Hayward Perflex Extended-Cycle Support and Manuals
Get Help and Manuals for this Hayward item
View All Support Options Below
Free Hayward Perflex Extended-Cycle manuals!
Problems with Hayward Perflex Extended-Cycle?
Ask a Question
Free Hayward Perflex Extended-Cycle manuals!
Problems with Hayward Perflex Extended-Cycle?
Ask a Question
Most Recent Hayward Perflex Extended-Cycle Questions
Hayward Pro Flex Filter
is the flow diffuser inside of the filter glued in? If so what type of glue do I use?
is the flow diffuser inside of the filter glued in? If so what type of glue do I use?
(Posted by burkeroxbury 8 years ago)
Is65ing Filter.motor Runs, Will Empty Out The Prime In The Hopper- Wont Refill
(Posted by tjmc522 9 years ago)
Perflex Extended Cycle Filtration System
Ec50c90 Series Pressure
what pressure should you operate the pump at
what pressure should you operate the pump at
(Posted by hiitshotch 10 years ago)
Peice Of Metal Rattling Around In The Filter
I found this peice of metal that was loose inside my filter. I was trying to figure out where it goe...
I found this peice of metal that was loose inside my filter. I was trying to figure out where it goe...
(Posted by Thecoptobe79 10 years ago)
Ec65 And Ec65a?
What's the difference between these two models? I have an old EC65 that I need to replace and I want...
What's the difference between these two models? I have an old EC65 that I need to replace and I want...
(Posted by itaintez4me 11 years ago)
Popular Hayward Perflex Extended-Cycle Manual Pages
Models: EC65A EC75A - Page 1
... special instructions that are important but not related to the potential for personal injury. SAVE THIS INSTRUCTION MANUAL
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Pomona,...instructions can cause severe injury and/or death. OWNER'S MANUAL
INSTALLATION, OPERATION & PARTS
IS65ING Rev. This is the safety-alert symbol. A
MODELS: EC65A, EC75A PERFLEX® SERIES Extended Cycle Basic FILTER...
Models: EC65A EC75A - Page 3
... connecting to a gas supply line. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Pomona, CA Clemmons, NC Nashville, TN www.haywardpool.com
o Replace damaged, broken, cracked, missing, or not securely attached suction outlet components immediately.
Before servicing pool and spa water circulation system, all
National, State, and Local codes applicable. WARNING - Limb Entrapment- WARNING...
Perflex EC40 - Page 1
... are recommended.
3. Since 40 GPM (150 LPM) is the desired maximum filter flow, a flow controller (part number ECX1055) is periodically regenerated and the filter cycle extended without backwashing or dismantling the filter.
Keep the number of the system. Instructions for swimming pool service. Position the filter so the tank can lift water from a lower level and prime automatically...
Instruction Manual - Page 1
...that must be furnished to avoid unnecessary service calls, read this product.
ISEC40C90 Rev. SAVE THIS INSTRUCTION MANUAL
HAYWARD POOL PRODUCTS, INC. Pomona, CA 91768 A
OWNER'S MANUAL
INSTALLATION, OPERATION, & PARTS
Perflex Extended Cycle Filtration System
EC40C90 Series
The Hayward® Perflex™ Filtration System is specifically designed for the demanding requirements of this...
Instruction Manual - Page 2
...used with storable pools. Perflex™ Extended Cycle Filtration System__________
PRODUCT REGISTRATION
(Retain For Your Records)
________
DATE OF INSTALLATION INITIAL PRESSURE GAUGE READING (CLEAN FILTER PUMP MODEL HORSEPOWER FILTER MODEL SERIAL NUMBER
IMPORTANT SAFETY INSTRUCTIONS
When installing and using this
product. READ AND FOLLOW ALL INSTRUCTIONS IN THIS OWNER'S MANUAL AND ON...
Instruction Manual - Page 3
... filter system. WARNING - WARNING - To prevent explosion caused by a GFCI. If your supplier. Do NOT connect to bleed air from your pump is damaged, cracked, missing, or not securely attached. Confirm that the receptacle is protected by entrapped air in compliance with the covers.
Perflex™ Extended Cycle Filtration System__________
NOTE: The National Electrical Code...
Instruction Manual - Page 4
...decreases the flow, conventional filters require backwashing. All Perflex™ Filtration models are combined on fresh or salt-water swimming pools. It may be followed precisely. Perflex™ Extended Cycle Filtration System
General Information
Introduction
This manual contains information for the proper installation and operation of a button, this manual MUST be used on...
Instruction Manual - Page 5
... over-tightening with insert fittings and stainless steel clamps.
3. A filter drain plug, with gasket, is needed .
4. When applying Teflon tape to the filter.) Ball type valves are covered later. Perflex™ Extended Cycle Filtration System
Installation Instructions
System Location
For best pump performance, the system MUST be level and vibration-free.
The field supplied...
Instruction Manual - Page 6
...Starting the Filter System
1. Open Air Relief Valve before loosening Center Clamp or servicing filter.
2. Stabilized...'s instructions.
Use only the swimming pool grades of wood to follow all in-line valves. Perflex™ Extended Cycle Filtration System
Prior...filter and prime and start system, open all instructions
When installing and using a wrench and socket (1/2" drive).
Instruction Manual - Page 7
.... As the filter removes dirt from the pool water, the accumulated dirt causes a resistance to do so could cause severe personal injury and/or property damage.
1. When the pressure rises 7-10 psi (.49-.70 Bar) above the pre-coat pressure, regenerate the filter.
Perflex™ Extended Cycle Filtration System
Start-Up & Operation
Starting the Filter
Close the filter drain and...
Instruction Manual - Page 8
...holes. Chlorine will naturally dissipate Dilution - partially drain & refill pool with water that the mineral content in a pool increases every day as described under "Cleaning". Perflex™ Extended Cycle Filtration System
Start-Up & Operation (cont.)
To Change Bump Handle Position
1. Push in shortened filter cycles. Use commercially available 20% muriatic acid added to water...
Instruction Manual - Page 9
... and straighten or replace. Clean.
Electric motor running less than maximum R.P.M. (underspeed). Super-chlorinate;
Restriction in return line caused by small eyeball fitting.
Repeat 6 times. D.E.
Pump output exceeds design flow rate of pump. Open valve.
Probable Cause D.E. Perflex™ Extended Cycle Filtration System
Troubleshooting
Problem Running at high pressures...
Instruction Manual - Page 10
...or replace. Add enough chlorine to control this part.)
Replace gasket. then vacuum. must be added as soon as to pool via skimmer or main drain.
will clog filter....leaking to bypass filter.
Sometimes happens when last charge of live algae present in pool. 3.
Perflex™ Extended Cycle Filtration System
Troubleshooting (cont.)
Problem
Short cycles - Opening or...
Instruction Manual - Page 11
... Pump
1
6 ft. SP0723
15
ECX27081
16
ECX1256
17
ECX4077B1
18
SPX1055
- Cord Set
1
Pump Mounting Screw
1
Washer
1
Platform Base
1 No. Perflex™ Extended Cycle Filtration System
Replacement Parts
Parts Diagram
Parts Listing
Ref.
Part No.
1
ECX10066
2
ECX5000BP
3
ECX4034
4
ECX4000C
5
ECX4000CHK
6
ECX1014A
7
ECX1037B
8
ECX4236A
9
ECX5000F
10...
Instruction Manual - Page 12
Perflex™ Extended Cycle Filtration System
HAYWARD® LIMITED WARRANTY
This filter system was inspected before shipment from the date of Pool
Years pool has been in obtaining warranty replacements. All other such costs incurred in service □ less than 1 □ 1-3 □ 3-5 □ 5-10
Purchased from state to state.
*Supersedes all previous publications.
To ...
Hayward Perflex Extended-Cycle Reviews
We have not received any reviews for Hayward yet.