TravelMate 630 Service Guide
Page 2
SmartCard slot Add Note for the updates made on Travelmate 630 service guide. Date 02/23/2002 02/25/2002 03/14/2002 03/19/2002 03/22/2002 Chapter Chapter 1 Chapter 5 Chapter 1 Chapter 1 Chapter 1 Updates Modify battery specifications. Revision History Please refer to the table below for RF receiver socket Delet " One PS/2 keyboard/mouse port" in Features and item 9 " speaker-outputs sound in Front View, and correct the board layout top view " Line-out Port" and " Line-in Port" II Add PCB number Correct Typo-
SmartCard slot Add Note for the updates made on Travelmate 630 service guide. Date 02/23/2002 02/25/2002 03/14/2002 03/19/2002 03/22/2002 Chapter Chapter 1 Chapter 5 Chapter 1 Chapter 1 Chapter 1 Updates Modify battery specifications. Revision History Please refer to the table below for RF receiver socket Delet " One PS/2 keyboard/mouse port" in Features and item 9 " speaker-outputs sound in Front View, and correct the board layout top view " Line-out Port" and " Line-in Port" II Add PCB number Correct Typo-
TravelMate 630 Service Guide
Page 3
...any particular purpose. Pentium and Pentium II/III are trademarks and/or registered trademarks of their purchase, the buyer (and not Acer Incorporated, its distributor, or its dealer) assumes the entire cost of all necessary servicing, repair, and any incidental or ... is sold or licensed "as is subject to the contents hereof and specifically disclaims any warranties of Acer Incorporated. No part of Acer Corporation. Any Acer Incorporated software described in any form or by Acer Incorporated. Should the programs prove defective following their respective holders. All rights...
...any particular purpose. Pentium and Pentium II/III are trademarks and/or registered trademarks of their purchase, the buyer (and not Acer Incorporated, its distributor, or its dealer) assumes the entire cost of all necessary servicing, repair, and any incidental or ... is sold or licensed "as is subject to the contents hereof and specifically disclaims any warranties of Acer Incorporated. No part of Acer Corporation. Any Acer Incorporated software described in any form or by Acer Incorporated. Should the programs prove defective following their respective holders. All rights...
TravelMate 630 Service Guide
Page 4
Conventions The following conventions are used in this manual: Screen messages NOTE WARNING CAUTION IMPORTANT Denotes actual messages that might result from doing or not doing specific actions. Alerts you to do specific actions relevant to the accomplishment of additional information related to any damage that appear on screen. Gives bits and pieces of procedures. Gives precautionary measures to avoid possible hardware or software problems. Reminds you to the current topic. IV
Conventions The following conventions are used in this manual: Screen messages NOTE WARNING CAUTION IMPORTANT Denotes actual messages that might result from doing or not doing specific actions. Alerts you to do specific actions relevant to the accomplishment of additional information related to any damage that appear on screen. Gives bits and pieces of procedures. Gives precautionary measures to avoid possible hardware or software problems. Reminds you to the current topic. IV
TravelMate 630 Service Guide
Page 7
Table of Contents Chapter 1 System Specifications 1 Features 1 System Block Diagram 3 Board Layout 4 Top View 4 Bottom View 5 Outlook View 6 Front View 6 Left Panel 7 Right Panel 8 Rear Panel 9 Bottom Panel 10 Indicators 11 ...Lock Keys 12 Embedded Numeric Keypad 13 Windows Keys 14 Hot Keys 15 Launch Keys 17 Touchpad 18 Touchpad Basics 18 Hardware Specifications and Configurations 20 Chapter 2 System Utilities 31 BIOS Setup Utility 31 Navigating the BIOS Utility 31 System Information 32 Main System Settings 33 Startup Configuration...
Table of Contents Chapter 1 System Specifications 1 Features 1 System Block Diagram 3 Board Layout 4 Top View 4 Bottom View 5 Outlook View 6 Front View 6 Left Panel 7 Right Panel 8 Rear Panel 9 Bottom Panel 10 Indicators 11 ...Lock Keys 12 Embedded Numeric Keypad 13 Windows Keys 14 Hot Keys 15 Launch Keys 17 Touchpad 18 Touchpad Basics 18 Hardware Specifications and Configurations 20 Chapter 2 System Utilities 31 BIOS Setup Utility 31 Navigating the BIOS Utility 31 System Information 32 Main System Settings 33 Startup Configuration...
TravelMate 630 Service Guide
Page 11
... cache and Intel® SpeedStepTM technology support ! 64-bit memory bus ! Smart Card interface with pre-boot authentication systems as security feature Display ! ! ! ! ! ! Chapter 1 System Specifications Features This computer was designed with the user in microphone High-speed optical drive (AcerMedia bay) Connectivity ! Li-Ion main battery pack ! Thin-Film Transistor...
... cache and Intel® SpeedStepTM technology support ! 64-bit memory bus ! Smart Card interface with pre-boot authentication systems as security feature Display ! ! ! ! ! ! Chapter 1 System Specifications Features This computer was designed with the user in microphone High-speed optical drive (AcerMedia bay) Connectivity ! Li-Ion main battery pack ! Thin-Film Transistor...
TravelMate 630 Service Guide
Page 24
Below are a few examples: ! + Tab (Activates next taskbar button) Windows + E (Explores My Computer) ! + F (Finds Document) ! + M (Minimizes All) j + ! + M (Undoes Minimize All) ! + R (Displays the Run...dialog box) Opens a context menu (same as a right-click). 14 Chapter 1 Key Windows logo key Application key Icon Description Start button. Windows Keys The keyboard has two keys that perform Windows-specific functions. Combinations with this key perform shortcut functions.
Below are a few examples: ! + Tab (Activates next taskbar button) Windows + E (Explores My Computer) ! + F (Finds Document) ! + M (Minimizes All) j + ! + M (Undoes Minimize All) ! + R (Displays the Run...dialog box) Opens a context menu (same as a right-click). 14 Chapter 1 Key Windows logo key Application key Icon Description Start button. Windows Keys The keyboard has two keys that perform Windows-specific functions. Combinations with this key perform shortcut functions.
TravelMate 630 Service Guide
Page 30
... Supports DIMM type Supports DIMM Speed Supports DIMM voltage Supports DIMM package Memory module combinations Specification Intel Pentium IV 1.5/1.6/1.7 GHz processor with 512KB L2 on-die Cache Micro-FCPGA package 1.40V/1.15V 1.25V Specification Phoenix V 4.0 R6.1 Flash ROM 512KB 32-pin TSOP ACPI 1.0b, APM 1.2,...Microsoft Simple Boot Flag Set by switch, see SW2(SW1) setting Built-in CPU 512KB Always enabled Always enabled Fixed in write-back Specification Specification Built-in Intel Amador-M 0MB 2 sockets (2 banks) 512MB 1024MB Synchronous DDR 266 MHz 3.3V 200-pin soDIMM You can install ...
... Supports DIMM type Supports DIMM Speed Supports DIMM voltage Supports DIMM package Memory module combinations Specification Intel Pentium IV 1.5/1.6/1.7 GHz processor with 512KB L2 on-die Cache Micro-FCPGA package 1.40V/1.15V 1.25V Specification Phoenix V 4.0 R6.1 Flash ROM 512KB 32-pin TSOP ACPI 1.0b, APM 1.2,...Microsoft Simple Boot Flag Set by switch, see SW2(SW1) setting Built-in CPU 512KB Always enabled Always enabled Fixed in write-back Specification Specification Built-in Intel Amador-M 0MB 2 sockets (2 banks) 512MB 1024MB Synchronous DDR 266 MHz 3.3V 200-pin soDIMM You can install ...
TravelMate 630 Service Guide
Page 31
... Interface Item Chipset Fax modem data baud rate (bps) Data modem data baud rate (bps) Supports modem protocol Modem connector type Modem connector location Specification Ambit MDC module with various capacities to form other combinations. Memory Combinations Slot 1 Slot 2 Total Memory 0 MB 64 MB 64 MB 64 MB 0 MB 64 ...
... Interface Item Chipset Fax modem data baud rate (bps) Data modem data baud rate (bps) Supports modem protocol Modem connector type Modem connector location Specification Ambit MDC module with various capacities to form other combinations. Memory Combinations Slot 1 Slot 2 Total Memory 0 MB 64 MB 64 MB 64 MB 0 MB 64 ...
TravelMate 630 Service Guide
Page 32
...transfer rate (diskbuffer, Mbytes/s) Data transfer rate (host~buffer, Mbytes/s) DC Power Requirements Voltage tolerance Toshiba MK2018GAP 20GB 20000 512 16 Specification IBM Travelstar 20GB IC25N020ATCS04 20000 512 3 16 IBM Travelstar 30 GB IC25N030ATCS04 30000 512 4 16 2 4200RPM 2 4200 RPM 2 4200... mode-5 Ultra DMA mode-5 2048KB ATA-5 235 100 MB/Sec. Floppy Disk Drive Interface Item Vendor & model name Floppy Disk Specifications Media recognition Sectors/track Tracks Data transfer rate (Kbit/s) Rotational speed (RPM) Read/write heads 2 Encoding method Power Requirement Input Voltage...
...transfer rate (diskbuffer, Mbytes/s) Data transfer rate (host~buffer, Mbytes/s) DC Power Requirements Voltage tolerance Toshiba MK2018GAP 20GB 20000 512 16 Specification IBM Travelstar 20GB IC25N020ATCS04 20000 512 3 16 IBM Travelstar 30 GB IC25N030ATCS04 30000 512 4 16 2 4200RPM 2 4200 RPM 2 4200... mode-5 Ultra DMA mode-5 2048KB ATA-5 235 100 MB/Sec. Floppy Disk Drive Interface Item Vendor & model name Floppy Disk Specifications Media recognition Sectors/track Tracks Data transfer rate (Kbit/s) Rotational speed (RPM) Read/write heads 2 Encoding method Power Requirement Input Voltage...
TravelMate 630 Service Guide
Page 33
... optional Mono or Stereo Resolution Compatibility Mixed sound source Voice channel Sampling rate Internal microphone Internal speaker / Quantity Supports PnP DMA channel Supports PnP IRQ Specification DVD: DVD-5, DVD-9, DVD-10, DVD-R (3.95G) CD: CD-Audio, CD-ROM (mode 1 and mode 2), CD-ROM XA (mode 2, ...Item Chip vendor and model name Chip voltage Supports ZV (Zoomed Video) port Graph interface Maximum resolution (LCD) Maximum resolution (CRT) Specification NVIDIA GeforceGO 100 Core/2.5V Memory/2.5V No 4X AGP (Accelerated Graphics Port) bus 1600x12000 (32 bit colors) 1920x1200(32 bit colors...
... optional Mono or Stereo Resolution Compatibility Mixed sound source Voice channel Sampling rate Internal microphone Internal speaker / Quantity Supports PnP DMA channel Supports PnP IRQ Specification DVD: DVD-5, DVD-9, DVD-10, DVD-R (3.95G) CD: CD-Audio, CD-ROM (mode 1 and mode 2), CD-ROM XA (mode 2, ...Item Chip vendor and model name Chip voltage Supports ZV (Zoomed Video) port Graph interface Maximum resolution (LCD) Maximum resolution (CRT) Specification NVIDIA GeforceGO 100 Core/2.5V Memory/2.5V No 4X AGP (Accelerated Graphics Port) bus 1600x12000 (32 bit colors) 1920x1200(32 bit colors...
TravelMate 630 Service Guide
Page 34
... Supports ECP/EPP Optional ECP DMA channel (in BIOS Setup) Optional parallel port I/O address (in BIOS Setup) Optional parallel port IRQ (in BIOS Setup) Specification Ali 1535+ 1 Rear side 25-pin D-type connector, in female type Enable/Disable by BIOS Setup Yes (set by BIOS setup) DMA channel 0,1, 2...port Supports 16550 UART Connector type Location Serial port function control Optional serial port (in BIOS Setup) Optional serial port IRQ (in BIOS Setup) Specification Ali 1535+ 1 Yes 9-pin D-type connector, in male type Rear side Enable/Disable by BIOS Setup 3F8h, 2F8h, 3E8h, 2E8h IRQ3, ...
... Supports ECP/EPP Optional ECP DMA channel (in BIOS Setup) Optional parallel port I/O address (in BIOS Setup) Optional parallel port IRQ (in BIOS Setup) Specification Ali 1535+ 1 Rear side 25-pin D-type connector, in female type Enable/Disable by BIOS Setup Yes (set by BIOS setup) DMA channel 0,1, 2...port Supports 16550 UART Connector type Location Serial port function control Optional serial port (in BIOS Setup) Optional serial port IRQ (in BIOS Setup) Specification Ali 1535+ 1 Yes 9-pin D-type connector, in male type Rear side Enable/Disable by BIOS Setup 3F8h, 2F8h, 3E8h, 2E8h IRQ3, ...
TravelMate 630 Service Guide
Page 36
... Ambit Sumida Ambit T621194.02 Sumida IV09117/T 8.5 (min.) - - 310(min.) - 1600(min.) 40 (min.) 50(min.) Iout(Min) 0mA Iout(Max) 5.5mA Specification 12 (typ.) 360(typ.) 600 (typ.) 54(typ.) 0.6mA 6.0mA 1.2mA 6.5mA 21 (max.) 1 (max.) 410(max.) 70 (max.) 58(max.) Vadj... to update the ID information. NOTE: There is turned on. Keyboard Item Windows 95 keys Yes Internal & external keyboard work simultaneously Yes Specification Battery Item Vendor & model name Battery Type Pack capacity Cell voltage Number of LCD brightness. If you replace a new inverter or replace the...
... Ambit Sumida Ambit T621194.02 Sumida IV09117/T 8.5 (min.) - - 310(min.) - 1600(min.) 40 (min.) 50(min.) Iout(Min) 0mA Iout(Max) 5.5mA Specification 12 (typ.) 360(typ.) 600 (typ.) 54(typ.) 0.6mA 6.0mA 1.2mA 6.5mA 21 (max.) 1 (max.) 410(max.) 70 (max.) 58(max.) Vadj... to update the ID information. NOTE: There is turned on. Keyboard Item Windows 95 keys Yes Internal & external keyboard work simultaneously Yes Specification Battery Item Vendor & model name Battery Type Pack capacity Cell voltage Number of LCD brightness. If you replace a new inverter or replace the...
TravelMate 630 Service Guide
Page 37
...no smoke) 15kV (at air discharge) 8kV (at contact discharge) 1500 Vac (or 2121 Vdc), 10 mA for LCD backlight (Vrms) 700 Specification No 3.3 660 AC Adapter Item Vendor & model name Input Requirements Maximum input current (A, @90Vac, full load) Nominal frequency (Hz) Frequency ...Over Voltage Protection (OVP) Short circuit protection Electrostatic discharge (ESD) Dielectric Withstand Voltage Primary to secondary Leakage current Regulatory Requirements Delta ADP-65DB BE Specification 1.5 A @ 90Vac 0.9 A @ 180Vac 47 - 63 47 - 63 90 - 270 The maximum inrush current will be less than 50A...
...no smoke) 15kV (at air discharge) 8kV (at contact discharge) 1500 Vac (or 2121 Vdc), 10 mA for LCD backlight (Vrms) 700 Specification No 3.3 660 AC Adapter Item Vendor & model name Input Requirements Maximum input current (A, @90Vac, full load) Nominal frequency (Hz) Frequency ...Over Voltage Protection (OVP) Short circuit protection Electrostatic discharge (ESD) Dielectric Withstand Voltage Primary to secondary Leakage current Regulatory Requirements Delta ADP-65DB BE Specification 1.5 A @ 90Vac 0.9 A @ 180Vac 47 - 63 47 - 63 90 - 270 The maximum inrush current will be less than 50A...
TravelMate 630 Service Guide
Page 38
...-off) Environmental Requirements Temperature Operating Item Non-operating Non-operating Humidity Operating Non-operating Non-operating Vibration Operating (unpacked) Non-operating (unpacked) Non-operating (packed) Specification +5~+35 °C -10~+65 °C -20~+65 °C (storage package) 20% to 80% RH, non-condensing 20% to 80% RH, non-condensing (unpacked) 20% to...
...-off) Environmental Requirements Temperature Operating Item Non-operating Non-operating Humidity Operating Non-operating Non-operating Vibration Operating (unpacked) Non-operating (unpacked) Non-operating (packed) Specification +5~+35 °C -10~+65 °C -20~+65 °C (storage package) 20% to 80% RH, non-condensing 20% to 80% RH, non-condensing (unpacked) 20% to...
TravelMate 630 Service Guide
Page 39
... 180-18F 170-177 1F0-1F7 220-22F 240-24F 278-27F 2E8-2EF 2F8-2FF 378, 37A I /O Ports Item Drive Bays Material Indicators Switch Specification 327.6 (W) x 270 (D) x 34.5(H) for 15.0" TFT less than 5.75 lbs for 15.0" TFT model Two type II CardBus socket(s), One RJ-11 modem ...port, One port replicator connector, Two USB ports, One audio line-out jack, One microphone-in jack, One 1394 port, One Kensington lock. Mechanical Specification Dimensions Weight I /O Address 512 KB 40 KB 128 KB Size Function System BIOS UMB Area VGA BIOS Video memory (VRAM) Conventional memory Function DMA ...
... 180-18F 170-177 1F0-1F7 220-22F 240-24F 278-27F 2E8-2EF 2F8-2FF 378, 37A I /O Ports Item Drive Bays Material Indicators Switch Specification 327.6 (W) x 270 (D) x 34.5(H) for 15.0" TFT less than 5.75 lbs for 15.0" TFT model Two type II CardBus socket(s), One RJ-11 modem ...port, One port replicator connector, Two USB ports, One audio line-out jack, One microphone-in jack, One 1394 port, One Kensington lock. Mechanical Specification Dimensions Weight I /O Address 512 KB 40 KB 128 KB Size Function System BIOS UMB Area VGA BIOS Video memory (VRAM) Conventional memory Function DMA ...
TravelMate 630 Service Guide
Page 43
... field. PhoenixBIOS Setup Utility Information Main Advanced Security Boot Exit System Time: System Date: Boot Display Screen Expansion [08:46:55] [03/27/2001] Item Specific Help [Auto] [Enabled] ,,or selects field QuickBoot Mode [Enabled] Boot-time Diagnostic Screen: [Disable] Boot on LAN Hotkey Beep [Disable] [Enable] Auto Dimm F12 Multi...
... field. PhoenixBIOS Setup Utility Information Main Advanced Security Boot Exit System Time: System Date: Boot Display Screen Expansion [08:46:55] [03/27/2001] Item Specific Help [Auto] [Enabled] ,,or selects field QuickBoot Mode [Enabled] Boot-time Diagnostic Screen: [Disable] Boot on LAN Hotkey Beep [Disable] [Enable] Auto Dimm F12 Multi...
TravelMate 630 Service Guide
Page 45
PhoenixBIOS Setup Utility Information Main Advanced Security Boot Exit CPU Speed Legacy Diskette A: [High] [1.44/1.25MB 3 ½"] Item Specific Help >Primary Master >Secondary Master [TOSHIBA MK2018GAP-(PM)] [MATSHITADVD-ROM SR-81] Temporary solution >I /O Device Configuration PCI IRQ Routing USB Host Controller Description Set CPU ...
PhoenixBIOS Setup Utility Information Main Advanced Security Boot Exit CPU Speed Legacy Diskette A: [High] [1.44/1.25MB 3 ½"] Item Specific Help >Primary Master >Secondary Master [TOSHIBA MK2018GAP-(PM)] [MATSHITADVD-ROM SR-81] Temporary solution >I /O Device Configuration PCI IRQ Routing USB Host Controller Description Set CPU ...
TravelMate 630 Service Guide
Page 46
... hard-disk drive installed at this connection. ATAPI Removable = removable disk drive is installed here. PhoenixBIOS Setup Utility Advanced Primary Master [TOSHIBA MK2018GAP-(PM)] Item Specific Help Type: Total Sectors: Maximum Capacity: [Auto] LBA Format 39070080 20004MB Multi-Sector Transfers: LBA Mode Control: 32 Bit I/O: Transfer Mode: Ultra DMA Mode: SMART...
... hard-disk drive installed at this connection. ATAPI Removable = removable disk drive is installed here. PhoenixBIOS Setup Utility Advanced Primary Master [TOSHIBA MK2018GAP-(PM)] Item Specific Help Type: Total Sectors: Maximum Capacity: [Auto] LBA Format 39070080 20004MB Multi-Sector Transfers: LBA Mode Control: 32 Bit I/O: Transfer Mode: Ultra DMA Mode: SMART...
TravelMate 630 Service Guide
Page 47
... Exit %& Select Menu Enter Select > Sub Menu F10 Save and Exit Chapter 2 37 PhoenixBIOS Setup Utility Advanced Secondary Master [MATSHITADVD-ROM SR-8176-(SM)] Item Specific Help Type: [Auto] Multi-Sector Transfers: LBA Mode Control: 32 Bit I/O: Transfer Mode: Ultra DMA Mode: SMART Monitoring: [Disabled] [Disabled] [Disabled] [Standard] [Disabled] Disabled User...
... Exit %& Select Menu Enter Select > Sub Menu F10 Save and Exit Chapter 2 37 PhoenixBIOS Setup Utility Advanced Secondary Master [MATSHITADVD-ROM SR-8176-(SM)] Item Specific Help Type: [Auto] Multi-Sector Transfers: LBA Mode Control: 32 Bit I/O: Transfer Mode: Ultra DMA Mode: SMART Monitoring: [Disabled] [Disabled] [Disabled] [Standard] [Disabled] Disabled User...
TravelMate 630 Service Guide
Page 48
... > Sub Menu F10 Save and Exit 38 Chapter 2 I/O Device Configuration The parameters in this screen are already optimized. PhoenixBIOS Setup Utility Advanced I/O Device Configuration Item Specific Help Serial Port A: Base I/O Address : Interrupt: Serial Port B: Parallel Port: Base I /O Device Configuration screen assigns resources to change the values in this screen because these...
... > Sub Menu F10 Save and Exit 38 Chapter 2 I/O Device Configuration The parameters in this screen are already optimized. PhoenixBIOS Setup Utility Advanced I/O Device Configuration Item Specific Help Serial Port A: Base I/O Address : Interrupt: Serial Port B: Parallel Port: Base I /O Device Configuration screen assigns resources to change the values in this screen because these...