Samsung MW5490W Support Question
Samsung MW5490W Support Question
Find answers below for this question about Samsung MW5490W.Need a Samsung MW5490W manual? We have 1 online manual for this item!
Question posted by sfarris on March 4th, 2013
Watts For Samsung Microwave Oven
How many watts does the Samsung Microwave Oven Model MW5490W have?
Current Answers
Related Samsung MW5490W Manual Pages
Service Manual - Page 1
Disassembly and Reassembly 5. Troubleshooting 7. Exploded Views and Parts List 8. Schematic Diagrams Specifications 3. Alignment and Adjustments 6. PCB Diagrams 9. Precaution 2. Operating Instructions 4. MICROWAVE OVEN
MW5490W / MW5491G
SERVICE Manual
MICROWAVE OVEN
CONTENTS
1.
Service Manual - Page 2
Samsung Electronics PRECAUTIONS TO BE OBSERVED BEFORE AND DURING SERVICING TO AVOID POSSIBLE EXPOSURE TO EXCESSIVE MICROWAVE ENERGY
(a) Do not operate or allow the oven to be operated with the door open.
(b) Make the following safety checks on all ovens to be serviced before activating the magnetron or other microwave source, and make repairs as necessary...
Service Manual - Page 3
...Examples include integrated circuits and field-effect transistors.
Samsung Electronics
1-1 Although the microwave oven is completely safe during ordinary use oven until it has been brought into compliance at the...important for the particular model being repaired.
13. Restore any of its assemblies, be extremely hazardous due to possible exposure to servicing if the oven is blown by ...
Service Manual - Page 4
... the negative terminal of the special components. Discharging the High Voltage Capacitor
1-2
Samsung Electronics Use replacement components that does not have the same ratings, especially for safety...voltage of the lead wires is present during any components or wiring, always unplug the oven and discharge the high voltage capacitor (See Figure 1-1)
2. Fig. 1-1. Pretaution
1-2 ...
Service Manual - Page 5
Specifications
2-1 Table of Specifications
ITEM TIMER POWER SOURCE POWER CONSUMPTION OUTPUT POWER
MODEL
OPERATING FREQUENCY MAGNETRON COOLING METHOD OUTSIDE DIMENSIONS NET WEIGHT
MW5490W / MW5491G 99 MINUTES 99 SECONDS 120V/60HZ, AC MICROWAVE : 1,450W FROM 100W TO 1000W (10 LEVEL POWER) (IEC-705 TEST PROCEDURE) 2,450MHz OM75PH(31)ESS COOLING FAN MOTOR 2011/32(W) x 1111...
Service Manual - Page 6
...
Light
Safety Interlock Holes
Door Latches
Glass Tray
Guide Roller
Control Panel Open Door Push Button
297mm
3-1
370mm 517mm
215mm 379mm
Samsung Electronics
Kitchen Timer Button
Start Button Press to pause oven ro correct a mistake.
Number Key Button Sets cooking times or amounts. Instant Cook Button Instant setting to be reheated. Operating...
Service Manual - Page 7
...voltage capacitor. 2.
V. V.
Disconnect all lead wires from hole
of fan
motor assembly. 6. Samsung Electronics
4-1 4. Disassembly and Reassembly
4-1 Replacement of Magnetron, Motor Assembly and Lamp
Remove the ... High Voltage Transformer
1.
Take out the fan motor assembly. 7. Remove the oven lamp by pulling out from the magnetron and lamp.
2.
Trans
4-2 Replacement of ...
Service Manual - Page 8
... of Door Assembly
4-3-1 Removal of Key Door & Spring
Remove pin hinge from Door "E" Detach spring from Door "E" and key door.
4-2
Door "E"
Door "E"
Key Door
Spring
Samsung Electronics
Service Manual - Page 9
... tray and the guide roller from the power source. 2. Turn the oven upside down to the cavity. 6. Samsung Electronics
Screw
Drive Motor
Drive Motor Cover Base Plate 4-3 When 15A fuse... the oven, be sure to the base plate with the coupler. 8. Disconnect the oven from the cavity.
2. Disconnect all the leads to prevent an excessive microwave leakage.
1.
Do the microwave leakage test...
Service Manual - Page 10
... surface of hair dryer is cleaned sufficiently so that the holes on the connector are properly engaged with Ass'y control panel.
2.
Membrane Panel
4-4
Screw Screw
Samsung Electronics When installing new membrane key board, make sure
that any static electric charge in your body and never touch the control circuit.
2. Window display...
Service Manual - Page 11
...
Gasket Plate
Cooling Fins
Samsung Electronics
5-1 Remove connectors from...oven from the circuit by disconnecting its power source and discharge the high voltage
capacitor.
5-1 High Voltage Transformer
1. High voltage is located on the control circuit board.
2.
Normal resistance readings are as follows:
MODEL
Secondary Filament Primary
(Room temperature = 20ûC)
MW5490W...
Service Manual - Page 12
...5. Resistance between terminals of the monitor circuit and all together). The relays are located on the PCB Ass'y. Operate the microwave oven with the meter set at the highest resistance scale. 2. Alignment and Adjustments
5-4 High Voltage Capacitor
1. Check continuity of ... switch (COM-NC) Door Sensing S/W
Door Open
¥ 0 ¥
Door Closed
0 ¥ 0
5-2
Samsung Electronics
Service Manual - Page 13
...watts is 9.9ûC to
high power and operate for 44 seconds exactly. (3 seconds included as a holding time of Magnetron
Alignment and Adjustments
CAUTION MICROWAVE RADIATION
PERSONNEL SHOULD NOT ALLOW EXPOSURE TO MICROWAVE RADIATION FROM MICROWAVE GENERATOR OR OTHER PARTS CONDUCTING MICROWAVE...: Coefficient for this model is computed by multiplying...Set the oven to 10...Samsung Electronics
5-3
Service Manual - Page 14
... 600cc, and place the beaker in the center of the oven.
2) Start to operate the oven and measure the leakage by its manufacturer.
5-4
Samsung Electronics
CENTRAL SERVICE CENTER
5-12-2 At least once a year have the microwave energy survey meter checked for accuracy by using a microwave energy survey meter.
3) Set survey meter with dual ranges to...
Service Manual - Page 15
...SOURCE ON. Fuse is replaced, check diode and magnetron also. No display and no microwave oscillation. (No heat while oven lamp and fan motor turn on.)
1. Open low voltage transformer 4. Check Ass'y PCB... to Ass'y PCB 3. Defective power relay or Ass'y PCB
Adjust door and latch switches. Samsung Electronics
6-1 DISCHARGE THE HIGH VOLTAGE CAPACITOR. 4. ALWAYS TOUCH GROUND WHILE WORKING ON IT TO ...
Service Manual - Page 16
... use any type of cookware with aluminum foil. Troubleshooting
6-2 Electrical Mulifunction(continued)
SYMPTOM Oven lamp and fan motor turn on
Oven can be heard. Operation of fan motor.
Wrap thinner parts of door sensing switch
Defective Ass'y PCB
1. Microwave output is low;.
Use plastic wrap or cover with gold or silver powder also...
Service Manual - Page 17
Exploded Views and Parts List
7-1 Exploded Views
D6 D1 D4
D5 D3 D2
M24
M1 M27
M25 M2 M3
M4 M5
M6
M8
M26
C7 C4
M11
M10
M22
B2
M21
B1
M12 M20 M23
M7
B3
M9
B4 B2
M14 M13
C8
C3
C2
C1
C5 C6
M15
M19
M16
M17 M18
Samsung Electronics
7-1 7.
Service Manual - Page 18
...,P/WHT ASSY DOOR;MW5491G,D/GRY ASSY POWER CORD;125V13A,AWG16,1350,GRAY,MSP-36 CUSHION-RUBBER;T3,W100,L190,-,MW5896W,BLK
Q'ty Remarks
1 MW5490W 1 MW5491G 1 1 1 1 1 1 1 CV/AIR 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 MW5490W 1 MW5491G 1 MW5490W 1 MW5491G 1 1 O/PANEL
: Warning
:Electrostatically Sensitive Devices
7-2
Samsung Electronics Parts No. Exploded Views and Parts List
7-2 Main Parts List
Ref.
Service Manual - Page 19
...FB53WH),-,-,-,3.5G,NTR,3RD-W MW5592W
Samsung Electronics
Q'ty Remarks 1 2 1 1
7-3 Parts No. No. Parts No.
No. 7-3 Door Parts List
Ref. D 1 DE64-00037D D 1 DE64-00037E D 2 DE64-40006B D 2 DE64-40006F D 3 DE61-70032A D 4 DE67-00011A D 5 DE94-00073A D 5 DE94-00073B D 6 DE64-40012B D 6 DE64-40012A
Description/Specification
DOOR-A;ABS(HR0370),-,-,-,P/WHT,MW5490W DOOR-A;ABS(HR0370),-,-,-,D/GRY...
Service Manual - Page 20
... Remarks
2 C/CEILING
4 MGT
4 TNS-HV
3 B-PLTE
2 BD-LAT
2 CN-BOX
1 CV/AIR
2 MGT-TCO
2 MO/FAN
1 N/F-EA
1 P-C-EA
5 PN/OUT
1 S-M-EA
2 M/DRIV
2
-
1 HVD
1
-
2 M/DRIV
2
-
1 HVD
1
-
7-4
Samsung Electronics Exploded Views and Parts List
7-5 Standard Parts List
Parts No.
Samsung Knowledge Base Results
We have determined that the information below may contain an answer to this question. If you find an answer, please remember to return to this page and add it here using the "I KNOW THE ANSWER!" button above. It's that easy to earn points!-
General Support
... Output Power (w) 950W 1,100W Control method Membrane Door opening type Pocket Handle Microwave distridution Turntable Max Cooking time 99'90" Meat 2. Clock The SAMSUNG microwave oven has an inbuilt clock that provides time and energy efficiency. 20L Grill The SAMSUNG microwave oven has a cavity of 20L and segment is called grill. Accessories Round rack... -
General Support
... of this appliance requires basic mechanical and electrical skills. Note: Installation instructions are the same for all over -the-range microwave oven. Installation of model number. Attachment : SMH7159WC install.pdf The above attachment contains instructions for Over-the-Range Microwave Ovens. Product failure due to improper installation is not covered under the Warranty. -
General Support
.../Heinrich Cnr Field & VIDEO RE. 044 874-4280/ 072 6252663 044 874-4280 Kevin & MICROWAVE 043 722-6201/2 043 722-6205 Peter Nel 4Buffalo Park Drive, Arcadia, East London, 5247 FLS REFRIGERATION ... LESOTHO (MASERU) GABORONE GOLDTECH (Pty) Ltd (Robby) 09267 3923-508 09267 3923-2272 Spencer Watt-Pringle Mds Crosscape,cnr Barbra&North Reef Rd,Elandsfon. JHB.BUSINESS SUPPLIES 0861 609 609 011...
Similar Questions
Condensation Between Glass Of The Microwave Door. Model Smh8165st
need to remove the glass from the microwave door to dry it. boiling anything the door fills with hea...
need to remove the glass from the microwave door to dry it. boiling anything the door fills with hea...
(Posted by thedays2 7 years ago)
Loud Buzzing, No Heat
The microwave makes a much louder and buzzing sound. All else is on OK but no heat. Is there a DIY f...
The microwave makes a much louder and buzzing sound. All else is on OK but no heat. Is there a DIY f...
(Posted by angietod 9 years ago)
Samsung Microwave Oven Model No. Smh7177ste Vent Door Will Not Open
(Posted by kamakru 9 years ago)
How Do You Unlock The Microwave. I Locked It By Mistake
(Posted by CWAGNER1953 9 years ago)
If A Microwave Is 1400 Watts, How Does That Correlate To The Cubic Footage??
(Posted by cjbrief 10 years ago)