Hayward TriStar Support Question
Hayward TriStar Support Question
Find answers below for this question about Hayward TriStar.Need a Hayward TriStar manual? We have 1 online manual for this item!
Question posted by scootergarrard on May 20th, 2014
Heater Displays Lower Temperature Than Pool.heater Runs Constant
Heater reads 55 temp. Pool temp is 85
Current Answers
Related Hayward TriStar Manual Pages
All TriStar models - Page 1
... in-ground swimming pool/spa that is equipped with a lower horsepower rating than the existing pump. NOTE - Max Rated SP3207X10 SP3210X15 SP3215X20 SP3220X25 SP3225X30
--- The Hayward TriStar Pump is a ...calls, read this manual carefully and completely. When replacing most existing pumps, you can use a TriStar pump with large capacity filters, heaters, and pool cleaning equipment. TriStar Pump ...
All TriStar models - Page 2
TriStar.... Pool and spa components have a finite life. Read and... follow instructions may result in a damp or non-ventilated location. CAUTION - WARNING - This is strongly advised to protect the electrical components from using them as the filtration system, pumps, and heaters must be alert to prevent children from the weather. FAILURE TO READ...
All TriStar models - Page 3
TriStar™ Pump Series
Page 3 of electric shock, do NOT use pool or spa if any suction outlet component is damaged, broken, cracked, missing, or..., swimsuits, hair decorations, fingers, toes, or knuckles to near point to be blocked by a user. - Run a continuous wire from near point. - IMPORTANT -
Provide a properly located electrical receptacle. To reduce the risk ...
All TriStar models - Page 4
...pool. Failure to minimize the risk for at least 20 minutes prior to maintenance to do so could cause property damage, severe personal injury, or death. Never operate or test the circulation system at high temperatures...flow, energy efficiency, and quietness. TriStar has a variety of dependability. ...not operate pool and spa circulation system if a system component is running.
WARNING...
All TriStar models - Page 5
...location.
Suction lines should be tight (but not over-tightened).
Keep motor clean.
TriStar™ Pump Series
Page 5 of air for cooling. Pump Location
Locate pump as...
3" [90] 160 [600]
15"
* NOTE - Suction line diameter must be as close to pool as practical and run suction lines as direct as "L" in line. Pump Mounting
Install pump on a level concrete slab or ...
All TriStar models - Page 6
... Officials (IAPMO) standards. Pool and spa fittings MUST conform to electrical service ground.
use Plumber's Pipe Dope as friction is running at least two suction outlets... threaded connections on molded plastic components.
Hazardous Pressure. Plumbing
Use Teflon tape to pool structure. TriStar™ Pump Series Pump Mounting (cont'd.)
Page 6 of the plastic components. ...
All TriStar models - Page 7
...50 psi (345 kPa) at a water temperature no longer than 100° F (38...Run pressure test for this test. ...0.94 (0.70) 1.25 (0.93) 1.65 (1.23) 2.20 (1.64) 2.60 (1.94) 3.45 (2.57) 1.85 / 0.22 (1.38 / 0.16) 2.40 / 0.28 (1.79 / 0.21) 2.70 / 0.33 (2.01 /...Pump - Ensure all pump and system components are
intact and functioning properly.
TriStar™ Pump Series
Page 7 of water (not air or air and ...
All TriStar models - Page 8
...when starting motor. See Troubleshooting Guide. TriStar™ Pump Series Prior to pool/spa system directly in front of pump suction. Failure to suction pipe level. NEVER run pump dry. Fill strainer housing with ...air relief valve when a steady stream of water (not air or air
and water) is lower than the pump, pump will depend on vertical length of suction lift and horizontal length of ...
All TriStar models - Page 9
...will not damage plastic system components; Failure to the pool. 2. B.
TriStar™ Pump Series
Page 9 of water, re-install... Seal Change Instructions
IMPORTANT SAFETY INSTRUCTIONS PLEASE READ AND FOLLOW ALL INSTRUCTIONS
When servicing electrical ...pump from pump and piping when expecting freezing temperatures or when storing pump for pump component locations...pool/spa system.
All TriStar models - Page 10
TriStar™ Pump Series
Page 10 of 15
Shaft Seal Change Instructions (cont'd.)
Removing the Motor Assembly (See Parts Diagram on page 11 of the seal ...
All TriStar models - Page 11
TriStar™ Pump Series
Replacement Parts
Parts Diagram
Page 11 of 15
Detail of motor canopy with Drain Plugs, threaded style Strainer Cover Kit (Includes Strainer ...
All TriStar models - Page 12
... Bolt Drain Plug with Hayward Pool Products. are not affiliated with O-Ring Bracket, Motor Support, TriStar Base, Short Riser, TriStar Base, Tall Riser, TriStar
Ctn. No. Part No...) Impeller for 3 HP with SP3220VSC.)
* STA-RITE is a registered trademark of Pentair Water Pool & Spa, Inc., which are retrofit bases for existing STA-RITE and WHISPERFLO pump installations. and WHISPERFLO is...
All TriStar models - Page 13
...power drop (frequently caused by removing the skimmer basket and holding your pool dealer can build up causing windings to check by undersized wiring or ...replace valves. 4. You may be certain it is filled with skimmer full and pump running. If no suction is clean. Manually check rotation of "Shaft Seal Change Instructions".... TriStar™ Pump Series
Page 13 of overheating.
All TriStar models - Page 14
..., cavitations caused by restricted or undersized suction line or leak at once.
© Hayward Pool Products, 2005 All rights reserved. Generally, Check For: (cont'd.)
2. Inspect other plumbing... and secure the pump to improper mounting, etc. TriStar™ Pump Series
Page 14 of filter, valve partially closed (high gauge reading). Solution: Sand filters - backwash as per manufacturer's...
All TriStar models - Page 15
...(1) year from Hayward:
□ Pump □ Filter □ Automatic Pool Cleaner □ Light □ Chlorinator □ Skimmer □ Heater □ Heat Pump □ Salt/Chlorine Generator □ Controls
WWW....do not allow a limitation on these other products from the date of purchase.
TriStar™ Pump Series
Page 15 of 15
HAYWARD® LIMITED WARRANTY
This pump...
Similar Questions
How Do I Make My Hpump Run Continuously For 24 Hr To Distribute A Chemical?
I need to distribute a chemical for the pool that requires the pump run constantly for 24 hours. I d...
I need to distribute a chemical for the pool that requires the pump run constantly for 24 hours. I d...
(Posted by bh2522 1 year ago)
No Deplay On Panel Did Get Pool To Run Not Sure If The System Is Working Right
(Posted by nheimbach 10 years ago)
O-ring Size
What is the size (dimensions) of the oring for the harward ecostar variable speed pool pump, 1Hp. T...
What is the size (dimensions) of the oring for the harward ecostar variable speed pool pump, 1Hp. T...
(Posted by jsniegowski1 11 years ago)