Poulan PD22H42STA Support and Manuals
Get Help and Manuals for this Poulan item
This item is in your list!
View All Support Options Below
Free Poulan PD22H42STA manuals!
Problems with Poulan PD22H42STA?
Ask a Question
Free Poulan PD22H42STA manuals!
Problems with Poulan PD22H42STA?
Ask a Question
Popular Poulan PD22H42STA Manual Pages
User Manual - Page 1
ALWAYS WEAR EYE PROTECTION DURING OPERATION
188781 Rev. 1 11.3.03 RD/MH Printed in serious injury. Failure to do so can result in U.S.A. IMPORTANT MANUAL
Do Not Throw Away
02478
OWNER'S MANUAL
MODEL:
PD22H42STA
LAWN TRACTOR
WARNING:
Read this Owner's Manual and follow allWarnings and Safety Instructions.
User Manual - Page 2
...mower discharge direction and do not mow it at anyone enters the area.
• Never carry passengers. • Do not mow in speed or direction. Always turn off blades, set... and replace with manufacturer...servicing
Do not make adjustments or repairs...parts...RIDE-ON MOWERS
IMPORTANT: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. I. instructions...
manual and...
User Manual - Page 4
...We have similar laws. In the state of this manual). TABLE OF CONTENTS
SAFETY RULES 2-3 PRODUCT SPECIFICATIONS 4 CUSTOMER RESPONSIBILITIES 4 ASSEMBLY 6-8 OPERATION 9-15 MAINTENANCE SCHEDULE 16
MAINTENANCE 16-19 SERVICE AND ADJUSTMENTS 20-25 STORAGE 26 TROUBLESHOOTING 27-28 REPAIR PARTS - PRODUCT SPECIFICATIONS
GASOLINE CAPACITY AND TYPE:
4.0 GALLONS UNLEADED REGULAR
OIL TYPE...
User Manual - Page 6
... REQUIRED FOR ASSEMBLY
A socket wrench set will make assembly easier. INSERT
1/2 HEX NUT
LARGE FLAT WASHER
TO REMOVE TRACTOR FROM CARTON
UNPACK CARTON
• Remove all accessible loose parts and parts cartons from carton .
• Cut along dotted lines on label (label located between terminals) charge battery for charging instructions).
6 Remove end panels and...
User Manual - Page 8
...replacing motion and mower blade drive belts in flated for best cutting results. (Tires must be properly leveled. Follow proper starting and transmission purging instructions (See "TO START ENGINE" and "PURGE TRANSMISSION" in the Service and Adjustments section of this manual. Your mower...;ector shield in "PRODUCT
SPECIFICATIONS" section of this manual. CHECK FOR PROPER POSITION OF...
User Manual - Page 17
.... (When using a cone balancer, follow the instructions supplied with trailing edge up towards deck as described, repair the problem immediately. • The engine should not start unless the clutch/brake
pedal is fully depressed and attachement clutch control is in the Service and Adjustments section of this manual).
• Keep tires free of the blade...
User Manual - Page 19
... tractor and mower.
of all foreign matter.
• Keep finished surfaces and wheels free of all times. We do not recommend using a dirty air filter. Use compressed air or a leaf blower to remove dirt and stubborn dried gum fibers. THEY MAY CAUSE DETERIORATION OF THE CARTRIDGE.
SPARK PLUGS
Replace spark plugs...
User Manual - Page 22
.... Engage parking brake.
SERVICE AND ADJUSTMENTS
TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 22)
The mower blade drive belt may be adjusted or the pads need to manually push the tractor forward. The rear wheels must be replaced. TO ADJUST BRAKE • Depress clutch/brake pedal all
belt guides. • Install mower (See "To Install Mower" in all pulley grooves...
User Manual - Page 23
...mower...parts dealer. WASHERS RETAINING RING
AXLE COVER
SQUARE KEY (REAR WHEEL ONLY)
FIG. 26
23
Insert square key.
• Replace...instructions in the Assembly section of this manual. Do not lose).
• Repair tire and reassemble.
• On rear wheels only: align grooves in axle groove.
• Replace...camber, contact your nearest authorized service center/department. Tire sealant also...
User Manual - Page 26
..., clean it thoroughly, remove all dirt, grease, leaves, etc.
TRACTOR
Remove mower from dust and dirt. • Cover your tractor with a suitable protective cover that all rusted or chipped paint surfaces; placement instructions in the Service and Adjustments section of this manual). • Lubricate as shown in the fuel tank or permanent damage may...
User Manual - Page 28
... an authorized service center/ department. Level mower deck. 3.
Frozen idler pulley. 4. Replace mower drive belt. 3. Replace blade mandrel.
Blades improperly installed. 10. Shift to open vent holes. Clean underside of grass, leaves and trash under mower. 4. Check/replace light switch. 4.
Faulty alternator.
1.
Place freewheel control in this manual. 11...
User Manual - Page 33
MODEL NUMBER PD22H42STA
KEY PART NO. inches 1 inch = 25.4 ...17490508 Screw Thdrol 6/16-18 x 1/2 TYT
38 175710
Bracket Asm Pivot Mower Rear
39 174714
Bracket Pivot
58 185949
Duct Air
60 72140606 Bolt RDHD ... Window
219 17000512 Screw 5/16-18 x 3/4
258 183835X599 Lens Grille Pro RH
259 183834X599 Lens Grille Pro LH
261 183829Z428 Insert Grille
263 183832
Bezel Grille LH
264 183833
Bezel...
User Manual - Page 43
MODEL NUMBER PD22H42STA
KEY PART NO. NO. DESCRIPTION
1 182032X421 Mower Deck Assembly, 42"
2 72140506 Bolt
3 138017
Bracket Asm Fr. ing mowers only)
- - 139775
Blade Mulching 42" Premium (For
better wear when mulching)
- - 138971
Blade Mower... Bracket Asm. Whl Ga. Whl Ga. Pulley Not Included)
- - 184563
Replacement Mower, Complete
(Std. Sway Bar 3/42
4 165460
Bracket Asm Deck 42" Sway...
User Manual - Page 45
inches 1 inch = 25.4 mm
45 MODEL NUMBER PD22H42STA
KEY PART NO. DESCRIPTION
1 159461
Wire Asm Inner/Sprg W/plunger
2 159476
Shaft Asm Lift RH w/Inf
3 178981
Pin Groove 2"
4 12000002 E Ring #5133-62
5 19211621 Washer 21/32...Indicator Height STLT
49 145212
Nut Hex Flange Lock
50 110452X Nut PUsh Phos & Oi
NOTE: All component dimensions given in U.S.
NO. MOWER LIFT
TRACTOR - -
User Manual - Page 48
...appearance of the nearest service dealer (under "saws" for Chain Saws
or under "lawn mowers" for parts and service should be necessary during the life of its authorized distributors and dealers;
Model Number/Manufacturer's I.D. Description of purchase. 2. Consult your local local dealer for updated information and assistance. Number. For replacement parts, have available the following...
Poulan PD22H42STA Reviews
Do you have an experience with the Poulan PD22H42STA that you would like to share?
Earn 750 points for your review!
We have not received any reviews for Poulan yet.
Earn 750 points for your review!