5. Always stand on the foot plate when performing an exercise that the cables are raised;the weights will fall with pre-existing health problems. Read all instructions in this or any worn parts immediately...
English Manual - Page 4
... model number and serial number before Before reading further, please review the drawing using the WEIDER® 245 training system. For your cardiovascular system, the WEIDER® 245 will help us assist you have below and familiarize yourself with the parts that are additional questions, please call our Customer Service labeled. The WEIDER® 245 offers a selection of weight stations...
English Manual - Page 7
... CHART on this page; Do not dispose of evenings. Tightening Parts
Tighten all parts as you assemble them, unless instructed to walk around the training system as shown in the drawings.
Mountain Time.
By setting aside plenty of this manual. Note: Assembly will save you much more convenient if you will go smoothly. Refer to it .
Before beginning...
English Manual - Page 14
... ASSEMBLY
23. Locate the Long Cable (69). Route the Long Cable between the Base (4) and the Press Frame (17) as shown. the Pulley must be able to the bottom set...securely in the Pulley Plates (58) with a 3/8" x 2" Bolt (12) and a 3/8" Nylon Locknut (21).
Remove the pre-assembled 3 1/2" Pulleys (15) from the Pulley Plates (58). Route the Short Cable (23) around the other 3 1/2" Pulley (15...
English Manual - Page 15
... Cable Trap (66) to hold the Long Cable in step 27. Route this section of the Pulley. Route the Long Cable around a 3 1/2" Pulley (15). CABLE ASSEMBLY
27.
English Manual - Page 16
Attach the Backrest (41) to the training
system, remove the 1 1/2" Square Inner Cap
(32) from the Seat Frame (36). Insert the four 3/4" Round Inner ... the ends of the Pad
Tubes.
36 30
28
30
29
34
30
34
34. Slide
the Pad Tubes into the holes in
51
use, replace the 1 1/2" Square Inner Cap
(32). 36
16 31. Attach the Seat (13) to the Seat Frame (36)
31
using two 1/4" ...
English Manual - Page 17
... is used. See TROUBLE-SHOOTING AND MAINTENANCE on page 18 of the cables does not move smoothly over the pulleys. SEAT ASSEMBLY
35. See the CABLE DIAGRAM on the
35
Top Frame (55) and the Base (4) using the training system, pull each cable a few times to be damaged when heavy weight is any slack...
English Manual - Page 18
... THE WEIGHT SETTING
To change the weight setting of resistance at each exercise station may vary from 6.5 pounds to see how the training system should be performed. Use the WEIGHT RESISTANCE CHART on page 19 to the Short Cable (23) or the Long Cable (69, not shown) with two Cable Clips. ADJUSTMENT
The instructions below describe how each part...
English Manual - Page 20
... on the end of the Short Cable further into the "U" Bracket.
If
there is slack in the Seat Frame. TROUBLE-SHOOTING AND MAINTENANCE
Make sure all parts are not too tight, or the top weight will be removed from the Seat Frame (36). Replace any worn parts immediately. The training system can be lifted off the...
English Manual - Page 21
If the cables have been assembled correctly. rectly routed, the training system will not come off the pulleys.
The cable traps should... so that the cable traps do not touch or bind
the cables.
2
3
7
1-High Pulley
5
4
Short Cable-23
6 3
8-Weight Stack
6
4
8
5
2
7
9-Leg Lever
1-Low Pulley Long Cable-69
21 CABLE DIAGRAM
The diagram below shows the proper routing of...
English Manual - Page 22
Qty. WESY19002
Key No. Qty.
1
4
3/8" x 2 1/4" Carriage Bolt
2
2
1/4" Nylon Locknut
... Frame Top Weight "U"-Bracket Pulley Plate Shroud 5/16" x 6" Bolt 1/2" x 1/2" Spacer Weight Guide Weight Tube 3/8" x 4 1/4" Bolt ..." SAE Washer User's Manual Exercise Guide Exercise Chart Decal
Note: "#" indicates a non-illustrated part. PART LIST-Model No. Specifications are subject to change...
English Manual - Page 23
WESY19002
R0303A
79
60
3
61 62
79 23 57 78 86
32 56
63
74
79 27
40
71 7 40 9
76 50 21 6 55 10
89
...
12 1
15 58
46
3
75 15 66
22
15 66 17
39
21
21
16
77
12 69 52
53
21 27
23 EXPLODED DRAWING-Model No.
English Manual - Page 24
... use and service conditions, for indirect, special or consequential damages arising out of or in Canada © 2002 ICON Health & Fitness, Inc.
LIMITED WARRANTY
ICON Health & Fitness, Inc. (ICON), warrants this product to give the following information:
• The MODEL NUMBER of the product (WESY19002)
• The NAME of the product (WEIDER® 245 training system)
•...
Weider 245 Reviews
We have not received any reviews for Weider yet.