Hayward Perflex Extended-Cycle Support Question
Hayward Perflex Extended-Cycle Support Question
Find answers below for this question about Hayward Perflex Extended-Cycle.Need a Hayward Perflex Extended-Cycle manual? We have 3 online manuals for this item!
Question posted by itaintez4me on January 12th, 2013
Ec65 And Ec65a?
What's the difference between these two models? I have an old EC65 that I need to replace and I want the same filter so re-installation will be easier (plus it's been a great filter for twenty some odd years).
Current Answers
Related Hayward Perflex Extended-Cycle Manual Pages
Models: EC65A EC75A - Page 1
... hazards that are important but not related to hazards. OWNER'S MANUAL
INSTALLATION, OPERATION & PARTS
IS65ING Rev. When you see this symbol on your... INSTRUCTION MANUAL
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Pomona, CA Clemmons, NC Nashville, TN www.haywardpool.com
A
MODELS: EC65A, EC75A PERFLEX® SERIES Extended Cycle Basic FILTER Units
Basic safety precautions should always ...
Models: EC65A EC75A - Page 3
... and replaced at more suction outlets per pump must be installed a minimum...filter manual air relief valve must be positioned so as to prevent their being used in winterization of the pool/spa from near point to avoid "dual blockage" by young children. Separation Hazard.
WARNING - Failure to the pool. Page 3 of water (not air or air and water) is discharged. o Installation...
Models: EC65A EC75A - Page 4
...
8. Tighten pump base mounting bolts, if loose.
4. Set the mounting platform level. Connect the pool suction plumbing between the filter and pump.
5. If the pressure gauge is periodically regenerated and the filter cycle extended without backwashing or dismantling the filter. Though the system is the most units. All electrical connections should be combined on local...
Models: EC65A EC75A - Page 5
... cleaner mixed according to the package instructions. PRECOATING
For the EC65A Scoop 6 lbs. (2.7 kgs.) of diatomite into the system through the skimmer as fast as described under bump cover), open the filter drain (Note: if the filter is installed below the pool water line, opening the suction valve for precoating.
WITCO
Witco Corporation
2. allow water...
Models: EC65A EC75A - Page 11
...No
City State_________ Zip
Product Model Number
Product Serial No
□ New Installation
□ Replacement
Type of In-Ground Pool:
□ Vinyl □ Fiberglass □ Gunite
Please send me more information on achieving and maintaining proper pool water chemistry, initial start-up and operation of your Perflex
fitter, cleaning your spa. Please Print Clearly: Warranty...
Perflex EC40 - Page 1
...filter uses diatomite filter powder (commonly called the centrifugal. is initially started; If the pump is going above or below the normal pool water line.
Install...filter is periodically regenerated and the filter cycle extended without backwashing or dismantling the filter...IS40AB-98
MODEL EC40 SERIES
The Perflex Model EC40 is a high performance swimming pool filter with pumps...
Perflex EC40 - Page 3
... slide the cover off will adequately flush the unit.)
Close the filter drain and the vent valve.
REGENERATION (Extending the Cycle)
Stop the pump. Restart the pump and filtration will decrease. After the filter has drained, and with each filter and is installed below the pool water line, close the suction and return valves) and allow water...
Perflex EC40 - Page 4
... a chlorine level of the pool will naturally dissipate
CHLORINE STABILIZER (Cyanuric Acid)
40 to clear it.
No returns may be necessary to regenerate the Perflex filter as frequently as every 2...Hayward Pool Products, Inc. WINTERIZING
In areas where sub-freezing temperatures can be expected, the filter should be drained and removed from a few hours. Prior to removal, cycle the filter as...
Instruction Manual - Page 1
...Pomona, CA 91768 WARNING - SAVE THIS INSTRUCTION MANUAL
HAYWARD POOL PRODUCTS, INC. The advanced design reduces maintenance requirements while providing superior performance.
A
OWNER'S MANUAL
INSTALLATION, OPERATION, & PARTS
Perflex Extended Cycle Filtration System
EC40C90 Series
The Hayward® Perflex™ Filtration System is specifically designed for the demanding requirements...
Instruction Manual - Page 2
...to its original integrity. It requires free circulation of swimming pool, spa, or hot tub. (In Canada use No. 6 ...Perflex™ Extended Cycle Filtration System__________
PRODUCT REGISTRATION
(Retain For Your Records)
________
DATE OF INSTALLATION INITIAL PRESSURE GAUGE READING (CLEAN FILTER PUMP MODEL HORSEPOWER FILTER MODEL SERIAL NUMBER
IMPORTANT SAFETY INSTRUCTIONS
When installing...
Instruction Manual - Page 3
...of electric shock replace damaged cord
immediately. Hazardous Pressure. Pumps, filters, and other ...installed and/or improperly tested filtration equipment and/or components may fail resulting in compliance with only one (1) wall of the pool or spa. Risk of a swimming pool filtration system operate under pressure. WARNING - WARNING - WARNING -
Perflex™ Extended Cycle...
Instruction Manual - Page 4
... base
Perflex™ Filtration Performance Data
Model No. Output pressure and flow are high performance, above-ground swimming pool filters. Effective...filter is designed for continuous operation and for installation below the pool water line.
Perflex™ Extended Cycle Filtration System
General Information
Introduction
This manual contains information for the proper installation...
Instruction Manual - Page 5
...rains. Instructions for changing the handle position are 1 ½" N.P.T. Securely hand tighten the union nut between the skimmer, pool outlet, and the pump. Piping must be new or thoroughly cleaned before operating system.
12. Perflex™ Extended Cycle Filtration System
Installation Instructions
System Location
For best pump performance, the system MUST be located below the...
Instruction Manual - Page 6
... a pool test kit. Stabilized forms of wood to help seat it. Important Safety Instructions -
Stand clear of water emerges from the Air Relief Valve, close Air Relief Valve. Perflex™ Extended Cycle Filtration System
Prior to follow all in -lbs.). When a steady stream of filter and prime and start system, open all instructions
When installing and...
Instruction Manual - Page 7
... period or when cloudy water returns to the pool for more than one (1) minute without the pre-coat charge.
CAUTION - Filtering
Filtration starts as soon as in the bottom of diatomite (D.E.) into the filter whenever needed. Regeneration (Extending the Cycle)
Stop the pump. Cleaning
Cleaning is installed below the pool water line, opening the suction valve for pre...
Instruction Manual - Page 8
... use other commercial filter element cleaner mixed in place.
4. Tap the pivot pin in accordance to the factory without the expressed written authorization of the handle.
3. WARNING - Do NOT mix chlorine and acid. Perflex™ Extended Cycle Filtration System
Start-Up & Operation (cont.)
To Change Bump Handle Position
1. Pool Chemistry Guidelines
Suggested Pool Chemistry Levels
pH...
Instruction Manual - Page 9
...Pump impeller vanes clogged. Cleaning with normal accumulation of pool dirt, algae, etc. Power cut-backs. 3. Regulate pump GPM/LPM output to max. Bump-Drain-Recharge as necessary. Perflex™ Extended Cycle Filtration System
Troubleshooting
Problem Running at high pressures.
Replace or tighten as needed. etc.
Short cycles. Partially closed valve on suction side of return...
Instruction Manual - Page 10
...pool dealer for chemical cleaning instructions.
Tighten bolts.
Very dirty water. Presence of alum or flocking agents which will cause this type of live , vigorously growing algae. Add enough chlorine to control this part.)
Replace gasket. Perflex™ Extended Cycle...stream. will clog filter. Soak tube nest in one or more often. Hard bumping. Very short cycles when vacuuming. ...
Instruction Manual - Page 11
...
12
ECX1031
13
SPX1500NYA
14
SP1022C
- SP0723
15
ECX27081
16
ECX1256
17
ECX4077B1
18
SPX1055
- Perflex™ Extended Cycle Filtration System
Replacement Parts
Parts Diagram
Parts Listing
Ref. No.
Req'd
Bump Mechanism Cover
1
Filter Head with Vent Valve
1
Filter Body with Flow Diffuser
1
Clamp Assembly with Hardware
1
Hardware Kit for Clamp Assembly
1
Shaft Kit...
Instruction Manual - Page 12
...defective during the warranty period, except as a result of freezing, negligence, improper installation, use, or care, shall be returned, transportation paid, to the place of the standard warranty apply.
Perflex™ Extended Cycle Filtration System
HAYWARD® LIMITED WARRANTY
This filter system was inspected before shipment from state to state.
*Supersedes all previous publications...
Similar Questions
What Are The Valve Settings For Inground Pool With Hayward Max Xl Flo Pump
(Posted by Anonymous-174361 10 months ago)
Hayward Perflex Model Ec50c90 Series
I have a new above ground pool with this filter. I am at a loss as to when i need to add new DE and ...
I have a new above ground pool with this filter. I am at a loss as to when i need to add new DE and ...
(Posted by Anonymous-144175 9 years ago)
Do I Need To Reclean Filter With Acid When Opening Pool? Or Just At Closing Time
(Posted by Anonymous-137113 9 years ago)
Perflex Extended Cycle Filtration System
Ec50c90 Series Pressure
what pressure should you operate the pump at
what pressure should you operate the pump at
(Posted by hiitshotch 10 years ago)
Dual Pool Spa System But The Settings Menu Doesn't Show Pool Heater Only Spa Hea
(Posted by Anonymous-39619 12 years ago)