Hayward NorthStar Support Question
Hayward NorthStar Support Question
Find answers below for this question about Hayward NorthStar.Need a Hayward NorthStar manual? We have 1 online manual for this item!
Question posted by bzichucks on August 14th, 2014
How To Wire Hayward Northstar Pool Motor
The person who posted this question about this Hayward product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related Hayward NorthStar Manual Pages
All NorthStar models - Page 1
...pool/spa that will provide many years of efficient, dependable, corrosion-free service. To prevent potential injury and to avoid unnecessary service calls, read this manual carefully and completely. Required: 2" plumbing minimum Recommended: 2 ½" plumbing or larger
SAVE THIS INSTRUCTION MANUAL
HAYWARD POOL... Hayward NorthStar Pump is equipped with large capacity filters, heaters, and pool ...
All NorthStar models - Page 2
..., including the following signal words and be readily disassembled for outdoor use with storable pools. ATTENTION INSTALLER -
If installed within an outer enclosure or beneath the skirt of a hot tub or spa, adequate ventilation and free circulation of the motor. This is strongly advised to hazards. CAUTION warns about hazards that it rains...
All NorthStar models - Page 3
...HAYWARD GENUINE REPLACEMENT PARTS WARNING - Failure to bond pump to the pump. Connect a No. 8 AWG (8.4 mm2) solid copper bonding wire to the pressure wire connector provided on pump or motor, turn off power supply to pool...entrapment.
Before working on the motor housing and to all metal parts of swimming pool, spa, or hot tub, and to all wiring standards including, but not ...
All NorthStar models - Page 4
... the pool. Rugged, one-piece housing, with strainer cover lock ring. Motor and ...NorthStar™ Pump Series
Page 4 of the Hayward NorthStar Pump Series. Failure to install according to all system valves must be in violent separation of corrosion-proof glass-filled thermoplastic for heavy debris loads. Failure to accommodate even the most demanding installations, including pool/spa...
All NorthStar models - Page 5
...-drained area that a minimum length of air for servicing pump and piping. Keep motor clean.
The base must be larger than the discharge line diameter. Allow for outdoor...codes. WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Joints must be ...(but not over-tightened). NorthStar™ Pump Series Product Specifications
Page 5 ...Locate pump as close to pool as practical and run suction ...
All NorthStar models - Page 6
...WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS NorthStar™ Pump Series Pump ...wiring standards including, but at motor MUST NOT be more than 10% above or below motor name plate rated voltage, or motor may fail resulting in accordance with the motor's voltage, phase, and cycle, and that the wire size is reduced considerably; Pool and spa fittings MUST conform to motor...
All NorthStar models - Page 7
...Motor Specifications
Max Rate (MR)
HP
KW
1
0.75
1-1/2
1.10
2
1.55
2-1/2
1.87
3
2.20
-
- Remove any trapped air in the system by fully opening filter manual air relief valve until a
steady stream of 15
Electrical (cont'd.)
Wiring....HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS If other... filter, when starting the pump.
NorthStar™ Pump Series
Page 7 of...
All NorthStar models - Page 8
... is higher than the pump, unscrew and remove strainer cover; Keep motor clean. Storage/Winterization
WARNING - NorthStar™ Pump Series
Page 8 of pump suction.
ATTENTION - Water acts... motor. Replace strainer cover on power and wait for more details. 4. See Troubleshooting Guide. WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Do NOT use water to pool/spa...
All NorthStar models - Page 9
... When servicing electrical equipment, basic safety precautions should attempt rotary seal replacement. A. Contact your pool/spa system.
Only qualified personnel should always be twisted off.
4. Propylene glycol is fully drained, re-install the strainer cover and drain plugs. B. NorthStar™ Pump Series
Page 9 of the pump/strainer housing (item #3), exposing the diffuser...
All NorthStar models - Page 10
... #10) over the impeller/impeller ring (item #11 & #12) onto the seal plate (item #14).
NorthStar™ Pump Series
Page 10 of the ceramic seal (item #13) with a soft cotton cloth. The spring ... (item #13) with wrench as well. Slide the motor assembly with the diffuser (item #10) in step #4. WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Note the tab on the top of...
All NorthStar models - Page 11
NorthStar™ Pump Series
Replacement Parts
Parts Diagram
Page 11 of 15
Parts Listing
Ref. Part No. 1 SPX3200UNKIT 2 SPX3200UG 3 SPX4020TP 4 SPX4000M 5 SPX4000S
6 & 7 SPX4000CLO SPX4000CLOB
8 SPX4000T...Impeller Kit (Includes Impeller, Impeller Ring, Seal Assy)
Ctn. Qty. 1 1 1 1 10 10 10 10 10 1 1
10 (5 for 2-3 HP)
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS No.
All NorthStar models - Page 12
... Seal Assembly Seal Plate Motor Cap Screws Motor Mounting Plate Motor Lock Ring Motor Drain Plug with O-Ring Mounting Base w/2 Cap Screws Mounting Base Cap Screw Kit (set of 15
Parts Listing (cont'd.)
Ref. NorthStar™ Pump Series
Page...SPX4015CKIT SPX4020CKIT SPX4025CKIT SPX4010CKIT SPX4015CKIT SPX4020CKIT
Motor P/N SPX1607Z1BNS SPX1610Z1BNS SPX1615Z1BNS SPX1620Z1BNS SPX1630Z1BNS...
All NorthStar models - Page 13
...wiring diagram on pool wall. 3. If pump does not develop a vacuum and pump has sufficient "priming water": i. Remove and replace shaft seal only if it if necessary. Undersized pool piping. Bypass it is equipped with debris. NOTE: Your Hayward pump motor...qualified repair professional. 2. Solution: Correct piping size. NorthStar™ Pump Series
Page 13 of overheating. open...
All NorthStar models - Page 14
...sometimes prove this point or putting in pump housing. Motor bearings noisy from return fittings). Solution: All seal leaks...undersized suction line or leak at once.
© Hayward Pool Products, 2007 All rights reserved. PRODUCT REGISTRATION
(Retain...Pump - NorthStar™ Pump Series
Page 14 of filter, valve partially closed (high gauge reading). filters - Air leak in pool, and...
All NorthStar models - Page 15
... option, without the express written authorization of Hayward Pool Products.
Hayward shall not be free from Hayward:
□ Pump □ Filter □ Automatic Pool Cleaner □ Light □ Chlorinator &#...shall be made directly to the nearest authorized Hayward service center. NorthStar™ Pump Series
Page 15 of 15
HAYWARD® LIMITED WARRANTY
This pump was inspected...
Similar Questions
Hayward Northstar Pool Pump .where Is The Capacitor?
(Posted by omidmsirro 9 years ago)
How To Install The Electric For Northstar Pool Pump
(Posted by ismaesa 10 years ago)
Dual Pool Spa System But The Settings Menu Doesn't Show Pool Heater Only Spa Hea
(Posted by Anonymous-39619 12 years ago)