Poulan 96194000901 Support and Manuals
Get Help and Manuals for this Poulan item
This item is in your list!
View All Support Options Below
Free Poulan 96194000901 manuals!
Problems with Poulan 96194000901?
Ask a Question
Free Poulan 96194000901 manuals!
Problems with Poulan 96194000901?
Ask a Question
Popular Poulan 96194000901 Manual Pages
User Manual - Page 1
Always Wear Eye Protection During Operation
435560 Rev 2 08.04.10 TH
Printed in serious injury. IMPORTANT MANUAL
Do Not Throw Away
OWNER'S MANUAL
MODEL NUMBER:
961940009
SNOW THROWER
WARNING:
Read the Owner's Manual and follow all Warnings and Safety Instructions.
Failure to do so can result in U.S.A.
User Manual - Page 2
...parts become extremely hot during operation or while performing an adjustment or repair to avoid slipping or falling, especially when operating the snow thrower in serious injury. Do not operate the equipment without proper instruction...thrower is spilled on the ground, away from your vehicle, before starting when setting up spilled fuel.
(h) If fuel is for use snow thrower on or cross...
User Manual - Page 3
...manual.
TABLE OF CONTENTS
SAFETY RULES 2-3
MAINTENANCE 14-15
PRODUCT SPECIFICATIONS 3
SERVICE AND ADJUSTMENTS 16-18
CUSTOMER RESPONSIBILITIES 3
STORAGE 19
ASSEMBLY / PRE-OPERATION 5-7
TROUBLESHOOTING 20
OPERATION 8-13
REPAIR PARTS... where ignition sources are dangerous.
8. Maintain or replace safety and instruction labels, as wheel weights, counterweights, or cabs)....
User Manual - Page 5
... are in handles. Install in lower holes in bag of carton and lay panels flat.
3.
Remove the two (2) plastic ties securing the upper handle to the skid plates. Use the correct tools as nuts, washers, bolts, etc., necessary to lower handle.
2. ASSEMBLY / PRE-OPERATION
Read these instructions and this manual in its entirety...
User Manual - Page 12
...manual.
Do not overfill.
To avoid engine problems, the fuel system should be reversed, providing additional service before storage of the housing, it can be emptied before requiring replacement...to adjust the skid plates.
See Storage Instructions for all moving skid plate to the ...by loosening the 1/2" hex nuts, then moving parts to give a 1/8" clearance between the scraper bar...
User Manual - Page 14
... this manual should be checked at least once each season.
• Once a year, you should replace the spark...instructed in Maintenance section
General Purpose Grease
Pivot points
LUBRICATION
Keep your snow thrower well lubricated (See "LUBRICATION CHART"). Check for wear. Some adjustments will help your engine run better and last longer.
• Follow the maintenance schedule in the Service...
User Manual - Page 15
... For approximate capacity see "PRODUCT SPECIFICATIONS" section of this manual.
9.
Select the oil's SAE ...Service and Adjustments section of operation and replace if necessary. Install drain plug and tighten securely.
5. Install left side wheel may be removed from your dealer...
See engine manual. Wipe off any spilled oil.
Spark plug type and gap setting are lifetime lubricated...
User Manual - Page 16
...parts have sheared. 16
FRAME
FIG. 21
SCREWS Insert safety ignition key and reconnect spark plug wire to frame.
2. If one or both of this manual.
BELT COVER
CAUTION: Do not substitute. SERVICE...thrower.
4. To replace the shear bolts:
1. Place wire where it should be replaced. Install 1/4-20 lock nut and tighten securely. Disengage all moving parts to spark plug....
User Manual - Page 18
... a qualified service center. SERVICE AND ADJUSTMENTS
TO REMOVE WHEELS (See Fig. 23)
• Remove the klik pin and remove wheel from your local parts dealer. If your engine does not operate properly due to suspected carburetor problems, take your snow thrower to make any necessary adjustments. Overspeeding the engine above the factory high speed setting can...
User Manual - Page 19
... spark plug hole into cylinder.
3.
SNOW THROWER
When snow thrower is an acceptable alternative in the Service and Adjustments section of acids during storage. Inspect moving parts for 30 days or more. Replace if necessary.
5. ENGINE
See engine manual. Also, alcohol blended fuels (called gasohol or using fuel stabilizer.
Remove spark plug.
2. Pour one...
User Manual - Page 20
... unless directed to pull
1. Engine idles or runs roughly
1.
Drive belt is off of this manual. TROUBLESHOOTING
See appropriate section in OFF position. 6.
PROBLEM
CAUSE
CORRECTION
Does not start
1. Insert safety ignition key.
3. Prime as instructed in fuel. 5. Wait a few minutes before restarting, DO NOT prime. 8. Empty fuel tank & carburetor, refill with fresh, clean...
User Manual - Page 25
... WITH PRODUCT. 2. ITEMS 15 AND 16 ARE SERVICE PART NUMBERS TO ALLOW PURCHASE OF INDIVIDUAL ITEMS IF NECESSARY. REPAIR PARTS
SNOW THROWER - MODEL 961940009 (96194000901)
CONTROL PANEL / DISCHARGE CHUTE
5
7 15
3 16
*14 *11
KEY PART
2
NO.
NO. inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. Failure to do so could be hazardous...
User Manual - Page 26
... PARTS ONLY.
2
1
KEY PART NO. DESCRIPTION
1
421249
STEER CABLE
2
74041024
SCREW 10−24 X 1.50
01.15.009-A
NOTE: All component dimensions given in U.S. Failure to do so could be hazardous, damage your snow thrower and void your warranty.
26 REPAIR PARTS
SNOW THROWER - inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts.
User Manual - Page 30
... PIVOT SUPPORT WELDMENT
3
428867
SCREW 5/16−18 X .750
4
17000616
SCREW 3/8−16 X 1.00
2
4
3
4 4
01-05-013-A
3 2
5 6
7
4
5
41
01.10.007-B
KEY NO.
1 2 3 4 5 6 7
PART NO....U.S. MODEL 961940009 (96194000901)
1
4 3
KEY PART NO. inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts.
REPAIR PARTS HANDLES
SNOW THROWER -
User Manual - Page 40
... properly assembled, adjusted, operated, and maintained in accordance with the instructions furnished. Please refer to the following limitations and exclusions.
1. The Warranty period for any part which we will repair or replace, at our option, without charge for parts or labor incurred in replacing parts, any products used for any unanswered questions concerning this Warranty are...
Poulan 96194000901 Reviews
Do you have an experience with the Poulan 96194000901 that you would like to share?
Earn 750 points for your review!
We have not received any reviews for Poulan yet.
Earn 750 points for your review!