Troy-Bilt TB225 Support Question
Troy-Bilt TB225 Support Question
Find answers below for this question about Troy-Bilt TB225.Need a Troy-Bilt TB225 manual? We have 1 online manual for this item!
Question posted by sparrish269 on May 22nd, 2018
Trouble Starting
I have a Troy bilt tb225 tiller and I can't get it to start plug looks good acts like its not getting spark to it though any suggestions?
Current Answers
Answer #1: Posted by Odin on May 22nd, 2018 8:50 AM
Odin
Member since:
April 10th, 2010 Points: 41,236,710
Member since:
April 10th, 2010 Points: 41,236,710
See https://www.repairclinic.com/RepairHelp/Tiller-Repair/24-323-1928107-/Troy-Bilt-Tiller-TB225-ModelTroubleshooting. The links most likely to solve are listed fifth and first.
Hope this is useful. Please don't forget to click the Accept This Answer button if you do accept it. My aim is to provide reliable helpful answers, not just a lot of them. See https://www.helpowl.com/profile/Odin.
Related Troy-Bilt TB225 Manual Pages
Operation Manual - Page 1
Operator's Manual
2-Cycle Gas Cultivator
TB225
TABLE OF CONTENTS Service Information 1 Rules for Safe Operation 2 Know Your Unit 5 Specifications 5 Assembly Instructions 6 Oil and Fuel Information 7 Starting and Stopping Instructions 8 Operating Instructions 9 Maintenance and Repair 10 Cleaning and Storage 13 Troubleshooting Chart 14 Warranty Information 16
SAVE THESE INSTRUCTIONS
...
Operation Manual - Page 2
... precautions:
• Store fuel only in any
spilled fuel from the unit immediately before starting the unit. Never remove the fuel tank cap or add fuel when the engine is ...; Inspect the unit before starting the engine.
All U.S. CALIFORNIA PROPOSITION 65
WARNING: Engine exhaust, some of its vapors
can explode if ignited.
Be familiar with a spark arrestor, maintained in order to...
Operation Manual - Page 3
...good artificial light.
• Avoid accidental starting. Allow the unit to Starting...get extremely hot from grass, leaves, excessive grease or carbon build up.
• If the unit starts to instruct other users. Do not operate the unit with fuel in the tank, inside a building where
fumes may reach an open flame (pilot lights, etc.) or sparks... the spark plug wire....cause of trouble. Take...
Operation Manual - Page 4
...before installing or removing the tines, or before cleaning or performing any maintenance. Be in a stable position while starting position whenever pulling the starter rope. • SAFETY & INTERNATIONAL SYMBOLS •
This operator's manual describes ... unit. Read the operator's manual for a short time.
• GARDEN CULTIVATORS - These parts get burned. May be in the starting .
4
Operation Manual - Page 5
...Displacement 25 cc (1.52 cu. We reserve the right to medium soil • Cultivating in .) Spark Plug Gap 0.025 inch (0.635 mm) Spark Plug Champion® RDJ7J or equivalent plug Lubrication Fuel/Oil Mixture Fuel/Oil Ratio 40:1 Fuel Tank Capacity 10 ounces (295 ml) Cultivating...• Cultivating sod and light to make changes at the time of printing. in garden areas, around trees, etc.
Operation Manual - Page 7
...instructions carefully for specific gas and oil mixing ratios. Using Blended Fuels
If you use a good 2-cycle oil designed for spilt fuel. NEVER add fuel additives directly to use the fresh fuel...It has been proven that may explode. Keep sparks and open flames at least 30 ft. (9.1 m) from the fuel container and
the fueling site before starting the engine. Remove the fuel cap. 3....
Operation Manual - Page 8
... serious injury, the operator and unit must be seen in a stable position while starting position (Fig. 6). STARTING INSTRUCTIONS
1. Move the choke lever to squeeze the throttle control. Continue to Position... in the OFF (O) position until fuel is in place. Hold the starter rope with oil. Start/On (I ) position at all times (Fig. 4).
3. Allow the engine to Fueling the Unit...
Operation Manual - Page 9
...squeeze the throttle control to starting the engine. If the tines are familiar with the ground (Fig. 7). 5. ADJUSTING THE TINE DEPTH The tines should penetrate most garden soils approximately 4 to ...clear the ground. 3.
WARNING: To prevent serious personal injury, use . Reconnect the spark plug wire and continue use extreme
caution when reversing or pulling the unit towards you are ...
Operation Manual - Page 10
... and re-oil the air filter.
All 4 tines should also be replaced at the frequency stated in the table. Grasp the spark plug wire
firmly and pull the cap from starting accidentally. Remove the click pins from the operating position. Always allow it to the shaft with the hubs facing in towards each...
Operation Manual - Page 11
...Reinstall the air filter cover. NOTE: Careless adjustments can cause permanent damage to your unit. Start the engine and let it to spread and remove excess oil. 6. NOTE: The tines should...not rotate during idle speed
adjustments. Apply enough clean SAE 30 motor oil to the Starting and Stopping Instructions. Tighten the cover screw to prevent serious personal injury. Checking the...
Operation Manual - Page 12
... 0.025 in the engine could damage the cylinder.
3. REPLACING THE SPARK PLUG
1. Grit in . (0.635 mm) (Fig. 12).
5. Reconnect the spark plug wire.
0.025 in .•lb. (12.3-13.5 N•m). Grasp the spark plug wire firmly and pull the cap from around the spark plug. socket counterclockwise.
Tighten the spark plug with a replacement part #753-06193, Champion® RDJ7J or...
Operation Manual - Page 13
...Allow the engine to distribute the oil. Pull the starter rope slowly to cool. NOTE: Remove the spark plug and drain all fuel has been drained from the cylinder before storing. • Store the unit in ...Repair or replace damaged parts and tighten loose screws, nuts or bolts. Reinstall the fuel cap. Start the engine and allow it to cool before you clean or service it stalls. The unit ...
Operation Manual - Page 14
...
CAUSE ENGINE WILL NOT START Empty fuel tank Primer bulb wasn't pressed enough
Engine is flooded
The fuel is old (over 30 days) and/or improperly mixed Fouled spark plug
ACTION
Fill fuel tank with...the fuel tank and add fresh, properly mixed fuel Replace or clean the spark plug
ENGINE WILL NOT IDLE Air filter is plugged The fuel is old (over 30 days) and/or improperly mixed Improper...
Operation Manual - Page 16
... in this Warranty. Box 361131, Cleveland, OH 44136-0019. C. Spark Plugs, Carburetor Adjustments, Filters B. Troy-Bilt shall not be liable for incidental or consequential loss or damages including,... through Troy-Bilt's authorized channels of the use or misuse or inability to use of any Troy-Bilt Product without limitation, expenses incurred for substitute or replacement lawn care ...
Similar Questions
Troy Bilt 22tb Weed Eater Trouble
Mt Troy-Bilt 2TB Weed Eater has had Bumper and Head replaced 2 times. Both were replaces because Bum...
Mt Troy-Bilt 2TB Weed Eater has had Bumper and Head replaced 2 times. Both were replaces because Bum...
(Posted by denisstpierre1961 1 year ago)
Is The Throttle Cable Adjustable On The Troy Bilt Tb225 Tiller? Also What Would
is the throttle cable adustable on the tb225 tiller and also what would make the fuel not stay in th...
is the throttle cable adustable on the tb225 tiller and also what would make the fuel not stay in th...
(Posted by tw285j 1 year ago)
Troy-bilt Tb225
I have this tiller model it was only used twice. It has new fuel and new spark plugs, getting fuel a...
I have this tiller model it was only used twice. It has new fuel and new spark plugs, getting fuel a...
(Posted by donniebailey1962 2 years ago)
Tb225 Starter Rope Replacement. How To Replace The Starter Rope On A Troy-bilt T
how to replace the starter rope on a Troy-Bilt TB 225 garden cultivator?
how to replace the starter rope on a Troy-Bilt TB 225 garden cultivator?
(Posted by hamptona0000 5 years ago)
How To Repair Troy-bilt Tb225 Starter Rope
how to repair Troy-bilt tb225 starter rope
how to repair Troy-bilt tb225 starter rope
(Posted by Rrodock 10 years ago)