Poulan PP165E30 Support and Manuals
Get Help and Manuals for this Poulan item
This item is in your list!
View All Support Options Below
Free Poulan PP165E30 manuals!
Problems with Poulan PP165E30?
Ask a Question
Free Poulan PP165E30 manuals!
Problems with Poulan PP165E30?
Ask a Question
Popular Poulan PP165E30 Manual Pages
User Manual - Page 1
Failure to do so can result in the U.S.A.
IMPORTANT MANUAL
Do Not Throw Away
OWNER'S MANUAL
MODEL NUMBER:
PP165E30
SNOW THROWER
WARNING:
Read the Owner's Manual and follow all Warnings and Safety Instructions. Always Wear Eye Protection During Operation
437738 08.27.10 TH Printed in serious injury.
User Manual - Page 2
... the snow thrower.
WARNING: This snow thrower is for use a nozzle lock-open device.
(g) Replace gasoline cap securely and wipe up , transporting, adjusting or making any repairs, adjustments or inspections.
Never allow children to prevent accidental starting when setting up spilled fuel.
(h) If fuel is spilled on clothing, change clothing immediately.
5.
Wear footwear...
User Manual - Page 3
.../impeller. Always refer to operator's manual for proper tightness to service or repair this owner's manual.
TABLE OF CONTENTS
SAFETY RULES 2-3
MAINTENANCE SCHEDULE 14
PRODUCT SPECIFICATIONS 3
SERVICE AND ADJUSTMENTS 16-18
CUSTOMER RESPONSIBILITIES 3
STORAGE 19
ASSEMBLY / PRE-OPERATION 4-7
TROUBLESHOOTING 20
OPERATION 8-13
REPAIR PARTS 22-42
MAINTENANCE 14-15...
User Manual - Page 4
...parts such as necessary to ensure proper tightness.
2. Remove snow thrower from carton.
4
located on your new snow thrower. HOW TO SET...of the product. Reading the entire manual will assist you assemble must be tightened securely. PARTS PACKED SEPARATELY IN CARTON
(1) FUEL ... these instructions and this manual in its entirety before you attempt to assemble or operate your snow thrower....
User Manual - Page 12
....
2. See Storage Instructions for a few seconds...gasoline near an open flame.
To avoid engine problems, the fuel system should be reversed, providing additional service before storage of snow thrower.
• When ...be emptied before requiring replacement. If necessary, add oil until the fuel lines and carburetor are higher than the front of this manual. ADD GASOLINE (See ...
User Manual - Page 14
...snow thrower does not cover items that have been subjected to service this manual should replace the spark plug and check belts for wear.
Failure to do... once each season.
• Once a year, you should be replaced by original equipment manufacturer
local parts dealer. A new spark plug will need to
14 the snow thrower. ...instructed in the Service and Adjustments section of this manual.
User Manual - Page 15
...PLUG
Replace spark plug at least once
a year if the snow thrower is not used above components can result in the Service and Adjustments section of this manual. Spark plug type and gap setting ....
•
Check the crankcase oil level before next oil change.
Refill engine with lubricant to install klik pin into proper hole in wheel axle (See "TO REMOVE WHEELS" in a suitable container...
User Manual - Page 16
...in the Operation section of this manual.
WARNING: To avoid serious injury, never operate your snow thrower with plug. Wait for all moving parts to STOP position.
IMPELLER SHEAR ... chute, is engaged, check to any service or adjustments: 1. To replace the shear bolts:
1. Place wire where it cannot come in impeller shaft and install two (2) new 1/4-20 x 1-5/8" capscrew...
User Manual - Page 17
...replaced by a service center/department. BELT KEEPER
TRACTION DRIVE BELT
ENGINE PULLEY
FLAT WASHER
BOLT
IDLER ARM SQUARE HOLE
AUGER BELT
FRAME
CLUTCHING IDLER ARM BRACKET
AUGER PULLEY
AUGER HOUSING
BOLTS
6. REMOVE AUGER BELT from around and inside belt keeper.
16. The V-belts on idler, install...While your assistant standing in this manual.
4. Install flat washer, bolt and tighten...
User Manual - Page 18
...PIN (INSTALL IN OUTER...manual. CARBURETOR
Your carburetor is snug. If your engine does not operate properly due to 7,000 feet (2,134 meters).
Overspeeding the engine above the factory high speed setting can be affected at altitudes up to suspected carburetor problems, take your model...qualified service center, which is factory set ... installing wheel, be purchased from axle. SERVICE AND ...
User Manual - Page 19
...manual).
2. Inspect and replace belts, if necessary (See "TO REPLACE BELTS" in a safe place.
• Do not store gasoline from one ounce (29 ml) of fuel gum deposits during storage. Inspect moving parts for damage, breakage and wear. ENGINE
See engine manual...gas appliance. Rust and/or dirt in your gasoline will cause problems.
• If possible, store your snow thrower indoors and ...
User Manual - Page 20
....
20 Out of drive speed 3. Stale fuel. 11. Clean or replace muffler. Empty fuel tank & carburetor, refill with ice or snow. 4.
Check / reinstall drive belt. TROUBLESHOOTING
See appropriate section in fuel line. 3. Spark plug wire loose. 2. Dirty or clogged muffler.
1. Blockage in manual unless directed to pull
1. Clean fuel line. 3. Empty fuel tank...
User Manual - Page 27
... 15 AND 16 ARE SERVICE PART NUMBERS TO ALLOW PURCHASE OF INDIVIDUAL ITEMS IF NECESSARY. ALL ITEMS INDICATED WITH AN * ARE PROVIDED IN THE BAG OF ITEMS SHIPPED LOOSE WITH PRODUCT. 2.
NOTE: All component dimensions given in U.S. MODEL PP165E30 (96198003700)
CONTROL PANEL / DISCHARGE CHUTE
5
7 15
3 16
*14 *11
2
4
6 *10
KEY PART
6
NO. REPAIR PARTS
SNOW THROWER -
User Manual - Page 29
...your warranty.
29
NO. MODEL PP165E30 (96198003700)
4
4 3
2
3
4
4
3
3
KEY PART NO.
DESCRIPTION
1
419797X431 LOWER HANDLE
4
2
427513X431 PIVOT SUPPORT WELDMENT
3
428867
SCREW ...REPAIR PARTS HANDLES
SNOW THROWER - DESCRIPTION
1
419798X431 LOOP HANDLE LH
2
419799X431 LOOP HANDLE RH
3 14
74780524 751153
SCREW 5/16−18 X 1.50 NUT 5/16−18
01.08.004-B
1
KEY PART...
User Manual - Page 44
..., GA 30907 USA
In Canada contact:
Poulan, Customer Service Department 5855 Terry Fox Way Mississauga, Ontario L5V 3E4
giving the complete mfg.
This Warranty gives you specific legal rights, and you may not apply to you have any products used for parts or labor incurred in accordance with the instructions furnished.
For a period of two...
Poulan PP165E30 Reviews
Do you have an experience with the Poulan PP165E30 that you would like to share?
Earn 750 points for your review!
We have not received any reviews for Poulan yet.
Earn 750 points for your review!