Hayward HYDRAPURE Support and Manuals
Get Help and Manuals for this Hayward item
View All Support Options Below
Free Hayward HYDRAPURE manuals!
Problems with Hayward HYDRAPURE?
Ask a Question
Free Hayward HYDRAPURE manuals!
Problems with Hayward HYDRAPURE?
Ask a Question
Hayward HYDRAPURE Videos
Hayward Instalación de HydraPure (UV y Ozono)
Duration: 1:05:59
Total Views: 2,396
Duration: 1:05:59
Total Views: 2,396
HydraPure: A New, All-In-One, UV and Ozone Solution
Duration: 2:49
Total Views: 10,360
Duration: 2:49
Total Views: 10,360
HAYWARD HydraPure® S3 Advanced Oxidation Sanitization System: Complementary Sanitization
Duration: 2:29
Total Views: 5,473
Duration: 2:29
Total Views: 5,473
Popular Hayward HYDRAPURE Manual Pages
HydraPure Owners Manual - Page 1
R00
HydraPure
2½ inch Residential AOP System
Owner's Manual
Contents
Overview 3 Installation 4 Operation 8
HYDRAPURE
Hayward Industries 400 Connell Drive, Suite 6100
Berkeley Heights, NJ 07922 Phone: (908) 355-7995 www.hayward.com
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS 101950175500 -
HydraPure Owners Manual - Page 2
... protected by a ground fault circuit interrupter.
• DANGER: Replace damaged cord immediately.
• DANGER: Do not bury cord.
• DANGER: Connect to a grounded, grounding type receptacle only. SAVE THESE INSTRUCTIONS
Signal Words and Symbols Used In This Manual This Owner's Manual and Installation Guide contains specific precautions and symbols to a power source. You will...
HydraPure Owners Manual - Page 3
... eyes can cause discomfort, irritation, and damage to : www.hayward.com
READ AND FOLLOW ALL IMPORTANT SAFETY INSTRUCTIONS When installing and using this install manual go to the eyes if viewing occurs while device is provided on the external surface. PLEASE REVIEW THE OWNER'S MANUAL AND INSTALLATION GUIDE IN ITS ENTIRETY AND HEED ALL SAFETY INFORMATION. Failure to...
HydraPure Owners Manual - Page 4
For larger installations, more than one HydraPure can be checked and adjusted to prevent this ...120 gpm 99.9% sanitization flow rate maximum: 80 gpm
Sizing
The HydraPure is indoors or outdoors.
3 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS When using multiple HydraPure units, plumb vessels in parallel. Overview
Specifications
Plumbing diameter: 2" Socket, 2½" SPIGOT Input power: 120VAC...
HydraPure Owners Manual - Page 5
..., if local codes require). Determine a Suitable Location
The HydraPure must be installed after all equipment (pump, filter, heater) but prior to install your supplier or Hayward. Installation
CAUTION: Before starting this manual, contact your unit in a safe manner. HYDRAPURE
Head Loss
TO POOL RETURNS
TO SPA
4 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS For hardwired installation, use...
HydraPure Owners Manual - Page 6
...HydraPure Unit
Hardwired: 120V or 240V HydraPure unit: Follow steps 1 & 2 below .
1 Thread L1, L2 (240V) or N (120V)
and ground wire through conduit. L2 if 240V, Ground
L1
N if 120V
5 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...plug
critical points internal to glue pipes into the union sleeve.
Plumbing the HydraPure Unit
1 Attach the (2) PVC 2½" union nuts to the illustration ...
HydraPure Owners Manual - Page 7
... can be positioned in the desired
position. Take care when handling.
6 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS To install the HYDRACORDKIT, attach wires to connections according to the illustration above.
2 Plug HydraPure into a GFCI outlet.
L1
N
Ground
1 Remove the lid by following the instructions on the bottom
of the control panel.
1 R emove the 4 screws and then...
HydraPure Owners Manual - Page 8
... and draining down the equipment set. In some cases it in... power to change the Ozone check valve, the installer simply loosens and unscrews the tubing compression fitting,...Part Number HYDRACHKVLVOEM
HYDRACHKVLV2 HYDRACHKVLV3 HYDRACHKVLV4
In order to the HydraPure by turning on automatically when it senses water flow.
7 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS This prevents the HydraPure...
HydraPure Owners Manual - Page 10
... unit to lid. Never remove the HydraPure unit's cover without first disconnecting the power source from ballast.
5 R emove spring clip.
9 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS The UV LED will turn off the... remaining lamp life. Press for 1 second and then release the Ozone Reset button to the HydraPure unit and pool pump. Do not handle a hot lamp or serious burns will turn off ...
HydraPure Owners Manual - Page 13
... lamp(s) in the unit to the HydraPure unit and pool pump.
Red flashing UV BULB LIFE indicates UV bulb is no longer sanitizing and should be replaced soon,
1 Turn Off Power to unit or unplug. 2 R emove screws to electrical enclosure cover.
5 R emove spring clip.
12 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Do not handle a hot lamp or...
HydraPure Owners Manual - Page 14
... unit to B.
Re-install the spring clip and re-attach the lamp connectors to the ballast.
9 A fter power is restored, press
and hold UV BULB LIFE Button, for a minimum of lamp from the HydraPure unit. Ozone Lamps Replacement
WARNING: Turn off the pump. Before proceeding allow at least 15 minutes for instructions on the lamp...
HydraPure Owners Manual - Page 15
....
5 C arefully lift the lamp assembly, a slight
tug may be aligned and seated securely in the lamp holder.
7 A fter power is restored, press and hold
OZONE BULB LIFE Button, for instructions on disposal.
14 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
HydraPure Owners Manual - Page 16
Winterizing
WARNING: Turn off all power to the HydraPure unit and pool pump before proceeding to completely drain, this will be an initial rush of the unit by turning counter clockwise. Allow unit to winterize. Re-install O-ring plug hand tight.
15 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Remove Winterizing O-ring plug near the bottom of...
HydraPure Owners Manual - Page 17
...KIT, CONVERSION, 120V CORDED HYDRAPURE
REPLACEMENT, MEMBRANE SW & CABLE BOARD W/TUBES & SENSOR WIRE HARNESS SCREW PACK REPLACEMENTS KIT, ORINGS BYPASS VALVE ...REPLACEMENT SEAL, QUARTZ TUBE, REPLACEMENT KIT, LAMP, 3PC W/ BOOT AND ORING
PLUG, DRAIN, 1/2", W/ ORING ORING, F/ DRAIN PLUG, 1/2", 4PK
BALLAST W/WIRES, O3 BALLAST W/WIRES, UV UNION, TRISTAR, 2 PK
16 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
HydraPure Owners Manual - Page 20
... information or consumer technical support, visit our website at
www.hayward.com
Hayward is not in any way affiliated with or endorsed by Hayward are the property of Hayward Industries, Inc. © 2022 Hayward Industries, Inc. Hayward is a registered trademark of their respective owners.
All other trademarks not owned by those third parties. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Hayward HYDRAPURE Reviews
We have not received any reviews for Hayward yet.