Hardware Maintenance Manual
Page 3
... Recovery discs 39 Restoring the factory contents by using PC-Doctor for DOS. . . . 30 Lenovo ThinkVantage Toolbox (Lenovo System Toolbox 33 PC-Doctor for servicing ThinkPad W700ds and W701ds 67 1010 Battery pack 68 1020 Digitizer pen 69 1030 Serial Ultrabay Enhanced device . . . ....No-beep symptoms 50 LCD-related symptoms 50 Intermittent problems 51 Undetermined problems 51 Chapter 5. Important service information 25 Strategy for replacing FRUs 25 Strategy for replacing a hard disk drive . . . 26 Important notice for CTO, CMV, and GAV products 27 Chapter 3. Status indicators . ...
... Recovery discs 39 Restoring the factory contents by using PC-Doctor for DOS. . . . 30 Lenovo ThinkVantage Toolbox (Lenovo System Toolbox 33 PC-Doctor for servicing ThinkPad W700ds and W701ds 67 1010 Battery pack 68 1020 Digitizer pen 69 1030 Serial Ultrabay Enhanced device . . . ....No-beep symptoms 50 LCD-related symptoms 50 Intermittent problems 51 Undetermined problems 51 Chapter 5. Important service information 25 Strategy for replacing FRUs 25 Strategy for replacing a hard disk drive . . . 26 Important notice for CTO, CMV, and GAV products 27 Chapter 3. Status indicators . ...
Hardware Maintenance Manual
Page 32
... codes. Important notice for a customer to configure an IBM® or a Lenovo solution from an eSite, and have this task. If more than one error code is a special bid offering. Strategy for replacing FRUs for CTO, CMV, and GAV Product definition Dynamic Configure To Order (CTO...The PEW record is provided to the customer to use error message Use the error codes displayed on the eSupport site.) 26 ThinkPad W700, W700ds, W701, and W701ds Hardware Maintenance Manual Running Automatic Configuration may have been changed. If no error code is displayed, see whether the error symptom...
... codes. Important notice for a customer to configure an IBM® or a Lenovo solution from an eSite, and have this task. If more than one error code is a special bid offering. Strategy for replacing FRUs for CTO, CMV, and GAV Product definition Dynamic Configure To Order (CTO...The PEW record is provided to the customer to use error message Use the error codes displayed on the eSupport site.) 26 ThinkPad W700, W700ds, W701, and W701ds Hardware Maintenance Manual Running Automatic Configuration may have been changed. If no error code is displayed, see whether the error symptom...
Hardware Maintenance Manual
Page 42
... be able to + 12.6 Ground (-) 3. Remove the battery pack and measure the voltage between battery terminals 5 and 7. If the resistance is not correct, replace the ac adapter. 4. If the voltage is acceptable, do the following figure: 3 4 5 6(-) 7(-) 2(+) 1(+) Terminal 1 7 Voltage (V dc) + ... charging. If the voltage is not correct, replace the battery pack. If it . After it cools down, reinstall and recharge it is correct, replace the system board. 36 ThinkPad W700, W700ds, W701, and W701ds Hardware Maintenance Manual This protects the battery pack ...
... be able to + 12.6 Ground (-) 3. Remove the battery pack and measure the voltage between battery terminals 5 and 7. If the resistance is not correct, replace the ac adapter. 4. If the voltage is acceptable, do the following figure: 3 4 5 6(-) 7(-) 2(+) 1(+) Terminal 1 7 Voltage (V dc) + ... charging. If the voltage is not correct, replace the battery pack. If it . After it cools down, reinstall and recharge it is correct, replace the system board. 36 ThinkPad W700, W700ds, W701, and W701ds Hardware Maintenance Manual This protects the battery pack ...
Hardware Maintenance Manual
Page 48
... this function is selected and the user HDP has been forgotten and cannot be replaced for a scheduled fee. Type the current SVP in the Setup confirmation window, select... known by the service technician: 1. Select Yes in Windows XP), and hibernation. 42 ThinkPad W700, W700ds, W701, and W701ds Hardware Maintenance Manual Power management To reduce power consumption, the computer has three power management ... The hard disk drive can be made available to the service technician, neither Lenovo nor Lenovo authorized service technicians provide any services to reset the user HDPs or to enter...
... this function is selected and the user HDP has been forgotten and cannot be replaced for a scheduled fee. Type the current SVP in the Setup confirmation window, select... known by the service technician: 1. Select Yes in Windows XP), and hibernation. 42 ThinkPad W700, W700ds, W701, and W701ds Hardware Maintenance Manual Power management To reduce power consumption, the computer has three power management ... The hard disk drive can be made available to the service technician, neither Lenovo nor Lenovo authorized service technicians provide any services to reset the user HDPs or to enter...
Hardware Maintenance Manual
Page 50
...Undetermined problems" on the timer, and if the user does not do undock it before resuming normal operation. Do not replace a nondefective FRU. If you do any number. The most likely cause is displayed for each error detected in boldface ...when battery becomes low, and the battery charge becomes critically low. Note: Do the FRU replacement or other actions in the sequence shown in the column headed "FRU or action, in the computer. This index ...that causes the system to go to "Intermittent problems" on page 51. 44 ThinkPad W700, W700ds, W701, and W701ds Hardware Maintenance Manual
...Undetermined problems" on the timer, and if the user does not do undock it before resuming normal operation. Do not replace a nondefective FRU. If you do any number. The most likely cause is displayed for each error detected in boldface ...when battery becomes low, and the battery charge becomes critically low. Note: Do the FRU replacement or other actions in the sequence shown in the column headed "FRU or action, in the computer. This index ...that causes the system to go to "Intermittent problems" on page 51. 44 ThinkPad W700, W700ds, W701, and W701ds Hardware Maintenance Manual
Hardware Maintenance Manual
Page 52
... bad-The password is dead. 1. Press to ignore the warning message. 2. Remove either a Mini-PCI Card or a modem daughter card. Replace the backup battery and run BIOS Setup Utility to clear this error. 2. Remove all but one Wireless LAN devices are found . Load Setup ... Load Setup Defaults in CMOS. Run BIOS Setup Utility, and then save the current setting by running BIOS Setup Utility. 46 ThinkPad W700, W700ds, W701, and W701ds Hardware Maintenance Manual System board. 01C9 More than one of them . Confirm the operation and try again. 0199 System Security- ...
... bad-The password is dead. 1. Press to ignore the warning message. 2. Remove either a Mini-PCI Card or a modem daughter card. Replace the backup battery and run BIOS Setup Utility to clear this error. 2. Remove all but one Wireless LAN devices are found . Load Setup ... Load Setup Defaults in CMOS. Run BIOS Setup Utility, and then save the current setting by running BIOS Setup Utility. 46 ThinkPad W700, W700ds, W701, and W701ds Hardware Maintenance Manual System board. 01C9 More than one of them . Confirm the operation and try again. 0199 System Security- ...
Hardware Maintenance Manual
Page 54
...CONTENTS in RECOVER TO FACTORY CONTENTS. If item 4 failed, replace the hard disk drive. 1820 More than one external fingerprint reader...authentication. 1830 Invalid memory configuration-Power off and remove all partitions. System board. 48 ThinkPad W700, W700ds, W701, and W701ds Hardware Maintenance Manual Table 2. If the Access Predesktop Area has been previously disabled, then...any physical shock to the customer: If in the primary bay the customer is using a supported IBM/Lenovo HDD with data integrity, including data loss. Ultrabay™ hard disk drive. 3. Numeric error codes (...
...CONTENTS in RECOVER TO FACTORY CONTENTS. If item 4 failed, replace the hard disk drive. 1820 More than one external fingerprint reader...authentication. 1830 Invalid memory configuration-Power off and remove all partitions. System board. 48 ThinkPad W700, W700ds, W701, and W701ds Hardware Maintenance Manual Table 2. If the Access Predesktop Area has been previously disabled, then...any physical shock to the customer: If in the primary bay the customer is using a supported IBM/Lenovo HDD with data integrity, including data loss. Ultrabay™ hard disk drive. 3. Numeric error codes (...
Hardware Maintenance Manual
Page 56
... System board One short beep, pause, three short beeps, pause, three more visible defective pixels, it will be deemed as defective by Lenovo and it should be considered faulty. System board No-beep symptoms Table 5. The presence of a small number of four short beeps and... is installed, confirm that are servicing has two or less visible defective pixels, it should not be replaced. Reseat DIMM. 2. System board. Type the password and press Enter. Type the password and press Enter. Notes: 50 ThinkPad W700, W700ds, W701, and W701ds Hardware Maintenance Manual
... System board One short beep, pause, three short beeps, pause, three more visible defective pixels, it will be deemed as defective by Lenovo and it should be considered faulty. System board No-beep symptoms Table 5. The presence of a small number of four short beeps and... is installed, confirm that are servicing has two or less visible defective pixels, it should not be replaced. Reseat DIMM. 2. System board. Type the password and press Enter. Type the password and press Enter. Notes: 50 ThinkPad W700, W700ds, W701, and W701ds Hardware Maintenance Manual
Hardware Maintenance Manual
Page 58
Turn on the computer. 5. If the problem remains, replace the following FRUs one at a time (do not replace a nondefective FRU): a. Determine whether the problem has been solved. 6. System board b. LCD assembly 52 ThinkPad W700, W700ds, W701, and W701ds Hardware Maintenance Manual PC Cards 4. If the problem does not recur, reconnect the removed devices one at a time until you find the failing FRU. 7. i.
Turn on the computer. 5. If the problem remains, replace the following FRUs one at a time (do not replace a nondefective FRU): a. Determine whether the problem has been solved. 6. System board b. LCD assembly 52 ThinkPad W700, W700ds, W701, and W701ds Hardware Maintenance Manual PC Cards 4. If the problem does not recur, reconnect the removed devices one at a time until you find the failing FRU. 7. i.
Hardware Maintenance Manual
Page 59
... first, then proceed with the installation. Turn on the computer. © Copyright Lenovo 2008, 2011 53 RAID Level 1 (RAID 1) - Press F1 to save the settings. Select RAID 6. Press F10 to enter the BIOS Setup Utility menu. 2. ThinkPad W700, W700ds, W701, and W701ds supports either RAID Level 0 (RAID 0) or RAID Level 1 (RAID 1). In this product... Configuration Utility to enable embedded SATA RAID functionality To configure the BIOS for this product, if the BIOS was formatted or the system board was replaced, RAID is not enabled by default.
... first, then proceed with the installation. Turn on the computer. © Copyright Lenovo 2008, 2011 53 RAID Level 1 (RAID 1) - Press F1 to save the settings. Select RAID 6. Press F10 to enter the BIOS Setup Utility menu. 2. ThinkPad W700, W700ds, W701, and W701ds supports either RAID Level 0 (RAID 0) or RAID Level 1 (RAID 1). In this product... Configuration Utility to enable embedded SATA RAID functionality To configure the BIOS for this product, if the BIOS was formatted or the system board was replaced, RAID is not enabled by default.
Hardware Maintenance Manual
Page 70
...was manufactured, the EEPROM on the system board was loaded with the serial numbers of your computer is '1STTTTMMMSSSSSSS'. Install the LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later and restart the computer. 2. From the main menu, select 1. Follow the ... designed to its original value. Add S/N data from EEPROM. If you replace the system board, you have the same number. 64 ThinkPad W700, W700ds, W701, and W701ds Hardware Maintenance Manual Install the LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later, and restart the computer. 2....
...was manufactured, the EEPROM on the system board was loaded with the serial numbers of your computer is '1STTTTMMMSSSSSSS'. Install the LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later and restart the computer. 2. From the main menu, select 1. Follow the ... designed to its original value. Add S/N data from EEPROM. If you replace the system board, you have the same number. 64 ThinkPad W700, W700ds, W701, and W701ds Hardware Maintenance Manual Install the LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later, and restart the computer. 2....
Hardware Maintenance Manual
Page 73
... servicing ThinkPad W700ds and W701ds The ...computer display is designed to be opened and used at an angle of the page. Do not open it to the main display. Do not open the main display beyond 150 degrees. When turning a screw to replace...replacing a FRU. Be sure to , and can cause electrical short circuits. Before replacing...replacing a FRU This chapter presents directions and drawings for rattling sounds. Any such FRUs are listed. 4. When replacing...replacement. Begin by , electrostatic discharge. DANGER..."FRU replacement notices" on page 153. 8. Attention: After replacing a FRU...
... servicing ThinkPad W700ds and W701ds The ...computer display is designed to be opened and used at an angle of the page. Do not open it to the main display. Do not open the main display beyond 150 degrees. When turning a screw to replace...replacing a FRU. Be sure to , and can cause electrical short circuits. Before replacing...replacing a FRU This chapter presents directions and drawings for rattling sounds. Any such FRUs are listed. 4. When replacing...replacement. Begin by , electrostatic discharge. DANGER..."FRU replacement notices" on page 153. 8. Attention: After replacing a FRU...
Hardware Maintenance Manual
Page 74
... properly on the second screen. • DVD playback and Blu-ray playback don't work in the slot. Considerations for replacing a battery pack: ThinkVantage Toolbox (in Windows 7) and Lenovo System Toolbox (in its slot. To use this diagnostic shows that the battery is extended, you do so might accidentally..., the external monitor will turn off automatically. If an external monitor has been attached and is reporting a possible safety issue. 68 ThinkPad W700, W700ds, W701, and W701ds Hardware Maintenance Manual a b • To store the second screen in use an external monitor.
... properly on the second screen. • DVD playback and Blu-ray playback don't work in the slot. Considerations for replacing a battery pack: ThinkVantage Toolbox (in Windows 7) and Lenovo System Toolbox (in its slot. To use this diagnostic shows that the battery is extended, you do so might accidentally..., the external monitor will turn off automatically. If an external monitor has been attached and is reporting a possible safety issue. 68 ThinkPad W700, W700ds, W701, and W701ds Hardware Maintenance Manual a b • To store the second screen in use an external monitor.
Hardware Maintenance Manual
Page 78
... same FRU no. must be installed properly. Otherwise the drive cannot be attached to the replacement drive. SSD and storage converter: 5 6 1050 DIMM slot cover and DIMM For access, remove this FRU: 72 ThinkPad W700, W700ds, W701, and W701ds Hardware Maintenance Manual In models with RAID features, two hard disk drives that the HDD...
... same FRU no. must be installed properly. Otherwise the drive cannot be attached to the replacement drive. SSD and storage converter: 5 6 1050 DIMM slot cover and DIMM For access, remove this FRU: 72 ThinkPad W700, W700ds, W701, and W701ds Hardware Maintenance Manual In models with RAID features, two hard disk drives that the HDD...
Hardware Maintenance Manual
Page 89
Removing and replacing a FRU 83 Removal steps of backup battery (continued) For ThinkPad W701 and W701ds: 1 2 When installing: Make sure that the battery connector is attached firmly. 1110 Numeric keypad For access, remove these FRUs in order: • "1010 Battery pack" on page 68 • "1040 Hard disk drive (HDD) cover, HDD and HDD rubber rails or solid state drive (SSD) and storage converter" on page 70 • "1060 Palm rest or palm rest with fingerprint reader" on page 75 • "1090 Keyboard" on page 80 Chapter 9. Table 19.
Removing and replacing a FRU 83 Removal steps of backup battery (continued) For ThinkPad W701 and W701ds: 1 2 When installing: Make sure that the battery connector is attached firmly. 1110 Numeric keypad For access, remove these FRUs in order: • "1010 Battery pack" on page 68 • "1040 Hard disk drive (HDD) cover, HDD and HDD rubber rails or solid state drive (SSD) and storage converter" on page 70 • "1060 Palm rest or palm rest with fingerprint reader" on page 75 • "1090 Keyboard" on page 80 Chapter 9. Table 19.
Hardware Maintenance Manual
Page 101
...of PCI Express Mini Card for wireless LAN/WiMAX for W700 and W700ds For ThinkPad W700 and W700ds: In step 1 , unplug the jacks by using the... on page 80 • "1120 DIMM slot cover and DIMM under keyboard for W701 and W701ds" on page 86 • "1130 Keyboard bezel and speaker assembly" on page ...88 Table 27. This slot also accepts a PCI Express Half Mini Card. 2 1 2 Step 2 Screw (quantity) M2 × 3 mm, thin-head, nylon-coated (2) 3 Color Silver Torque 0.181 Nm (1.85 kgfcm) Chapter 9. Removing and replacing...
...of PCI Express Mini Card for wireless LAN/WiMAX for W700 and W700ds For ThinkPad W700 and W700ds: In step 1 , unplug the jacks by using the... on page 80 • "1120 DIMM slot cover and DIMM under keyboard for W701 and W701ds" on page 86 • "1130 Keyboard bezel and speaker assembly" on page ...88 Table 27. This slot also accepts a PCI Express Half Mini Card. 2 1 2 Step 2 Screw (quantity) M2 × 3 mm, thin-head, nylon-coated (2) 3 Color Silver Torque 0.181 Nm (1.85 kgfcm) Chapter 9. Removing and replacing...
Hardware Maintenance Manual
Page 103
Removing and replacing a FRU 97 If the computer you are routed as shown in this figure. 1160 Intel Turbo Memory Minicard For access, remove these FRUs in the ... 80 • "1130 Keyboard bezel and speaker assembly" on the card. Table 28. Removal steps of PCI Express Mini Card for wireless LAN/WiMAX for ThinkPad W701 and W701ds (continued) When installing: • In models with wireless LAN card that the cables are servicing has three cables, put the white cable in order...
Removing and replacing a FRU 97 If the computer you are routed as shown in this figure. 1160 Intel Turbo Memory Minicard For access, remove these FRUs in the ... 80 • "1130 Keyboard bezel and speaker assembly" on the card. Table 28. Removal steps of PCI Express Mini Card for wireless LAN/WiMAX for ThinkPad W701 and W701ds (continued) When installing: • In models with wireless LAN card that the cables are servicing has three cables, put the white cable in order...
Hardware Maintenance Manual
Page 123
Removal steps of LCD unit for W701 and W701ds (continued) 5 5 6 7 6 5 5 Step 5 6 Screw (quantity) M2.5 × 9 mm, wafer-head, nylon-coated (4) M2 × 12 mm, wafer-head, nylon-coated (2) Step 9a is attached firmly. Chapter 9. Removing and replacing a FRU 117 Table 42. Color Black Black Torque 0.392 Nm (4 kgfcm) 0.181 Nm (1.85 kgfcm) 9 8 9 9a When installing: • Make sure that the cable connector 8 is attached firmly. • In ThinkPad W701ds, make sure that the cable connector 9a is only for ThinkPad W701ds.
Removal steps of LCD unit for W701 and W701ds (continued) 5 5 6 7 6 5 5 Step 5 6 Screw (quantity) M2.5 × 9 mm, wafer-head, nylon-coated (4) M2 × 12 mm, wafer-head, nylon-coated (2) Step 9a is attached firmly. Chapter 9. Removing and replacing a FRU 117 Table 42. Color Black Black Torque 0.392 Nm (4 kgfcm) 0.181 Nm (1.85 kgfcm) 9 8 9 9a When installing: • Make sure that the cable connector 8 is attached firmly. • In ThinkPad W701ds, make sure that the cable connector 9a is only for ThinkPad W701ds.
Hardware Maintenance Manual
Page 149
Table 55. Removal steps of second LCD cable assembly (for ThinkPad W700ds) (continued) 5 6 6 Table 56. Removing and replacing a FRU 143 Removal steps of second LCD cable assembly (for ThinkPad W701ds) For ThinkPad W701ds: Chapter 9.
Table 55. Removal steps of second LCD cable assembly (for ThinkPad W700ds) (continued) 5 6 6 Table 56. Removing and replacing a FRU 143 Removal steps of second LCD cable assembly (for ThinkPad W701ds) For ThinkPad W701ds: Chapter 9.
Hardware Maintenance Manual
Page 151
Table 56. Removal steps of second LCD cable assembly (for ThinkPad W701ds) (continued) 3 3 4 3 6 5 Step 3 4 Screw (quantity) M2.5 × 4.5 mm, wafer-head, nylon-coated (3) M2.5 × 7 mm, wafer-head, nylon-coated (1) Color Silver Silver Torque 0.392 Nm (4 kgfcm) 0.392 Nm (4 kgfcm) Chapter 9. Removing and replacing a FRU 145
Table 56. Removal steps of second LCD cable assembly (for ThinkPad W701ds) (continued) 3 3 4 3 6 5 Step 3 4 Screw (quantity) M2.5 × 4.5 mm, wafer-head, nylon-coated (3) M2.5 × 7 mm, wafer-head, nylon-coated (1) Color Silver Silver Torque 0.392 Nm (4 kgfcm) 0.392 Nm (4 kgfcm) Chapter 9. Removing and replacing a FRU 145