LG DLG5988WM Support and Manuals
Get Help and Manuals for this LG item
View All Support Options Below
Free LG DLG5988WM manuals!
Problems with LG DLG5988WM?
Ask a Question
Free LG DLG5988WM manuals!
Problems with LG DLG5988WM?
Ask a Question
Popular LG DLG5988WM Manual Pages
Service Manual - Page 1
MODEL : DLE5977W/DLG5988W DLE5977B/DLG5988B DLE3777W/DLG3788W DLE5977WM/DLG5988WM DLE5977SM/DLG5988SM Website:http://www.LGservice.com [For U.S.A] www.lg.ca [For Canada]
ELECTRIC & GAS DRYER SERVICE MANUAL
CAUTION
READ THIS MANUAL CAREFULLY TO DIAGNOSE TROUBLES CORRECTLY BEFORE OFFERING SERVICE.
Service Manual - Page 2
... removing the part from a neighbor's phone. Do not use any liability in connection with its package, touch the anti-static bag to a green ground connection point or unpainted metal in the appliance. The new control assembly may damage or weaken the electronic control assembly. IMPORTANT SAFETY NOTICE
The information in this service guide is...
Service Manual - Page 5
...Options
5
5
No. Weight (lbs) : Net / Gross
124 / 144
No. of Dry Levels
5
5
Sound levels
High / Low / Off
Sensor
Moisture Temperature
Avaiable Avaiable
Electrode sensor Termistor
Reversible Door
Avaiable
Drum
Stainless Steel
Dryer Rack Child Lock
Avaiable Avaiable
Interior Light Product (WxHxD) Packing (WxHxD)
Avaiable
27" x 42 3/4 x 28 1/3 29 1/2" x 44 3/4 x 30 3/4
5
of...
Service Manual - Page 6
2 FEATURES AND BENEFITS
DLE5977W/DLG5988W/DLE5977B/DLG5988B/DLE5977WM/DLG5988WM/DLE5977SM/DLG5988SM
DLE3777W/DLG3788W
3 INSTALLATION INSTRUCTIONS
Dryer Rack Installation Instructions
1Open the door. Hold the dryer rack with both hands.
2 Put the dryer rack into the drum
3 Make sure that dryer is evenly placed right onto the drum inside and door rim.
6
Service Manual - Page 7
... secure installation, please observe the instructions below. Push the front stacking kit back to the stoppers of side stacking kit.
3
Fit the stacking kit side bracket firmly to the side of top plate by attaching the doublefaced tape to the stopper of the washer by 2 or more experienced service personnel.
5
Place the dryer on...
Service Manual - Page 8
... first.
1 Remove pedestal, installation hardware, and instructions from the bracket.
7 Move the dryer to the desired place. for dryer
.
Adjust the legs of the appliance and pedestal by turning with screws. Pedestal Installation Instructions
For washer, dryer, and combo LG 27
4 Attach the double-faced tape of the bracket to the dryer as shown so the bent parts of the brackets...
Service Manual - Page 13
...-
20min Saturation (66±5°C) (5min) (47±5°C)
3Hr
AIR DRY
-
-
30min
Saturation
No heater
N/A
N/A
Load
Motor Heater
Off Time: 6min On Time: 10sec Temperature Control for each cycle
* Sensor dry : "Dry Level" is set by users. ** Manual dry : "Temperature control" is set by users.
13 Temp- 4 DRYER CYCLE PROCESS
Cycle
Default
Conditions of operation and termination...
Service Manual - Page 16
...Thermostat (Auto reset)
• Check Top Marking : N95
13. Outlet Thermostat (Manual reset)
• Check Top Marking : N100
Test Procedure
Measure resistance of terminal ...terminal to terminal
Open at 212 ± 12°F (100 ± 7°C)
Manual reset
If thermal fuse is open must be replaced
Resistance value ∞
Continuity < 1Ω
• Gas type • Gas funnel
16 Component
13...
Service Manual - Page 20
... Door open may trip the Thermostat attached to the Heater, therefore do not activate it manually. (Do not press the door switch to the step 4. • Press Start 3... with damp cloth. Do not use this DIAGNOSTIC TEST other than specified.
2.
Unit must be used for Factory test /Service test. Buzzer beeps seven times
During check, Motor on & Heater If the door is below 180, in the end....
Service Manual - Page 22
Measure with the Ground.)
Trouble Symptom
During Diagnostic Test, tE1 and tE2 Error occur. During operation, Heater would not...2.2
22
Test 2 Thermistor Test --- Difference between terminals after separating Harness
NO
From Thermistor assembly Connector.
• Replace Thermistor. Check if resistance is in the range of Table 1 when measuring 6pin connector Pin (Blue wire) and ...
Service Manual - Page 23
... " (Yellow wire) and "BL2- No Heater will function; " (Brown wire)? YES
• Replace Control. (Relay check)
• Check Controller connector.
• Check if Door flame presses door switch ...; between terminals of Power cord with earth line.)
Trouble Symptom Drum will not rotate; Measurement Condition Turn the Dryer's Power Off, then measure resistance.
" (White wire) and "BL2-...
Service Manual - Page 24
...in Electric load, is resistance below 1Ω? YES
• Replace Control and Check.
IMC Ratio and Display Value / Voltage (...Dryer's Power Off, then measure resistance. Take 6pin Connector from Washing Machine
Damp Dry
10% ~ Dried clothes 205 ~ 240
Over 4.0V
Completely-dried clothes
24
Is the measurement within the range of dryness does not match with earth line.)
Trouble...
Service Manual - Page 26
... resistance, be sure to turn Power off , measure the resistance. Drying time takes longer. NO • Replace Heater. YES
Check Controller. TH3 TH2
1. Check Harness-linking Connector.
26
Check if the value of Power cord with earth line.)
Trouble Symptom
While operating, Heating will not work. YES
Check if the value of measured
resistance...
Service Manual - Page 27
...
• Change Valve
NO
• Harness check • Controller change
27
Trouble Symptom
While operating, Heating will not work.
Gas Type
Caution
When measuring power, be sure to wear insulated gloves, to avoid electric shock. Drying time takes longer. Measurement Condition With dryer power on "Valve 1", "Valve 2", Value is more than1.5 ~ 2.5kΩ? (Measure...
Service Manual - Page 28
... mode is on sale as a Service
Part to authorized servicers only. Disassemble the pipe assembly.
Gas type Orifice P/No Marking Shape Natural Gas 4948EL4001B NCU Propane Gas 4948EL4002B PCU
Kit contents : Orifice (Dia. = 1.613mm, for Propane Gas) : Replace Label : Instruction sheet
28
Propane Gas Orifice is set. Warning After Natural Gas Setting, applying Propane Gas Orifice or...
LG DLG5988WM Reviews
We have not received any reviews for LG yet.