Hayward NorthStar Support Question
Hayward NorthStar Support Question
Find answers below for this question about Hayward NorthStar.Need a Hayward NorthStar manual? We have 1 online manual for this item!
Question posted by AtheTina on April 25th, 2014
How To Wire Hayward Northstar Dual Speed Pool Pump
The person who posted this question about this Hayward product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related Hayward NorthStar Manual Pages
All NorthStar models - Page 1
... OPERATION, & PARTS
NorthStarTM Pump Series
*50HZ Models are not UL Listed. The Hayward NorthStar Pump is equipped with large capacity filters, heaters, and pool cleaning equipment. The advanced ... The NorthStar is a self-priming pump that includes an improved seal and impeller design that is specifically engineered for the demanding requirements of today's in-ground swimming pool/spa that ...
All NorthStar models - Page 2
... advised to use on the equipment. All electrical wiring MUST be inspected frequently and replaced at all instructions in conformance with storable pools. Do not install in this manual, look for use or climb on your pump or in a damp or non-ventilated location.
NorthStar™ Pump Series
Page 2 of 15
IMPORTANT SAFETY INSTRUCTIONS
Before...
All NorthStar models - Page 3
...other general wiring procedures.
NorthStar™ Pump Series
Page 3 of Electric Shock. All electrical wiring MUST be...HAYWARD GENUINE REPLACEMENT PARTS To reduce the risk of two functioning suction outlets per pump installed in conformance with all wiring standards including, but not limited to avoid "dual blockage" by a person, a minimum of electric shock, do NOT use pool or spa...
All NorthStar models - Page 4
... not close filter manual air relief valve until a steady stream of the Hayward NorthStar Pump Series.
Motors operate at more than 50 PSI. Tri-Lock design makes strainer... the motor to cool for burns. WARNING - WARNING -
NorthStar™ Pump Series
Page 4 of pump components. Do not operate pool and spa circulation system if a system component is running.
WARNING - ...
All NorthStar models - Page 5
... in line.
NorthStar™ Pump Series Product Specifications
Page 5 of short, direct suction pipe (to reduce friction losses). This product should have continuous slope upward from lowest point in the shade to shield them from excess moisture and flooding.
Be protected from continuous direct heat. WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT...
All NorthStar models - Page 6
...overheat, causing overload tripping and reduced component life. Fire Hazard - NorthStar™ Pump Series Pump Mounting (cont'd.)
Page 6 of swimming pool, spa, or hot tub, and to motor nameplate voltage. All plastic.... 8 AWG (8.4 mm2) solid copper bonding wire to the pressure wire connector provided on electrical connections. WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
All NorthStar models - Page 7
...hours. NorthStar™ Pump Series
Page 7 of water (not air...HAYWARD GENUINE REPLACEMENT PARTS Pump MUST be OPEN, as well as the Master On-Off switch. If other lights or appliances are sealed properly to ensure pump is being pressure tested (50 PSI MAXIMUM), be in the system by fully opening filter manual air relief valve until a
steady stream of 15
Electrical (cont'd.)
Wiring...
All NorthStar models - Page 8
... pool/spa system directly in severe personal injury. Before removing strainer cover:
1. STOP PUMP before re-starting pump, see "Starting/Priming the Pump" instructions. If water source is higher than the pump,...cause components to explode, with risk of 15
Starting/Priming the Pump (cont'd.)
WARNING - NorthStar™ Pump Series
Page 8 of severe injury or death to anyone nearby.
...
All NorthStar models - Page 9
... ALL INSTRUCTIONS When servicing electrical equipment, basic safety precautions should attempt rotary seal replacement. Disconnect all inlets to pump before draining pump. B. Only qualified personnel should always be twisted off.
4. Contact your pool/spa system. A. Slide the motor assembly out of 15
Storage/Winterization (cont'd.)
ATTENTION - Pull the diffuser off the cap...
All NorthStar models - Page 10
...Press the ceramic seat with a dilute solution of this manual for pump component locations.)
8. black polished surface facing the ceramic seat.
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Remove the seal plate (item #14). Seal Installation...'d.)
5. Tighten snugly by using the two (2) hex shaped screws. NorthStar™ Pump Series
Page 10 of this manual for...
All NorthStar models - Page 11
... (Biguanide Sanitizer Applications Only; NOT Pressure Testable) Seal Plate O-Ring Diffuser O-Ring Diffuser Impeller Ring
Impeller Kit (Includes Impeller, Impeller Ring, Seal Assy)
Ctn. No. NorthStar™ Pump Series
Replacement Parts
Parts Diagram
Page 11 of 15
Parts Listing
Ref.
All NorthStar models - Page 12
... 2 HP MR 2 SP 2 ½ HP MR 2 SP
Note: FR: Full Rate Pump MR: Max Rate Pump 2 SP: Dual Speed Pump
Impeller Kit P/N SPX4007CKIT SPX4010CKIT SPX4015CKIT SPX4020CKIT SPX4030CKIT SPX4007CKIT SPX4010CKIT SPX4015CKIT SPX4020CKIT SPX4025CKIT SPX4010CKIT SPX4015CKIT SPX4020CKIT
Motor ....HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS No. NorthStar™ Pump Series
Page 12 of 2)
...
All NorthStar models - Page 13
... the wiring diagram on suction side. Empty pump/strainer housing. Solution: Refer to cut On/Off until the problem is clean. Motor Hums, But Does NOT Start - Any self-priming pump will continue to Steps 4 & 5 of overheating. Low Flow - Solution: Contact a qualified repair professional. 2. WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS NorthStar™ Pump...
All NorthStar models - Page 14
... caused by restricted or undersized suction line or leak at once.
© Hayward Pool Products, 2007 All rights reserved.
Motor bearings noisy from return fittings). NorthStar™ Pump Series
Page 14 of filter, valve partially closed (high gauge reading). Air leak in pool, and unrestricted discharge return lines.
Solution: Correct suction condition or throttle return...
All NorthStar models - Page 15
...state.
*Supersedes all previous publications.
NorthStar™ Pump Series
Page 15 of 15
HAYWARD® LIMITED WARRANTY
This pump was inspected before shipment from the...others.
The Hayward Pool Products warranty does not apply to be returned, transportation paid, to the place of Hayward Pool Products.
To original purchasers of this pump, Hayward Pool Products warrants its...
Similar Questions
Hayward Northstar Pool Pump .where Is The Capacitor?
(Posted by omidmsirro 9 years ago)
Can You Replace Motor Burn Out On Hayward Ecostar Variabke Speed Pool Pump?
(Posted by timar 9 years ago)
How To Install The Electric For Northstar Pool Pump
(Posted by ismaesa 10 years ago)