Hayward TriStar Support and Manuals
Get Help and Manuals for this Hayward item
View All Support Options Below
Free Hayward TriStar manuals!
Problems with Hayward TriStar?
Ask a Question
Free Hayward TriStar manuals!
Problems with Hayward TriStar?
Ask a Question
Most Recent Hayward TriStar Questions
How To Wire Capacitor In Hayward Tristar Pump
(Posted by docsouth8404 1 year ago)
How To Wire A Hayward Tristar Es Pool Pump
(Posted by olddgcr 9 years ago)
Heater Displays Lower Temperature Than Pool.heater Runs Constant
Heater reads 55 temp. Pool temp is 85
Heater reads 55 temp. Pool temp is 85
(Posted by scootergarrard 9 years ago)
How Pograme Time In Model Sp3220vsc Please Help Me Thank You
(Posted by joelvillanueva24 11 years ago)
O-ring Size
What is the size (dimensions) of the oring for the harward ecostar variable speed pool pump, 1Hp. T...
What is the size (dimensions) of the oring for the harward ecostar variable speed pool pump, 1Hp. T...
(Posted by jsniegowski1 11 years ago)
Hayward TriStar Videos
Universal TriStar VS Installation and Start-up
Duration: 13:46
Total Views: 1,204
Duration: 13:46
Total Views: 1,204
TriStar Pump Seal and Motor Replacement
Duration: 7:27
Total Views: 1,128
Duration: 7:27
Total Views: 1,128
Hayward TRIStar Electric Motor Switch Removal
Duration: 1:06
Total Views: 367
Duration: 1:06
Total Views: 367
Hayward Tristar Pump
Duration: 3:03
Total Views: 4,277
Duration: 3:03
Total Views: 4,277
Popular Hayward TriStar Manual Pages
All TriStar models - Page 1
... THIS INSTRUCTION MANUAL
HAYWARD POOL PRODUCTS
620 DIVISION STREET ELIZABETH, NJ 07207 (908) 351-5400 WWW.HAYWARDPOOL.COM TriStar Pump Replacement Guide
IMPORTANT - Full Rated
--SP3207EE SP3210EE SP3215EE SP3220EE SP3230EE
TriStar Model No.
To prevent potential injury and to avoid unnecessary service calls, read this manual carefully and completely. The Hayward TriStar Pump is specifically...
All TriStar models - Page 2
... for use on permanently installed swimming pools and may result in or on the equipment. Do NOT use with hot tubs
and spas if so marked. Do not install in conformance with all applicable local codes, regulations, and the
National Electric Code (NEC).
TriStar™ Pump Series
Page 2 of 15
IMPORTANT SAFETY INSTRUCTIONS
Before installing or servicing this product is designed...
All TriStar models - Page 3
... Hazard. WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Connect a No. 8 AWG (8.4 mm2) solid copper bonding wire to the pressure wire connector provided on the motor housing and to all metal parts of swimming pool, spa, or hot tub, and to reinforcing rod or mesh. Reference NEC codes for information on pump or motor, turn off power supply to near...
All TriStar models - Page 4
... new TriStar Pump's advanced fluid dynamic design optimizes the three essential pump elements to defined instructions will void warranty. Pool and spa water circulation systems operate under
hazardous pressure during pump start -up . Before servicing pool and spa water circulation system, all system and pump controls must be in off position and filter manual air relief valve must be set in...
All TriStar models - Page 5
...for outdoor use of 15
Product Specifications
HP ½ ¾ 1 1 * 1 ½ 1 ½ * 2 2 * 2 ** 2 ½ 2 ½ * 3 3 ** 5
FR "A" 13 5/8" 13 7/8" 14 3/8" 14 3/8" 14 7/8" 14 7/8" 14 7/8" 14 7/8" 13 1/2"
17 1/8" 14 1/2" 17 1/8"
MR "A" -
13 3/8" 13 7/8"
13 7/8" 14 3/8" 15 1/8" 14 7/8"
14 7/8" 14 7/8" 15 5/8"
-
* Two-Speed Pump ** Three-Phase Pump
Installation Instructions
WARNING - Pipe...
All TriStar models - Page 6
... will connect all applicable local codes,
regulations, and the National Electric Code (NEC). Connect a No. 8 AWG (8.4 mm2) solid copper bonding wire to the pressure wire connector provided on the motor housing and to all metal parts of swimming pool, spa, or hot tub, and to seal threaded connections on electrical connections.
Incorrectly installed and/or improperly tested filtration...
All TriStar models - Page 7
... same circuit, be used with all parts to add their amp loads before calculating wire and circuit breaker sizes. Immediately inspect all applicable local codes, regulations,
and the National Electric Code (NEC). May only be sure to verify they are
intact and functioning properly. Full Rate Pumps
Motor Specifications
Motor Brake Horsepower
HP (kW) 0.99 (0.74) 1.39 (1.04) 1.85...
All TriStar models - Page 8
... within five minutes, stop motor and determine cause. Failure to five (5) minutes. Failure to pool/spa system directly in severe personal injury.
See Troubleshooting Guide. WARNING - RELEASE ALL PRESSURE from pump and piping system using the filter manual air relief valve, before starting pump, see "Starting/Priming the Pump" instructions. Do NOT add chemicals...
All TriStar models - Page 9
... not purge the system with genuine Hayward seal assembly kit. To avoid condensation/corrosion problems, do not permit children to use water to hose off motor.
Gravity drain system as far as necessary.
Exercise extreme care in this manual for a long time (see instructions below all water from mounting pad, wiring (after power has been turned...
All TriStar models - Page 10
... of the seal plate (item #15). Replace the two diffuser screws (item #7). Rotate the impeller screw (item #10) clockwise (note that secure it firmly into the motor shaft in a clockwise direction, and screw the impeller screw (item #10) into the recess of this manual for pump component locations.)
12. Seal Installation (See Parts Diagram on page 11 of the...
All TriStar models - Page 11
No. TriStar™ Pump Series
Replacement Parts
Parts Diagram
Page 11 of 15
Detail of motor canopy with Drain Plugs, threaded style Strainer ... Impeller Screw Impeller Ring
Ctn. Qty. 1 1 1 10 10 10 15 1 10 1 1 1
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Parts Listing
Ref. Part No. 1 SPX3200UNKIT 2 SPX3200UG 3 SPX3200A 4 SPX3200DLS SPX3200DLSB 5 SPX3200S 6...
All TriStar models - Page 12
... pump installations. TriStar™ Pump Series
Page 12 of Pentair Water Pool & Spa, Inc., which are used with Hayward Pool Products. No. These are retrofit bases for 5 HP with Impeller Screw Shaft Seal Assembly Housing O-Ring Seal Plate Housing Insert/Seal Plate Spacer Kit Housing Bolt Motor Bolt Drain Plug with O-Ring Bracket, Motor Support, TriStar Base, Short Riser, TriStar...
All TriStar models - Page 13
... Instructions" in bubbles emanating from return fittings on suction side.
Reset tripped breakers or replace blown fuses. 2. NOTE: Your Hayward pump motor is lubricated with the wiring diagram on valves. Solution: Have a qualified repair professional open switches or relays; Empty pump/strainer housing.
ii. WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
All TriStar models - Page 14
... For Your Records)
DATE OF INSTALLATION INITIAL PRESSURE GAUGE READING (CLEAN FILTER PUMP MODEL HORSEPOWER FILTER MODEL SERIAL NUMBER
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Plugged or restricted discharge line of 15
Low Flow - Cartridge filters - Inspect other plumbing connections and tighten as per manufacturer's instructions;
Holding hand over return...
All TriStar models - Page 15
... replacements or repair, defective components or parts should be responsible for a period of ONE (1) year from the date of Pool
Years pool has been in service □ less than 1 □ 1-3 □ 3-5 □ 5-10
Purchased from state to the nearest authorized Hayward service center.
This warranty gives you specific legal rights, and you .
For further Hayward dealer or service...
Hayward TriStar Reviews
We have not received any reviews for Hayward yet.