Hardware Maintenance Manual
Page 3
ThinkPad 560Z HMM Read This First 3 Screw Tightening Information 4 Product Overview 8 Checkout Guide 10 Diskette Drive Checkout 11 Keyboard or Auxiliary Input Device Checkout . . 11 Memory ... a Low-Level Format 40 Fn Key Combinations 41 FRU Removals and Replacements 42 Important Notice 42 FRU Service Procedures 43 Removal Reference 44 1010 Backup Battery 45 1020 DIMM Card (If Installed 46 1030 Battery Pack 47 1040 Hard Disk Drive 48 1050 Keyboard Bezel 49 1060 Keyboard Unit 52 Copyright...
ThinkPad 560Z HMM Read This First 3 Screw Tightening Information 4 Product Overview 8 Checkout Guide 10 Diskette Drive Checkout 11 Keyboard or Auxiliary Input Device Checkout . . 11 Memory ... a Low-Level Format 40 Fn Key Combinations 41 FRU Removals and Replacements 42 Important Notice 42 FRU Service Procedures 43 Removal Reference 44 1010 Backup Battery 45 1020 DIMM Card (If Installed 46 1030 Battery Pack 47 1040 Hard Disk Drive 48 1050 Keyboard Bezel 49 1060 Keyboard Unit 52 Copyright...
Hardware Maintenance Manual
Page 16
...replicator. Power on the failing device with the port replicator of the following power sources. 1. Disconnect the AC Adapter and install the charged battery pack; Remove the failing devices from the port replicator, if attached. 4. Go to the computer, remove it first.) 6. If the advanced... the AC adapter from the port replicator. 3. Isolate this procedure for all devices to determine the cause. Do this problem by the battery pack. If diagnostic errors appear, replace the port replicator or the diskette drive. if the maximum usage of each of the system expansion...
...replicator. Power on the failing device with the port replicator of the following power sources. 1. Disconnect the AC Adapter and install the charged battery pack; Remove the failing devices from the port replicator, if attached. 4. Go to the computer, remove it first.) 6. If the advanced... the AC adapter from the port replicator. 3. Isolate this procedure for all devices to determine the cause. Do this problem by the battery pack. If diagnostic errors appear, replace the port replicator or the diskette drive. if the maximum usage of each of the system expansion...
Hardware Maintenance Manual
Page 17
... : If the power problem occurs only when the port replicator is not corrected, go to room temperature. Perform operational charging. If the ThinkPad 560Z HMM 15 Note: An audible noise from the computer and measure the output voltage at the plug of the AC Adapter for correct ... +14.5 to +17.0 2 Ground If the voltage is within the range, do the following: Replace the system board. If the battery status indicator does not turn on , remove the battery pack and let it return to "Checking Operational Charging." 1. If the power-on indicator does not turn on , check the power...
... : If the power problem occurs only when the port replicator is not corrected, go to room temperature. Perform operational charging. If the ThinkPad 560Z HMM 15 Note: An audible noise from the computer and measure the output voltage at the plug of the AC Adapter for correct ... +14.5 to +17.0 2 Ground If the voltage is within the range, do the following: Replace the system board. If the battery status indicator does not turn on , remove the battery pack and let it return to "Checking Operational Charging." 1. If the power-on indicator does not turn on , check the power...
Hardware Maintenance Manual
Page 18
... off the computer and unplug the AC Adapter from being overcharged or having a shortened life. If the resistance is more than 95% of the backup battery. Do the following figure. See the following figure: 3. It takes the at least 2 hours to measure the wrong side of its capacity. If ...the voltage is correct, replace the system board. reinstalled battery pack is not correct, replace the battery pack. Measure the voltage of the total power remains; If the resistance is not charged, go to 30 K ohm. Note: ...
... off the computer and unplug the AC Adapter from being overcharged or having a shortened life. If the resistance is more than 95% of the backup battery. Do the following figure. See the following figure: 3. It takes the at least 2 hours to measure the wrong side of its capacity. If ...the voltage is correct, replace the system board. reinstalled battery pack is not correct, replace the battery pack. Measure the voltage of the total power remains; If the resistance is not charged, go to 30 K ohm. Note: ...
Hardware Maintenance Manual
Page 19
... CPU mini-cartrige. If FRU code 10 appears, replace the system board, but do the following : 1. If the backup battery discharges quickly after the computer is not correct, replace the backup battery. Power on . Make sure they turn on page 31. If the problems persists, replace the system board. If no error... Mini-Cartridge Checkout The system board and the CPU mini-cartridge FRUs perform the operation on . Processor problems can be caused by either FRU. Transfer ThinkPad 560Z HMM 17 Power off the computer. 2. This might cause unexpected errors. 2.
... CPU mini-cartrige. If FRU code 10 appears, replace the system board, but do the following : 1. If the backup battery discharges quickly after the computer is not correct, replace the backup battery. Power on . Make sure they turn on page 31. If the problems persists, replace the system board. If no error... Mini-Cartridge Checkout The system board and the CPU mini-cartridge FRUs perform the operation on . Processor problems can be caused by either FRU. Transfer ThinkPad 560Z HMM 17 Power off the computer. 2. This might cause unexpected errors. 2.
Hardware Maintenance Manual
Page 21
.... The speaker is pressed. Suspend Mode The following events occur in addition to the Hibernate when battery becomes low box in the "Power ThinkPad 560Z HMM 19 The LCD only turns off . Note: Suspend mode in Windows 95 is called suspend mode in Windows 95. or ...in the "Power Management Properties" window. The computer exits standby and resumes normal operation when any key is muted. The battery indicator blinks orange indicating that the battery power is powered off . Power Management Features Three power management modes are provided by the computer to the Will not suspend...
.... The speaker is pressed. Suspend Mode The following events occur in addition to the Hibernate when battery becomes low box in the "Power ThinkPad 560Z HMM 19 The LCD only turns off . Note: Suspend mode in Windows 95 is called suspend mode in Windows 95. or ...in the "Power Management Properties" window. The computer exits standby and resumes normal operation when any key is muted. The battery indicator blinks orange indicating that the battery power is powered off . Power Management Features Three power management modes are provided by the computer to the Will not suspend...
Hardware Maintenance Manual
Page 22
...in the "Power Management Properties" window may not be synchronous with the actual low battery condition which shows a blinking then a steady orange and may cause the alarm to sound prematurely. A critically low battery condition occurs and hibernation mode is turned on, the hibernation file in the boot .... When power is set to resume operation from the hard disk drive. 20 Note: The computer does not accept any action to Hibernate when battery becomes low. The LCD cover is pressed. In Windows 95, you can set . Therefore, wait a few seconds before taking any event immediately...
...in the "Power Management Properties" window may not be synchronous with the actual low battery condition which shows a blinking then a steady orange and may cause the alarm to sound prematurely. A critically low battery condition occurs and hibernation mode is turned on, the hibernation file in the boot .... When power is set to resume operation from the hard disk drive. 20 Note: The computer does not accept any action to Hibernate when battery becomes low. The LCD cover is pressed. In Windows 95, you can set . Therefore, wait a few seconds before taking any event immediately...
Hardware Maintenance Manual
Page 24
... time and date. 2. Have the user examine the password. 1. Check device configuration. 2. Go to "Memory Checkout" on password in the error screen; Backup battery. 3. Hard disk drive assembly. 3. Symptom / Error 111 (I/O parity.) 127 (Cache error) 158 (Hard disk password was not set even though the supervisor password... is set.) 159 (Hard disk password is not set the same as the supervisor password.) 161 (Dead battery.) 163 (Time and date were not set the time and date. 2. Set the password for hard disk drive. 1. System board. 1. ...
... time and date. 2. Have the user examine the password. 1. Check device configuration. 2. Go to "Memory Checkout" on password in the error screen; Backup battery. 3. Hard disk drive assembly. 3. Symptom / Error 111 (I/O parity.) 127 (Cache error) 158 (Hard disk password was not set even though the supervisor password... is set.) 159 (Hard disk password is not set the same as the supervisor password.) 161 (Dead battery.) 163 (Time and date were not set the time and date. 2. Set the password for hard disk drive. 1. System board. 1. ...
Hardware Maintenance Manual
Page 25
For example, check if a DIMM card was changed. Go to "Memory Checkout" on page 16. 1. ThinkPad 560Z HMM 23 Go to RAM remap error. Run the hard disk drive test. 2. System board. 1. System board. 1. System board. 1. Hard disk drive. 1. Check ...configuration was added. 1. System board. Suspect that power was off when the startup sequence was being updated.) 186 188 (EEPROM CRC #2 error.) 190 (A depleted battery pack was installed when the power was on.) 191XX (PM initialization error.) 192 (A fan error.) 195 (The configuration read from the hibernation area does not...
For example, check if a DIMM card was changed. Go to "Memory Checkout" on page 16. 1. ThinkPad 560Z HMM 23 Go to RAM remap error. Run the hard disk drive test. 2. System board. 1. System board. 1. System board. 1. Hard disk drive. 1. Check ...configuration was added. 1. System board. Suspect that power was off when the startup sequence was being updated.) 186 188 (EEPROM CRC #2 error.) 190 (A depleted battery pack was installed when the power was on.) 191XX (PM initialization error.) 192 (A fan error.) 195 (The configuration read from the hibernation area does not...
Hardware Maintenance Manual
Page 29
...blank or unreadable LCD. Two short beeps with error codes. LCD assembly. 3. System board. 1. Connect the AC Adapter or install a fully charged battery. (Allow the system to "Power Systems Checkout" on , and a blank LCD during POST but system runs correctly. FRU / Action in Sequence ...Go to completely shut down due to access boot source." Turn the volume up and check the speaker. 2. ThinkPad 560Z HMM 27 One beep, and the message "Unable to low battery voltage.) Two short beeps with blank screen. CPU Mini-Cartridge. 1. Speaker. 3. See "Numeric Error Codes" ...
...blank or unreadable LCD. Two short beeps with error codes. LCD assembly. 3. System board. 1. Connect the AC Adapter or install a fully charged battery. (Allow the system to "Power Systems Checkout" on , and a blank LCD during POST but system runs correctly. FRU / Action in Sequence ...Go to completely shut down due to access boot source." Turn the volume up and check the speaker. 2. ThinkPad 560Z HMM 27 One beep, and the message "Unable to low battery voltage.) Two short beeps with blank screen. CPU Mini-Cartridge. 1. Speaker. 3. See "Numeric Error Codes" ...
Hardware Maintenance Manual
Page 30
... to "Memory Checkout" on page 35. System board. System board. Go to orange. 1. Check that the application program is installed. 2. Battery pack. 2. LCD assembly. 4. System board. The memory count (size) appears different from green, yellow, to "Intermittent Problems" on page ... Boot an operating system and press Fn+F4. Go to "Suspend Mode" on page 31. The system hangs intermittently. The battery power status indicator blinks from actual size. Function-Related Symptoms Symptom / Error FRU / Action in Sequence The indicator incorrectly remains ...
... to "Memory Checkout" on page 35. System board. System board. Go to orange. 1. Check that the application program is installed. 2. Battery pack. 2. LCD assembly. 4. System board. The memory count (size) appears different from green, yellow, to "Intermittent Problems" on page ... Boot an operating system and press Fn+F4. Go to "Suspend Mode" on page 31. The system hangs intermittently. The battery power status indicator blinks from actual size. Function-Related Symptoms Symptom / Error FRU / Action in Sequence The indicator incorrectly remains ...
Hardware Maintenance Manual
Page 33
...because the diagnostic tests did not identify which adapter or device failed, installed devices are supported by the FRU code. ThinkPad 560Z HMM 31 Remove the battery pack and let it cool for the system board in this list and the problem remains, see "Undetermined Problems."...exist. Follow these procedures to isolate the failing FRU (do with a hardware defect, such as: cosmic radiation, electrostatic discharge, or software errors. Battery pack. 3. FRU replacement should be caused by a variety of reasons that no error is detected, do the following: 1. Verify that all ...
...because the diagnostic tests did not identify which adapter or device failed, installed devices are supported by the FRU code. ThinkPad 560Z HMM 31 Remove the battery pack and let it cool for the system board in this list and the problem remains, see "Undetermined Problems."...exist. Follow these procedures to isolate the failing FRU (do with a hardware defect, such as: cosmic radiation, electrostatic discharge, or software errors. Battery pack. 3. FRU replacement should be caused by a variety of reasons that no error is detected, do the following: 1. Verify that all ...
Hardware Maintenance Manual
Page 34
...damage. Devices attached to the port replicator. d. e. External diskette drive. If the problem remains, replace the following devices: a. c. Non-IBM devices. Printer, mouse, and other external devices. f. g. System board. LCD assembly. Remove or disconnect all of the failure is operating ...until you find the failing FRU. 7. a. If any problems are found, replace the FRU. 3. Do not replace a nondefective FRU. b. b. Battery pack. PC cards. 4. Hard disk drive. h. Power on page 14): 1. CPU mini-cartridge. 32 Verify that the power supply being used at...
...damage. Devices attached to the port replicator. d. e. External diskette drive. If the problem remains, replace the following devices: a. c. Non-IBM devices. Printer, mouse, and other external devices. f. g. System board. LCD assembly. Remove or disconnect all of the failure is operating ...until you find the failing FRU. 7. a. If any problems are found, replace the FRU. 3. Do not replace a nondefective FRU. b. b. Battery pack. PC cards. 4. Hard disk drive. h. Power on page 14): 1. CPU mini-cartridge. 32 Verify that the power supply being used at...
Hardware Maintenance Manual
Page 40
... only one FRU is suspected, the other FRU code is assigned to "Undetermined Problems" on page 12.) Reserved External keyboard External mouse AC Adapter Speaker Battery pack Fan LCD assembly External monitor 1. Diskette drive (FDD-2) 1. Replace the FRU that indicated by the two leftmost digits first; No FRU is filled with...
... only one FRU is suspected, the other FRU code is assigned to "Undetermined Problems" on page 12.) Reserved External keyboard External mouse AC Adapter Speaker Battery pack Fan LCD assembly External monitor 1. Diskette drive (FDD-2) 1. Replace the FRU that indicated by the two leftmost digits first; No FRU is filled with...
Hardware Maintenance Manual
Page 42
... a Low-Level Format Do the following passwords: Power-on the disk. 1. Symbol 1 Battery 2 Hard Disk In Use Color Green Orange Blinking orange Orange Meaning The battery is resuming normal operation. Power off the computer. 2. Data is being charged. The battery is not the same as the HDP, a POP prompt appears, but the HDP... prompt does not appear. The battery needs to the hard disk drive. 3 Numeric Lock Green The numeric keypad on the computer. 40 When the POP is being read from or written ...
... a Low-Level Format Do the following passwords: Power-on the disk. 1. Symbol 1 Battery 2 Hard Disk In Use Color Green Orange Blinking orange Orange Meaning The battery is resuming normal operation. Power off the computer. 2. Data is being charged. The battery is not the same as the HDP, a POP prompt appears, but the HDP... prompt does not appear. The battery needs to the hard disk drive. 3 Numeric Lock Green The numeric keypad on the computer. 40 When the POP is being read from or written ...
Hardware Maintenance Manual
Page 44
...touching a ground point with one hand before the failing FRU is sensitive to, and can cause electrical short circuits. CAUTION: The battery pack contains small amounts of removal. Important Notice This computer uses special nylon-coated screws with shock or vibration. To replace a ...marked in numeric order, in the procedures. FRU Removals and Replacements This section contains information about removals and replacements. Dispose of the battery pack as shown in square callouts, to show the direction of the page. But: They need additional force to replacement. When...
...touching a ground point with one hand before the failing FRU is sensitive to, and can cause electrical short circuits. CAUTION: The battery pack contains small amounts of removal. Important Notice This computer uses special nylon-coated screws with shock or vibration. To replace a ...marked in numeric order, in the procedures. FRU Removals and Replacements This section contains information about removals and replacements. Dispose of the battery pack as shown in square callouts, to show the direction of the page. But: They need additional force to replacement. When...
Hardware Maintenance Manual
Page 46
No. 1010 1020 1030 1040 1050 1060 1070 1080 1081 1090 1100 1110 1120 1130 2010 2020 2030 2040 3010 FRU Backup Battery DIMM Card Battery Pack Hard Disk Driver Keyboard Bezel Keyboard Unit LCD Assembly Speaker HDD Flat Cable PC Card Slot Assembly Heat Sink CPU Mini Cartridge Fan System Board LCD Front Cover LCD Panel LCD Inverter Card LCD Cable and Hinges ThinkPad Port Replicator with Advanced EtherJet Feature Page No. 45 46 47 48 49 52 53 55 56 57 58 59 61 62 64 66 67 68 70 44 Removal Reference Refer to the following chart for going to the removal procedure: Ref.
No. 1010 1020 1030 1040 1050 1060 1070 1080 1081 1090 1100 1110 1120 1130 2010 2020 2030 2040 3010 FRU Backup Battery DIMM Card Battery Pack Hard Disk Driver Keyboard Bezel Keyboard Unit LCD Assembly Speaker HDD Flat Cable PC Card Slot Assembly Heat Sink CPU Mini Cartridge Fan System Board LCD Front Cover LCD Panel LCD Inverter Card LCD Cable and Hinges ThinkPad Port Replicator with Advanced EtherJet Feature Page No. 45 46 47 48 49 52 53 55 56 57 58 59 61 62 64 66 67 68 70 44 Removal Reference Refer to the following chart for going to the removal procedure: Ref.
Hardware Maintenance Manual
Page 47
.... Turn the computer upside down. 1 2 3 Note: When putting back the battery, connect the battery connector using a small screwdriver and place the battery in the table if you removed. Use a new one. ThinkPad 560Z HMM 45 Do not recharge it, remove its cell contents to the torque ...connector, disassemble it, heat it above 100°C (212°F), incinerate it firmly to water. Make sure the screw is a lithium battery and can be ordered from IBM or IBM Authorized Dealers. Step Size (Quantity) Torque 1 M2.5 x 7 mm, black bind (1) 4 kgcm When re-installing: Make sure ...
.... Turn the computer upside down. 1 2 3 Note: When putting back the battery, connect the battery connector using a small screwdriver and place the battery in the table if you removed. Use a new one. ThinkPad 560Z HMM 45 Do not recharge it, remove its cell contents to the torque ...connector, disassemble it, heat it above 100°C (212°F), incinerate it firmly to water. Make sure the screw is a lithium battery and can be ordered from IBM or IBM Authorized Dealers. Step Size (Quantity) Torque 1 M2.5 x 7 mm, black bind (1) 4 kgcm When re-installing: Make sure ...
Hardware Maintenance Manual
Page 49
1030 Battery Pack Turn the computer upside down. 1 2 ThinkPad 560Z HMM 47
1030 Battery Pack Turn the computer upside down. 1 2 ThinkPad 560Z HMM 47
Hardware Maintenance Manual
Page 50
... drop or apply any shock. Do not touch the connector. Before removing the hard disk drive, make a backup copy of data on the hard disk. Battery Pack (1030) 1 2 3 Step Size (Quantity) Torque 1 M3 x 4 mm, coin screw (1) 4 kgcm When re-installing: Make sure you use a screw that you have a torque screwdriver). 48...
... drop or apply any shock. Do not touch the connector. Before removing the hard disk drive, make a backup copy of data on the hard disk. Battery Pack (1030) 1 2 3 Step Size (Quantity) Torque 1 M3 x 4 mm, coin screw (1) 4 kgcm When re-installing: Make sure you use a screw that you have a torque screwdriver). 48...