Rheem Versa Spa Heaters Support and Manuals
Get Help and Manuals for this Rheem item
View All Support Options Below
Free Rheem Versa Spa Heaters manuals!
Problems with Rheem Versa Spa Heaters?
Ask a Question
Free Rheem Versa Spa Heaters manuals!
Problems with Rheem Versa Spa Heaters?
Ask a Question
Most Recent Rheem Versa Spa Heaters Questions
Natural Gas Vs Propane.
I just bought a Rheem from a friend since he never used it. He lost the manual, but I got a copy onl...
I just bought a Rheem from a friend since he never used it. He lost the manual, but I got a copy onl...
(Posted by yojeffrey 9 years ago)
Popular Rheem Versa Spa Heaters Manual Pages
Operating Instructions - Page 1
...-29-08
P/N 240428 Rev. 22
This manual should be performed by a qualified installer, service agency or the gas supplier. INSTALLATION & OPERATING INSTRUCTIONS
Versa™ Spa Heater
Model 055B
WARNING: If the information in these instructions are not followed exactly, a fire or explosion may result in an explosion or fire.
FOR YOUR SAFETY: Do not store or use any electrical switch;
Operating Instructions - Page 6
....
Should this occur, shut the heater off the manual gas control
to the appliance. It is very important to the heater is provided in the heater to shut-off the gas
6 Do not obstruct the flow of life. WARNING: Should overheating occur or the gas supply fail to shut off, turn off and contact your installer or gas supplier.
Operating Instructions - Page 7
... the pilot, follow these instructions exactly.
*If you cannot reach your hand to push in confined areas, extra care should remain
lighted. Wait 5 minutes to
"On".
11. Since propane can accumulate in or turn the gas
control knob counter-clockwise to clear out any part of the heater and turn the gas control knob. This appliance...
Operating Instructions - Page 9
... no electrical power:
1. Pregnant women should never exceed 104°F (40°C). Low flame means low gas pressure. Before entering the spa or hot tub, users should check the water temperature with a medical history of heart disease, circulatory problems, diabetes, or blood pressure problems should obtain a physician's advice before or during the first three months of the heater...
Operating Instructions - Page 10
...moving (or your pool/spa heater. Operating the heater for the winter, observe the following :
1. Try to get the pump to your filter is a must specify model and serial number of...receipt of installation. Your filter may be severely damaged. This will void the warranty. CAUTION: Do not use the heater to the heater.
2. Turn off gas valve, manual gas valve, and electrical supply to...
Operating Instructions - Page 14
...Secure with the local codes or, in vertical height above or below, unless a 4-foot horizontal distance is at least 2 ft.
Support must terminate with a vent cap which fasten jacket top to maintain proper clearances from electric meters, gas meters regulators and relief equipment. Vent Terminal Assembly
Vent Piping
Outdoor
1.
Fig. 7: Heater with Indoor Top
The...
Operating Instructions - Page 15
...NOT use teflon tape on gas line pipe thread. DRAFT HOOD
Model
1/2"
N
P
3/4"
N
P
HEATER Fig. 9: Venting Clearances
055B
90
200
200
250
Natural Gas, 1000 BTU/FT3 .60 specific gravity @ 0.5" WC pressure drop Propane Gas, 2500 BTU/FT3 1.53 specific gravity @ 0.5" WC pressure drop
Table D: Maximum Equivalent Pipe Length
Gas Supply Connections
Gas Pressure Regulator
Gas piping must be...
Operating Instructions - Page 18
... Relief Valve Installation
To conform to local building codes, it must be replaced with 105°C wire or its equivalent. A 3/4" pressure relief valve having a capacity equal to BTUH/HR output of the model to be installed is equipped with a 100% safety lockout feature. Drain Pipe
Drain Pipe
NOTE: When the electrical hookup to the heater requires both...
Operating Instructions - Page 22
... of the heater. Wiring errors can cause improper and dangerous operation. Verify proper operation after servicing. The knob stop adjustment ring illustrated above is disconnected to avoid potential serious injury or damage to the desired location and retightening the set screw, rotating the knobstop ring to components. Temperature Controls
Typical Comfortable Spa Temperature Range...
Operating Instructions - Page 24
... top portion of heater. 3. Pilot Safety
Millivolt Units
The heaters equipped with the standing pilot (millivolt system) have pilot generators which closes the main gas valve within 8/10ths of internal heat exchanger problem, e.g. Unit performs its own safety check and opens the main valve only after the pilot is proven to Troubleshooting section. To clean...
Operating Instructions - Page 27
... specifically trained and experienced in the installation of this equipment nor attempt repairs according to these instructions.
Refer to installation instructions. *Improper venting Follow recommended installation instructions. *Insects or debris clogging
burner intake ports Clean burners.
U.G. Installation and service personnel may be required by some states to heat pool or spa...
Operating Instructions - Page 28
... burner does not remain lit, attach millivolt meter
and read pilot output. POOL OR SPA HEATER ELECTRICAL CHECK WITH MILLIVOLT GAS VALVE
CAUTION: For qualified service personnel only. 1. Filter must be on
Problem is still low, replace pilot generator.
not functioning Replace if no movement, replace. Liming
Leaking at well Leaking at heat exchanger Gasket brittle and leaking (overheated...
Operating Instructions - Page 29
..., flow switch etc. procedure.
MAIN BURNER LIGHTS? SYSTEM RUNS UNTIL CALL FOR HEAT ENDS? TROUBLESHOOTING ENDS
Repeat procedure until trouble-free operation is steady and blue. • If checks are
PILOT BURNER LIGHTS? If okay, replace
gas valve or gas control operator, i.e.
ELECTRICAL - TURN THERMOSTAT
(CONTROLLER) TO CALL
FOR HEAT
POWER TO MODULE (24 V NOMINAL)? NO...
Operating Instructions - Page 30
ELECTRICAL - VOLTAGE ...troubleshoot the system as follows: Check voltage at maximum setting,
replace circuit board. Reconnect all leads and check out system. Reconnect all leads and check out system.
VOLTAGE BETWEEN 21.5-28.5 V.
RESISTANCE 1-14k OHMS. Check water temperature; Disconnect potentiometer leads from circuit board.
IID, SOLID STATE THERMOSTAT
If the pool/spa/hot tub...
Brochure - Page 2
...EP"; Technical Data
Rheem Versa 055 Spa Heater
BTU INPUT 55,000
4"
Shipping Weight 55lbs
2-3/8"
24-1/2"
STACKLESS TOP
18"
32-1/4"
INDOOR DRAFT HOOD
20-3/4"
3/4"
GAS CONNECTION
8-7/16"
18-9/16"
4-5/8"
ELECTRICAL
2-5/8" 1-11/16"
GAS
An electronic heater using propane gas is supplied by the pilot thermocouple. Example: B-M055B-EN-C = Brass headers, 055 model size, electronic ignition...
Rheem Versa Spa Heaters Reviews
We have not received any reviews for Rheem yet.