Rheem Versa Heaters Support and Manuals
Get Help and Manuals for this Rheem item
This item is in your list!
View All Support Options Below
Free Rheem Versa Heaters manuals!
Problems with Rheem Versa Heaters?
Ask a Question
Free Rheem Versa Heaters manuals!
Problems with Rheem Versa Heaters?
Ask a Question
Popular Rheem Versa Heaters Manual Pages
Operating Instructions - Page 3
... Model Identification Specifications Unpacking INSTALLATION Installation Codes Clearances Base Installation Outdoor Installation Indoor Installation Combustion & Ventilation Air Gas Connections Water Connections Electrical Connections Control Adjustments-Millivolt Wiring Diagrams Post Start-Up Inspection Cold Weather Operation
CONTENTS
4 MAINTENANCE
21
4 SERVICE
21
5 Water Pressure...
Operating Instructions - Page 4
..., personal injury or loss of natural gas or propane, ask your local gas supplier. Strong air intake from carbon monoxide, never operate this manual can disturb the combustion process and cause damage or personal injury. WARNING: The heater shall not be able to personal injury hazards. NOTE:
Indicates special instructions on indoor installation and properly vent the...
Operating Instructions - Page 5
...**
*Free Chlorine MUST NOT EXCEED 5 ppm! ** In salt water chlorinated pools, the total TDS can be as high as a guide for your health and the protection of the pool or spa water should be chemically balanced.
If the pH drops below 7.2, this will cause corrosion of the heater and have an anti-siphoning device to prevent...
Operating Instructions - Page 6
... any problems understanding the warnings and instructions in this Installation and Operation Manual. Consumer Product Safety Commission has these guidelines:
first three months of pregnancy resulting in accordance with this manual, STOP, and get help from a qualified installer, service technician, or the gas supplier. Special caution is considered safe for a healthy adult. Soaking in water...
Operating Instructions - Page 7
.... Fig. 2: Location of installation. When ordering under warranty conditions, specify the date of Heater Rating Plate
Claims for defective replacement parts will not be accepted and will void the warranty. Records of Components
• Millivolt heater +32°F to +175°F • Electronic heater only -40°F to +175°F
Model Identification
Specifications
Model No. Debits for...
Operating Instructions - Page 11
...
Fig. 7: Outdoor Installation Clearances
and inspection.
Use soapy water for maintenance
CAUTION: The heater and its gas connections shall be tested after installation in operation.
CAN/CSAB149). CAUTION: Do not use open flame.
11 The heater and its manual shut-off valve located outside the heater jacket. All gas piping should be adequately supported to this heater. do not use...
Operating Instructions - Page 12
...10.5 in . WC
11 in . Table D: Gas Pressure
A.
WC
13 in . Gas Pressure* Natural Gas Propane Gas
Max.
Fig. 10B: Robertshaw MV Gas Valve
Gas Pressure Adjustment
C. Fig. 10A: Honeywell DSI VR 8205 Gas Valve
Gas Pressure Adjustment
B. WC
10 in . Fig. 10C: Honeywell MV Gas Valve
12 Inlet (dynamic)
7 in . WC
*Static means without heater operating, dynamic refers to decrease...
Operating Instructions - Page 13
... Valve section for Gas Connections
Model Input 1/2 in. 3/4 in series.
13
Drain Plug
Fig. 12: In/Out Header for 2" Installation
In/Out Header Hose Connector Hose
Fig. 13: Optional In/Out Header for 1-1/2" or 1-1/4" Hose Connection NP
130A 130 15 35 60 145 200 500
• Natural Gas 1000 BTU/FT3 0.60 Specific Gravity @ 0.5 in . WC...
Operating Instructions - Page 15
... directly from the GFCI power source.
Canadian Electrical Code, CSA C22.1, Part 1 and Part 2.)
Be sure that waterways are clear. See Figures 19 and 20 for heat. wiring errors can be supplied from the load (pump) side of wiring from the valve. Electronic Heaters
WARNING: To avoid water damage or scalding due to relief valve operation...
Operating Instructions - Page 18
... not use tools. Replace heater door panel.
18
Use only your hand to the appli-
D.
Turn off all the electrical power to push in a fire or explosion. do not try to light any appliance. *Do not touch any part has been under water. OPERATING INSTRUCTIONS
1. If you don't smell gas, go to repair it. Do not try...
Operating Instructions - Page 21
... these occur, shut the heater off gas valve, manual gas valve, and electrical supply to ensure adequate flow of the spa or pool, it before re-installing. Fig. 26: Water Pressure Switch Adjustment
1. SERVICE
Water Pressure Switch
In/Out Header Drain Plug
Fig. 25: In/Out Header Drain Plug Location
3. When the heater is factory set at 1.75 PSI for the...
Operating Instructions - Page 22
... main electrical power switch to heater. 2. Both are set to the lighting instructions provided on high limit.
Shut off on the heater label.
Remove In/Out inspection panel. 3. Refer to open at high speed when heating the water.
A flow switch, mounted and wired adjacent to the heater, may be manually re-lighted to Troubleshooting section. CAUTION: Do not...
Operating Instructions - Page 27
... specifically trained and experienced in the installation of chlorinator and backflow preventer.
Over chlorination Check location of this equipment nor attempt repairs according to installation instructions. Inspect bypass for use by adding manual bypass valve. Clean burners. Refer to these instructions. Flush system and clean. Raise water level.
Clean filter. TROUBLESHOOTING...
Operating Instructions - Page 28
... fires, remove jumper
Replace thermostat
If main burner does NOT fire... Also check for temporary check only. Relight pilot
If pilot burner does not light
Check gas supply, gas line size, gas pressure. Jump across both "TH" wires on with adequate water flow through heater. 2. Gas valve must be in "ON" position. Thermostat set higher than pool water temperature. 3. Electrical...
Brochure - Page 2
... ratings. Electronic ignition models only
• Electronic Ignition Rheem electronic ignition heaters come standard with 3-prong plug. Suffix "X" is for a completely nonferrous waterway, leaving your pool truly rust-free.
• 2" Water Connections Supplied with every Rheem heater is a set your pool or spa temperature precisely at your installation secure and effortless.
•...
Rheem Versa Heaters Reviews
Do you have an experience with the Rheem Versa Heaters that you would like to share?
Earn 750 points for your review!
We have not received any reviews for Rheem yet.
Earn 750 points for your review!