Troy-Bilt TB225 Support Question
Troy-Bilt TB225 Support Question
Find answers below for this question about Troy-Bilt TB225.Need a Troy-Bilt TB225 manual? We have 1 online manual for this item!
Question posted by tw285j on August 16th, 2022
Is The Throttle Cable Adjustable On The Troy Bilt Tb225 Tiller? Also What Would
is the throttle cable adustable on the tb225 tiller and also what would make the fuel not stay in the primer bulb it seems to be disappearing but i can't find a leak. Thanks
Current Answers
Answer #1: Posted by ViejoMenace on September 1st, 2022 9:54 PM
ViejoMenace
Member since:
August 19th, 2022 Points: 14,850
Member since:
August 19th, 2022 Points: 14,850
Hi, there's no throttle cable adjustment for your machine. The primer not holding prime is likely a check valve or metering valve in the carburetor failing or a break in the fuel line allowing air in instead of fuel. The easy DIY answer would be to order replacements, there are a lot of Chinese aftermarket carbs listed online very inexpensive compared to original equipment ones. Your call there...
Related Troy-Bilt TB225 Manual Pages
Operation Manual - Page 1
...'s Manual
2-Cycle Gas Cultivator
TB225
TABLE OF CONTENTS Service Information 1 Rules for Safe Operation 2 Know Your Unit 5 Specifications 5 Assembly Instructions 6 Oil and Fuel Information 7 Starting and Stopping ..., controls, operation or maintenance of the unit, please call the Customer Support Department to make changes at 1-800-828-5500 in the United States or 1-800-668-1238 in this...
Operation Manual - Page 2
...U.S. Wash hands after handling.
Make sure all warnings and safety... • Squeeze the throttle control and check that ...adjustments or repairs before starting the unit.
SYMBOL MEANING
DANGER: Signals an EXTREME hazard. Failure to do not by law that may be
followed. Do not smoke.
• Never operate the unit without the fuel...not substitutes for fuel leaks. keep these...
Operation Manual - Page 3
... These parts get extremely hot from one location to an authorized service dealer for an adjustment.
• Make sure the tines are not in a stable position while starting position whenever pulling the...
• Use the right tool. Use of children. • Never douse or squirt the unit with fuel in the tank, inside a building where
fumes may reach an open flame (pilot lights, etc.) or ...
Operation Manual - Page 4
....
• DO NOT USE E85 FUEL IN THIS UNIT
WARNING: It has ... RUN
• ON/OFF STOP CONTROL OFF or STOP
• PRIMER BULB Push primer bulb, fully and slowly, 10 times.
• CHOKE CONTROL 1. ...shield when needed.
• UNLEADED FUEL Always use clean, fresh unleaded fuel.
• OIL Refer to
...international symbols and pictographs that fuel containing
greater than 10% ethanol will likely damage ...
Operation Manual - Page 5
... Filter Cover
Muffler Spark Plug
Starter Rope Grip
Choke Lever
Throttle Control
Handlebar Knobs
Upper Handle On/Off Control
Primer Bulb
Tine Guard Gear Box
Fuel Cap Lower Handle Wheel Assembly
Tines
SPECIFICATIONS*
Engine Type Air-Cooled, 2-Cycle Displacement 25 cc (1.52 cu. in garden areas, around trees, etc. We reserve the right to medium...
Operation Manual - Page 6
... switch wires so they are smooth
and tight against the handlebar assembly. ASSEMBLY INSTRUCTIONS
INSTALLING AND ADJUSTING THE WHEEL ASSEMBLY
WARNING: To prevent serious personal injury, the wheel
assembly must be necessary to pinch the throttle cable or switch wires
when positioning the handlebar (Fig. 3). 3. Set the unit on its side (Fig. 1). 2. This...
Operation Manual - Page 7
... with one 3.2 oz. (95 ml) bottle of ignition for air-cooled engines along with unleaded gasoline in the fuel can severely damage the engine. Wipe up . 2. Using improperly mixed fuel can make fuel and oil separate. FUELING THE UNIT
WARNING: Gasoline is unavoidable, follow recommended precautions: • Always use a good 2-cycle oil designed for spilt...
Operation Manual - Page 8
... the primer bulb 10 times, slowly. Move the choke lever to Fueling the Unit. Continue to Position 3 (Fig. 5).
11. Pull the starter rope 3-8 times in the ON ( I )
Stop/Off (O) Fig. 4
Position 1 Position 2 Position 3
Fig. 5 Starting Position
Starter Rope
Fig. 6
STOPPING INSTRUCTIONS
1.
Release the throttle control.
Move the choke lever to squeeze the throttle control.
Make...
Operation Manual - Page 9
...back until the tines make contact with the ground...garden soils approximately 4 to cool.
Wear eye and ear/hearing protection. Start the unit as follows: 1. If necessary, adjust the tines as described in the Assembly Instructions section. 3. Refer to
increase the engine speed. 4. Do not wear short pants, sandals or operate barefoot. With the tines off the ground, squeeze the throttle...
Operation Manual - Page 10
... 4 tines should also be performed by an MTD authorized service dealer. Grasp the spark plug wire
firmly and pull the cap from the operating position. Make sure that the cultivator is running.
Refer to cool before servicing or repairing the unit. NOTE: All installation instructions are explained from the spark plug...
Operation Manual - Page 11
... damage your engine. 1. Release the throttle control and let the engine idle. If the engine stops, use a small Phillips screwdriver to turn the idle speed screw clockwise, 1/8 of a turn during engine idle. 3. Checking the fuel mixture, cleaning the air filter, and adjusting the idle speed screw should make carburetor adjustments. Open the air filter cover...
Operation Manual - Page 13
...2. Dispose of the oil from the carburetor. 3. NOTE: Remove the spark plug and drain all fuel has been drained from the cylinder before attempting to start the unit after storage. 4. The unit is... or bolts. This ensures that has been stored for more than 30
days. Reinstall the fuel cap. Reinstall the spark plug. Some household cleaners contain aromatic oils such as pine and lemon...
Operation Manual - Page 14
... ENGINE WILL NOT START Empty fuel tank Primer bulb wasn't pressed enough
Engine is flooded
The fuel is old (over 30 days) and/or improperly mixed Fouled spark plug
ACTION
Fill fuel tank with properly mixed fuel Press the primer bulb 10 times or until fuel is visible Place choke lever into position 3, squeeze the throttle trigger and pull the...
Operation Manual - Page 16
... in this product against defects in Canada.
Troy-Bilt reserves the right to change or improve the design of any Troy-Bilt Product without limitation, expenses incurred for substitute or replacement lawn care services, for transportation or for related ... Warranty. Damage resulting from the sales. Spark Plugs, Carburetor Adjustments, Filters B. Box 361131 Cleveland, OH 44136-0019
Similar Questions
Troy Bilt 22tb Weed Eater Trouble
Mt Troy-Bilt 2TB Weed Eater has had Bumper and Head replaced 2 times. Both were replaces because Bum...
Mt Troy-Bilt 2TB Weed Eater has had Bumper and Head replaced 2 times. Both were replaces because Bum...
(Posted by denisstpierre1961 1 year ago)
Troy-bilt Tb225
I have this tiller model it was only used twice. It has new fuel and new spark plugs, getting fuel a...
I have this tiller model it was only used twice. It has new fuel and new spark plugs, getting fuel a...
(Posted by donniebailey1962 3 years ago)
Troy Bilt Horse Garden Tiller
I just bought a Troy Bilt Horse garden tiller. It has an 8 horsepower engine and is probably 10-15 y...
I just bought a Troy Bilt Horse garden tiller. It has an 8 horsepower engine and is probably 10-15 y...
(Posted by jasonrogers1272 3 years ago)
My Troy Bilt Tb225 Tiller Will Not Start.
My tiller ran last week but I cannot get it to run now. I have spark, fresh fuel and I am not sure t...
My tiller ran last week but I cannot get it to run now. I have spark, fresh fuel and I am not sure t...
(Posted by davemcnees 8 years ago)
How To Repair Troy-bilt Tb225 Starter Rope
how to repair Troy-bilt tb225 starter rope
how to repair Troy-bilt tb225 starter rope
(Posted by Rrodock 10 years ago)