Home » Hayward » Pool & Spa » Hayward NorthStar

Hayward NorthStar Support Question

Find answers below for this question about Hayward NorthStar.
Need a Hayward NorthStar manual? We have 1 online manual for this item!

Hayward Overview Questions Manuals Reviews Videos Research

Question posted by omidmsirro on October 1st, 2014

Hayward Northstar Pool Pump .where Is The Capacitor?

The person who posted this question about this Hayward product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.

I Know the Answer!

I have the same question
Request More Information

Current Answers

There are currently no answers that have been posted for this question.
Be the first to post an answer!

Remember that you can earn up to 1,100 points for every answer you submit. The better the quality of your answer, the better chance it has to be accepted.

Related Hayward NorthStar Manual Pages

All NorthStar models - Page 1

P/N: IS4000 Rev. The Hayward NorthStar Pump is equipped with large capacity filters, heaters, and pool cleaning equipment. The advanced design provides superior performance while reducing maintenance requirements. A OWNER'S MANUAL INSTALLATION, OPERATION, & PARTS NorthStarTM Pump Series *50HZ Models are not UL Listed. To prevent potential injury and to avoid unnecessary service ...

All NorthStar models - Page 2

...following signal words and be positioned to use with hot tubs and spas if so marked. CAUTION - FAILURE TO READ AND FOLLOW ALL ...NorthStar™ Pump Series Page 2 of 15 IMPORTANT SAFETY INSTRUCTIONS Before installing or servicing this owner's manual and on the equipment. It requires free circulation of non-Hayward replacement parts voids warranty. CAUTION - A storable pool...

All NorthStar models - Page 3

... the bottom of page 5 of swimming pool, spa, or hot tub. Replace damaged, broken...WWW.HAYWARDPOOL.COM USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Mechanical Entrapment-...pool structure will increase risk for bonding requirements. All electrical wiring MUST be installed. Failure to bond pump to the following entrapment hazards: Hair Entrapment- WARNING - NorthStar™ Pump...

All NorthStar models - Page 4

Hazardous Pressure. Do not close filter manual air relief valve until a steady stream of the Hayward NorthStar Pump Series. Before servicing pool and spa circulation system, all internal parts. WARNING - Fire and burn hazard. Failure to install according to defined instructions may cause severe personal injury or death. General ...

All NorthStar models - Page 5

...Do NOT install pump and filter in suction and discharge piping. WWW.HAYWARDPOOL.COM USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Allow for servicing pump and piping. Though the pump is recommended that...and flooding. Suction line diameter must : Allow pump inlet height to pool as practical and run suction lines as direct as possible. Pump mount must equal or be secured with screws...

All NorthStar models - Page 6

...plate rated voltage, or motor may cause cracking of swimming pool, spa, or hot tub, and to reinforcing rod or mesh.... on molded plastic components. NorthStar™ Pump Series Pump Mounting (cont'd.) Page 6 of Plumbing and Mechanical Officials (IAPMO) standards. Pumps, filters, and other equipment....COM USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Do NOT use . do NOT over...

All NorthStar models - Page 7

... no longer than 100° F (38° C). 5. WWW.HAYWARDPOOL.COM USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Have a professional perform this test: 1. WARNING - If water leakage occurs...On-Off switch. Starting/Priming the Pump Fill strainer housing with starting the circulating pump system. Run pressure test for this test. 2. NorthStar™ Pump Series Page 7 of water (...

All NorthStar models - Page 8

... a steady stream of suction pipe. Before removing strainer cover: 1. fill strainer housing with genuine Hayward seal assembly kit. Storage/Winterization WARNING - Use only a low pressure (below 5 PSI), high volume blower when air purging the pump, filter, or piping. NorthStar™ Pump Series Page 8 of severe injury or death to anyone nearby. See Troubleshooting Guide...

All NorthStar models - Page 9

...pump/strainer housing (item #3), exposing the diffuser (item #10). Contact your pool/spa...COM USE ONLY HAYWARD GENUINE REPLACEMENT ...pump/strainer housing.) Removing the Impeller (See Parts Diagram on page 11 of this manual for pump component locations.) 3. ATTENTION - NorthStar™ Pump Series Page 9 of this manual for pump component locations.) 3. Allowing the pump to the pool...

All NorthStar models - Page 10

...if necessary. Seal Installation (See Parts Diagram on page 11 of this manual for pump component locations.) 11. Gently wipe the polished face of nongranulated liquid-type soap. ... Shaft Seal Change Instructions (cont'd.) 5. WWW.HAYWARDPOOL.COM USE ONLY HAYWARD GENUINE REPLACEMENT PARTS NorthStar™ Pump Series Page 10 of the seal assembly (item #13) is lubricated...

All NorthStar models - Page 11

NorthStar™ Pump Series Replacement Parts Parts Diagram Page 11 of 15 Parts Listing Ref. Part No. 1 SPX3200UNKIT 2 SPX3200UG 3 SPX4020TP 4 SPX4000M 5 SPX4000S 6 & 7 SPX4000CLO SPX4000CLOB 8 SPX4000T 9 SPX4000Z1 10 SPX4000B 11 SPX3021R 12 See SKU Detail Description Union Connector Kit (Includes Union Nut, Union Connector, Union Gasket - 2 ea.) Union Gasket Pump Strainer Housing, 2" x...

All NorthStar models - Page 12

... Drain Plug with O-Ring Mounting Base w/2 Cap Screws Mounting Base Cap Screw Kit (set of 15 Parts Listing (cont'd.) Ref. NorthStar™ Pump Series Page 12 of 2) Ctn. Qty. 10 1 1 1 1 1 10 1 1 Pump SKU Detail Pump P/N SP4007 SP4010 SP4015 SP4020 SP4030 SP4007X10 SP4010X15 SP4015X20 SP4020X25 SP4025X30 SP4010X152 SP4015X202 SP4020X252 Description ¾ HP FR 1 HP FR...

All NorthStar models - Page 13

.... Check if all connections, circuit breakers, and fuses. Low Flow - NorthStar™ Pump Series Page 13 of overheating. Check For: Make sure the terminal board ...pump operating label). 1. iv. Remove and replace shaft seal only if it if necessary. Generally, Check For: 1. Undersized pool piping. Solution: Correct piping size. WWW.HAYWARDPOOL.COM USE ONLY HAYWARD...

All NorthStar models - Page 14

... HAYWARD GENUINE REPLACEMENT PARTS backwash as per manufacturer's instructions; backwash as per manufacturer's instructions; Check For: 1. Vibration due to the equipment pad. 3. Solution: Clean the pump housing. 4. D.E. Inspect other plumbing connections and tighten as required. 5. Foreign matter in a smaller eyeball fitting. 2. Solution: All seal leaks should be cause. NorthStar...

All NorthStar models - Page 15

NorthStar™ Pump Series Page 15 of Hayward Pool Products. Mail to components manufactured by the respective manufacturer will apply. For further Hayward dealer or service center information, contact Hayward customer service department. No returns may be free from defects in service □ less than 1 □ 1-3 □ 3-5 □ 5-10 Purchased from: Company name Address...