AL1515 LCD Monitor Service Guide
Page 2
...this guide is ". Pentium and Pentium II/III are trademarks and/or registered trademarks of their purchase, the buyer (and not Acer Incorporated, its distributor, of its dealer) assumes the entire cost of all necessary servicing, repair, and any incidental or consequential ...in the software. Copyright Copyright © 2003 by any particular purpose, Any Acer Incorporated software described in this manual is sold or licensed "as is subject to the contents hereof and specifically disclaims any warranties of merchantability or fitness for any means, electronic, mechanical, magnetic...
...this guide is ". Pentium and Pentium II/III are trademarks and/or registered trademarks of their purchase, the buyer (and not Acer Incorporated, its distributor, of its dealer) assumes the entire cost of all necessary servicing, repair, and any incidental or consequential ...in the software. Copyright Copyright © 2003 by any particular purpose, Any Acer Incorporated software described in this manual is sold or licensed "as is subject to the contents hereof and specifically disclaims any warranties of merchantability or fitness for any means, electronic, mechanical, magnetic...
AL1515 LCD Monitor Service Guide
Page 3
... relevant to any damage that might result from doing or not doing specific actions. Caution Gives precautionary measures to avoid possible hardware or software problems. Important Reminds you to the accomplishment of procedures. please not WHEN ..., please read the following conventions are used in this generic service guide. To better fit local market requirements and enhance product competitiveness, your regional Acer office to provide you with further technical details. 2. These LOCALIZED FEATURES will not be covered in the FRU list of additional information related to ...
... relevant to any damage that might result from doing or not doing specific actions. Caution Gives precautionary measures to avoid possible hardware or software problems. Important Reminds you to the accomplishment of procedures. please not WHEN ..., please read the following conventions are used in this generic service guide. To better fit local market requirements and enhance product competitiveness, your regional Acer office to provide you with further technical details. 2. These LOCALIZED FEATURES will not be covered in the FRU list of additional information related to ...
AL1515 LCD Monitor Service Guide
Page 7
...MONITOR BOARD LAYOUT ...16 SOFTWARE FLOW CHART ...17 GENERAL INSTRUCTIONS ...18 SYSTEM INSTALLATION ...19 POWER BOARD...24 ELECTRICAL SPECIFICATION...25 INVERTER ELECTRICAL SPECIFICATION ...26 SAFETY ...28 Chapter 2 Operating Instruction 30 CONTROLS ...30 MAIN OSD MENU...31 OSD MESSAGE...33 PLUG... AND PLAY ...35 WHITE COLOR TEMPERATURE...36 AUDIO TECHNICAL SPECIFICATION (FOR AL1515 m ONLY 36 SPEAKERS ...37 Chapter 3 Machine Disassembly and Replacement 38 DISASSEMBLY PROCEDURE ...38 Chapter 4 Troubleshooting 41 TROUBLESHOOTING ...
...MONITOR BOARD LAYOUT ...16 SOFTWARE FLOW CHART ...17 GENERAL INSTRUCTIONS ...18 SYSTEM INSTALLATION ...19 POWER BOARD...24 ELECTRICAL SPECIFICATION...25 INVERTER ELECTRICAL SPECIFICATION ...26 SAFETY ...28 Chapter 2 Operating Instruction 30 CONTROLS ...30 MAIN OSD MENU...31 OSD MESSAGE...33 PLUG... AND PLAY ...35 WHITE COLOR TEMPERATURE...36 AUDIO TECHNICAL SPECIFICATION (FOR AL1515 m ONLY 36 SPEAKERS ...37 Chapter 3 Machine Disassembly and Replacement 38 DISASSEMBLY PROCEDURE ...38 Chapter 4 Troubleshooting 41 TROUBLESHOOTING ...
AL1515 LCD Monitor Service Guide
Page 8
... speakers. Description The LCD monitor is also a space saving design, allowing more . - 8 - This will alleviate the growing health concerns. Monitor Feature INTRODUCTION Chapter 1 Scope This specification defines the requirements for the 15" high resolution color LCD monitor. This monitor can be directly connected to drive a pair of optional special display card...
... speakers. Description The LCD monitor is also a space saving design, allowing more . - 8 - This will alleviate the growing health concerns. Monitor Feature INTRODUCTION Chapter 1 Scope This specification defines the requirements for the 15" high resolution color LCD monitor. This monitor can be directly connected to drive a pair of optional special display card...
AL1515 LCD Monitor Service Guide
Page 9
... temperature: 20 ± 5 ˚C ( 68 ± 9 ˚ F) Analog input mode: 1024 x768 /60 Hz MEASUREMENT SYSTEMS The units of LCD panel Warrn up time All specifications : 30 minutes Fully functional : 5 seconds Measuring Equipment : Chroma 2250 signal generator or equivalent, directly Connected to the monitor under the following conditions, unless otherwise specified...
... temperature: 20 ± 5 ˚C ( 68 ± 9 ˚ F) Analog input mode: 1024 x768 /60 Hz MEASUREMENT SYSTEMS The units of LCD panel Warrn up time All specifications : 30 minutes Fully functional : 5 seconds Measuring Equipment : Chroma 2250 signal generator or equivalent, directly Connected to the monitor under the following conditions, unless otherwise specified...
AL1515 LCD Monitor Service Guide
Page 10
LCD monitor General specification Panel Type: 15 " active matrix color TFT LCD LCD Panel Type Size Display Type Resolution Display Dot Display color Brightness Contrast Ratio Response Time Lamp ... Sync: TTL positive or negative Signal connector: 15 pin Mini D type, (standard VGA video) 3.5 mm stereo audio jack (Audio) (For AL1515 m only) Audio power: 0.5Wrms + 0.5Wrms (300Hz - 10kHz (S.P.L. - 10 dB))(AL1515 m only) Front control: power on/off with LED select adjustment (+,-) Interface frequency Horizontal Frequency 24KHz --61KHz Vertical Frequency 56Hz ------75Hz Plug...
LCD monitor General specification Panel Type: 15 " active matrix color TFT LCD LCD Panel Type Size Display Type Resolution Display Dot Display color Brightness Contrast Ratio Response Time Lamp ... Sync: TTL positive or negative Signal connector: 15 pin Mini D type, (standard VGA video) 3.5 mm stereo audio jack (Audio) (For AL1515 m only) Audio power: 0.5Wrms + 0.5Wrms (300Hz - 10kHz (S.P.L. - 10 dB))(AL1515 m only) Front control: power on/off with LED select adjustment (+,-) Interface frequency Horizontal Frequency 24KHz --61KHz Vertical Frequency 56Hz ------75Hz Plug...
AL1515 LCD Monitor Service Guide
Page 20
Top and Bottom Back cover & Bezel concavity 0.8mm ≤ A ≤ 1.3 mm Left and Right Back cover & Bezel concavity 0.8mm ≤ A ≤ 1.3 mm Back Cover & Hinge Cover concavity 0mm ≤ B ≤ 0.5mm - 20 - The step between front bezel and back cover shall be within specification.
Top and Bottom Back cover & Bezel concavity 0.8mm ≤ A ≤ 1.3 mm Left and Right Back cover & Bezel concavity 0.8mm ≤ A ≤ 1.3 mm Back Cover & Hinge Cover concavity 0mm ≤ B ≤ 0.5mm - 20 - The step between front bezel and back cover shall be within specification.
AL1515 LCD Monitor Service Guide
Page 24
..., SCP. Interface Signals Input 1. AC Inlet: HUAJIE SA-4S-066 or compatible. The connecter was pitch 2.0mm, cable length was 125mm. POWER BOARD Description This specification defined the performance and characteristic for the VP-589 power board.
..., SCP. Interface Signals Input 1. AC Inlet: HUAJIE SA-4S-066 or compatible. The connecter was pitch 2.0mm, cable length was 125mm. POWER BOARD Description This specification defined the performance and characteristic for the VP-589 power board.
AL1515 LCD Monitor Service Guide
Page 25
...Dynamic Load Regulation --- Typ. Max. are paralleled with a 10uf Ecap &0.1uf Ceramic cap. 2.Band width is limited --- Electrical Specification: AC-DC Electrical specification Input Specification No Item 1 Input Voltage Condition ----- Unit 100 --- 240 Vac 2 Input Frequency ----- 47 --- 63 Hz 3 Input Current...Hold Up Time 10 --- --- Type load 6 Turn on /off (keep over 1 hour) and Ta=25 degree C AC-DC Output Specification Output Voltage Tolerance --- within 20MHz. 50~100% or 100~50% load change of 1MHz (min.) 1.5A 1% 3% ±5% 11.4~15Vdc...
...Dynamic Load Regulation --- Typ. Max. are paralleled with a 10uf Ecap &0.1uf Ceramic cap. 2.Band width is limited --- Electrical Specification: AC-DC Electrical specification Input Specification No Item 1 Input Voltage Condition ----- Unit 100 --- 240 Vac 2 Input Frequency ----- 47 --- 63 Hz 3 Input Current...Hold Up Time 10 --- --- Type load 6 Turn on /off (keep over 1 hour) and Ta=25 degree C AC-DC Output Specification Output Voltage Tolerance --- within 20MHz. 50~100% or 100~50% load change of 1MHz (min.) 1.5A 1% 3% ±5% 11.4~15Vdc...
AL1515 LCD Monitor Service Guide
Page 26
...) Vbri=0.5~3.2V 3 6.5 7 mA Frequency --- 40 50 70 Open Lamp Voltage --- 1350 --- --- Operating Life Time --- 30000 --- --- *.The open lamp voltage is within 40W ~ 70W Inverter Electrical Specification: For Hannstar HSD 150SX84-D Condition Min. Input Voltage --- --- 12 Input Current --- --- 1.0 Backlight ON/OFF Control ON 0 OFF 2.0 3.0 Brightness Adjust (Lamp Current Control) Min. Unit --- KHz...
...) Vbri=0.5~3.2V 3 6.5 7 mA Frequency --- 40 50 70 Open Lamp Voltage --- 1350 --- --- Operating Life Time --- 30000 --- --- *.The open lamp voltage is within 40W ~ 70W Inverter Electrical Specification: For Hannstar HSD 150SX84-D Condition Min. Input Voltage --- --- 12 Input Current --- --- 1.0 Backlight ON/OFF Control ON 0 OFF 2.0 3.0 Brightness Adjust (Lamp Current Control) Min. Unit --- KHz...
AL1515 LCD Monitor Service Guide
Page 36
... as 9300, 7500,6500 and User, Default value of user color should follow "Microsoft Windows Color Quality Specification for Liquid Crystal Display OEM's". (http://www.microsoft.com/hwdev/tech/color/ColorTest.asp) Audio Technical specification (For AL1515 m only) General Description: Output power Total harmonic distortion Input signal sensitivity Input impedance Frequency response range...
... as 9300, 7500,6500 and User, Default value of user color should follow "Microsoft Windows Color Quality Specification for Liquid Crystal Display OEM's". (http://www.microsoft.com/hwdev/tech/color/ColorTest.asp) Audio Technical specification (For AL1515 m only) General Description: Output power Total harmonic distortion Input signal sensitivity Input impedance Frequency response range...
AL1515 User's Guide
Page 1
... 4 Viewing Angle Adjustment...4 Detaching LCD Monitor from Its Stand 5 Interface for Arm Applications ...5 Connecting the Display ...5 Connecting the AC Power...5 Connecting the Audio Cable (For AL1515 m and AL1515 bm 6 Power Management System ...6 Chapter 2 Display Controls 7 General Instructions ...7 Front Panel Control...8 How To Adjust A Setting...9 Adjusting The Picture ...9 Chapter 3 Technical Information 11...
... 4 Viewing Angle Adjustment...4 Detaching LCD Monitor from Its Stand 5 Interface for Arm Applications ...5 Connecting the Display ...5 Connecting the AC Power...5 Connecting the Audio Cable (For AL1515 m and AL1515 bm 6 Power Management System ...6 Chapter 2 Display Controls 7 General Instructions ...7 Front Panel Control...8 How To Adjust A Setting...9 Adjusting The Picture ...9 Chapter 3 Technical Information 11...
AL1515 User's Guide
Page 5
..., 0.7 pitches threaded nuts, as well as four 5 mm access holes in the plastic covering as illustrated in Figure 1-4. Connect the power cord to Fig.1-3. These specifications meet the VESA Flat Panel Monitor Physical Mounting Interface Standard (paragraphs 2.1 and 2.1.3, version 1, dated 13 November 1997). Interface for Arm Applications Before installing to mounting...
..., 0.7 pitches threaded nuts, as well as four 5 mm access holes in the plastic covering as illustrated in Figure 1-4. Connect the power cord to Fig.1-3. These specifications meet the VESA Flat Panel Monitor Physical Mounting Interface Standard (paragraphs 2.1 and 2.1.3, version 1, dated 13 November 1997). Interface for Arm Applications Before installing to mounting...
AL1515 User's Guide
Page 11
Chapter 3 Technical Information Specifications LCD Panel Size Display Type Resolution Display Dot Display Area (mm)(H x V) Display Color Brightness Contrast Ratio Response Time Lamp Voltage Lamp Current Viewing Angle 15" (...; 2% Positive, Negative 0 - 0.7 ± 0.05 Vp Horizontal Frequency: 24 ~ 60 KHz Vertical Frequency: 49 ~ 75 Hz Control Power switch On/Off switch with LED indicator Audio (AL1515 m/AL1515 bm) Input 500mVrms Output 1W+1W OSD Brightness Contrast Horizontal Position Vertical Position Phase Clock Display Mode Setup Digital Digital Digital Digital Digital Digital Use...
Chapter 3 Technical Information Specifications LCD Panel Size Display Type Resolution Display Dot Display Area (mm)(H x V) Display Color Brightness Contrast Ratio Response Time Lamp Voltage Lamp Current Viewing Angle 15" (...; 2% Positive, Negative 0 - 0.7 ± 0.05 Vp Horizontal Frequency: 24 ~ 60 KHz Vertical Frequency: 49 ~ 75 Hz Control Power switch On/Off switch with LED indicator Audio (AL1515 m/AL1515 bm) Input 500mVrms Output 1W+1W OSD Brightness Contrast Horizontal Position Vertical Position Phase Clock Display Mode Setup Digital Digital Digital Digital Digital Digital Use...
AL1515 User's Guide
Page 15
... is no picture on LCD Monitor If there's no picture on timing. 2. Attention This LCD Monitor Supports Multiple VGA Modes. In Windows XP open the specific application where the problems appear. 2. Refer to see if there's any black vertical stripes appear. If there is supported by this LCD Monitor. Refer to...
... is no picture on LCD Monitor If there's no picture on timing. 2. Attention This LCD Monitor Supports Multiple VGA Modes. In Windows XP open the specific application where the problems appear. 2. Refer to see if there's any black vertical stripes appear. If there is supported by this LCD Monitor. Refer to...