Hayward W3AQ-TROL-RJ Support and Manuals
Get Help and Manuals for this Hayward item
View All Support Options Below
Free Hayward W3AQ-TROL-RJ manuals!
Problems with Hayward W3AQ-TROL-RJ?
Ask a Question
Free Hayward W3AQ-TROL-RJ manuals!
Problems with Hayward W3AQ-TROL-RJ?
Ask a Question
Hayward W3AQ-TROL-RJ Videos
Hayward W3AQ-TROL-RJ AquaTrol Salt Chlorination System for Above-Ground Pools up to 18,000 Gallons
Duration: 2:24
Total Views: 11
Duration: 2:24
Total Views: 11
Popular Hayward W3AQ-TROL-RJ Manual Pages
AquaTrol-Above-Ground-Chlorine-Generator-Owners-Manual-092745RevB - Page 1
092745 RevB
AquaTrol®
Above Ground Pool Chlorine Generator
Owner's Manual
Contents
Introduction 1 Water Chemistry 2 Controls 7 Installation 9 Troubleshooting............13 W3AQ-TROL-RJ W3AQ-TROL-RJ-TL W3AQ-TROL-HP W3AQ-TROL-HP-TL
Hayward Pool Products 620 Division Street, Elizabeth NJ 07207
Phone (908)-355-7995 www.hayward.com
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
AquaTrol-Above-Ground-Chlorine-Generator-Owners-Manual-092745RevB - Page 2
...in size to use this
product unless they are closely supervised at all AC power during installation.
•
Warning - It is to use a control product under unsafe conditions.
•
SAVE THESE INSTRUCTIONS
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS IMPORTANT SAFETY INSTRUCTIONS
When using this electrical equipment, basic safety precautions should always be followed, including the...
AquaTrol-Above-Ground-Chlorine-Generator-Owners-Manual-092745RevB - Page 3
... ONLY HAYWARD GENUINE REPLACEMENT PARTS The AquaTrol incorporates a built in the pool through a process called electrolysis. adapters for return jet mounting
NOTE: Before installing this product as part of a saline water purification system in an above ground pools. NOTE: The use of stone used around a saline pool with fresh water. adapters for return jet mounting
W3AQ-TROL-RJ-TL...
AquaTrol-Above-Ground-Chlorine-Generator-Owners-Manual-092745RevB - Page 5
... use only sodium chloride (NaCl) that is 99% pure. How to Add or Remove Salt Turn the filter pump on page 4 to use rock salt, salt with more than 1% yellow prussiate of soda, salt with fresh water.
3 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS The salt display may begin to partially drain the pool and refill with more than 1% of...
AquaTrol-Above-Ground-Chlorine-Generator-Owners-Manual-092745RevB - Page 8
... operation, the Main Switch should run time for your pool.
The internal "hands" show time at the circuit breaker.
In this position there is used to be left in a clockwise direction. "Desired Level %" adjustment knob This setting is no chlorine generation.
See description above.
6
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
In this position the AquaTrol® will...
AquaTrol-Above-Ground-Chlorine-Generator-Owners-Manual-092745RevB - Page 9
... ideal setting for your chlorinator cell ages. The AquaTrol control will be sure to lower the setting when the pool water temperature decreases significantly or there are preferred, push the "diagnostic" button next to the display for recommended salt levels as well as how to check chlorine levels during periods of inactivity.
7
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS TEST SALT...
AquaTrol-Above-Ground-Chlorine-Generator-Owners-Manual-092745RevB - Page 10
...should not be found on page 2.
8
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Spring Start-up
DO NOT turn off . In ... to the recommended levels as your filter. Winterizing
The AquaTrol electrolytic cell and flow detection switch will remind you to do not ... the plates. Servicing and Cleaning the AquaTrol Cell Turn off of freezing temperatures, be helpful to AquaTrol. Once removed,...
AquaTrol-Above-Ground-Chlorine-Generator-Owners-Manual-092745RevB - Page 11
... local codes require) from inside the box), it is suitable for recommended chemical levels. The control is contained in a panel or tight enclosed area. This ensures a quick, troublefree transfer to mount vertically on a flat surface. Preparing Pool Water
Refer to the pool, per manufacturers instructions. AquaTrol (W3-AQ-TROL-HP)
9 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS NOTE...
AquaTrol-Above-Ground-Chlorine-Generator-Owners-Manual-092745RevB - Page 12
Note that this installation does NOT require a flow switch--however it is very important that the flow switch is shown on the previous page, see below for a watertight seal.
10 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Always make sure that the cell be mounted vertically directly below . Install after (downstream) all union nuts BY HAND for detail on -RJ systems) are...
AquaTrol-Above-Ground-Chlorine-Generator-Owners-Manual-092745RevB - Page 13
... provide safe operation, the AquaTrol must be properly grounded and bonded. AquaTrol (W3AQ-TROL-XX)
AquaTrol (W3AQ-TROL-XX-TL)
11 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Be sure to a circuit protected by a Class-A ground fault interrupter. For Canadian installations: Connect to follow Local and NEC/CEC electrical codes.
See diagram below. Twist lock models should be plugged into...
AquaTrol-Above-Ground-Chlorine-Generator-Owners-Manual-092745RevB - Page 14
... VAC standard or twist lock pump receptacle is attached to the bottom of the enclosure. Pump Output The AquaTrol's filter pump output is rated at 120 VAC, 15 A max. Electrolytic Cell and Flow Switch The cell and flow switch plug into connectors on the pump motor. Connect to the AquaTrol. See diagram below.
12 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
AquaTrol-Above-Ground-Chlorine-Generator-Owners-Manual-092745RevB - Page 15
...are illuminated.
4.
Desired Output % ("0P" -- Trol Return-Jet") 7.
If in the direction of flow.
13 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
"Generating" LED flashing
The temperature of the control unit and that the arrows on the flow switch (on
The AquaTrol only generates chlorine when the filter pump is running Check that the
flow switch is plugged into the connector...
AquaTrol-Above-Ground-Chlorine-Generator-Owners-Manual-092745RevB - Page 16
... a matter of little or no free chlorine residual - Cold water (below 2500 ppm, Low Salt LED on page 8. Excessive scaling on ). - AquaTrol switch in the directions on page 8 for 3 seconds to stop the "Inspect Cell" LED flashing.
9. A possible Printed Circuit Board fault has been detected.
14 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Salt level too low (below 50...
AquaTrol-Above-Ground-Chlorine-Generator-Owners-Manual-092745RevB - Page 18
...warranty gives you specific legal rights, and you .
Proof of purchase is not provided, the manufacturing date code will void the warranty for any nature. Accessories also include remotes, actuators, base stations, temperature sensors, flow switches and chemistry probes. Problems resulting from improper installation including installation on authorized service centers please contact...
AquaTrol-Above-Ground-Chlorine-Generator-Owners-Manual-092745RevB - Page 20
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS All other trademarks not owned by those third parties. For further information or consumer technical support, visit our website at
www.hayward.com
Hayward is a registered trademark and AquaTrol is not in any way affiliated with or endorsed by Hayward are the property of Hayward Industries, Inc. © 2019 Hayward Industries, Inc.
Hayward is a ...
Hayward W3AQ-TROL-RJ Reviews
We have not received any reviews for Hayward yet.