Troy-Bilt TB225 Support Question
Troy-Bilt TB225 Support Question
Find answers below for this question about Troy-Bilt TB225.Need a Troy-Bilt TB225 manual? We have 1 online manual for this item!
Question posted by scottc65 on April 3rd, 2021
Tb 2225 Will Not Prime
I replaced fuel tank, primer bulb and fuel lines on my tb225 cultivator and it still won't prime. It builds pressure in the tank but fuel doesn't get into the carburetor. What can I do
Current Answers
Answer #1: Posted by Odin on May 5th, 2021 5:23 PM
Odin
Member since:
April 10th, 2010 Points: 41,236,670
Member since:
April 10th, 2010 Points: 41,236,670
See ENGINE WILL NOT START at https://www.manualslib.com/manual/591407/Troy-Bilt-Tb225.html?page=14.
If the issue persists or if you require further advice, you may want to consult the company: use the contact information at https://www.contacthelp.com/ttroy-bilt/customer-service.
If the issue persists or if you require further advice, you may want to consult the company: use the contact information at https://www.contacthelp.com/ttroy-bilt/customer-service.
Hope this is useful. Please don't forget to click the Accept This Answer button if you do accept it. My aim is to provide reliable helpful answers, not just a lot of them. See https://www.helpowl.com/profile/Odin.
Related Troy-Bilt TB225 Manual Pages
Operation Manual - Page 1
....troybilt.com (U.S.) or www.troybilt.ca (Canada). When servicing, use only identical replacement parts.
769-08657 / 00
All information, illustrations, and specifications in Canada. Copyright...Manual
2-Cycle Gas Cultivator
TB225
TABLE OF CONTENTS Service Information 1 Rules for Safe Operation 2 Know Your Unit 5 Specifications 5 Assembly Instructions 6 Oil and Fuel Information 7 Starting...
Operation Manual - Page 2
... fuel leaks.
Wash hands after handling. Replace damaged parts. Replace parts that it requires replacement, ask your careful attention and understanding. Encourage bystanders to liability or a fine. SAFETY WARNINGS FOR GAS UNITS
WARNING: Gasoline is hot.
Please keep them outside a 50-foot (15 m) radius, at risk from the fueling source and site before filling the fuel tank...
Operation Manual - Page 3
...are available from debris. Refer to Cleaning and Storage. • Clean the tines with fuel in the tank, inside a building where
fumes may reach an open flame (pilot lights, etc.) or sparks (switches, ...by a authorized service dealer.
• Before inspecting, servicing, cleaning, storing, transporting or replacing any gum buildup. Keep a firm grip on steep slopes or inclines.
• Use ...
Operation Manual - Page 4
...operator's manual for a short time.
• GARDEN CULTIVATORS - Use a full face shield when needed.
• UNLEADED FUEL Always use clean, fresh unleaded fuel.
• OIL Refer to operator's manual ... STOP CONTROL ON / START / RUN
• ON/OFF STOP CONTROL OFF or STOP
• PRIMER BULB Push primer bulb, fully and slowly, 10 times.
• CHOKE CONTROL 1. • FULL choke position 2. &#...
Operation Manual - Page 5
...
Choke Lever
Throttle Control
Handlebar Knobs
Upper Handle On/Off Control
Primer Bulb
Tine Guard Gear Box
Fuel Cap Lower Handle Wheel Assembly
Tines
SPECIFICATIONS*
Engine Type Air-Cooled, 2-Cycle Displacement 25 cc (1.52 cu. in garden areas, around trees, etc.
APPLICATION • Cultivating sod and light to make changes at the time of printing...
Operation Manual - Page 7
...).
Add 0.8 oz. (23 ml) of fuel additive per gallon of fuel according to the unit's fuel tank.
*WARNING: DO NOT USE E85 FUEL IN THIS UNIT. Do not smoke while filling the tank. WARNING: Add fuel in the fuel can make fuel and oil separate. Reinstall the fuel cap. 6. OIL AND FUEL INFORMATION
OIL AND FUEL MIXING INSTRUCTIONS
Old and/or improperly...
Operation Manual - Page 8
... (Fig. 4).
3. Throttle Control On/Off Control
Choke Lever Primer Bulb
Throttle Control
8 Make sure you are
in the starting position when pulling the starter rope (Fig. 6). Refer to squeeze the throttle control. Fill the fuel tank. Stand in the starting position (Fig. 6).
Continue to Oil and Fuel Mixing Instructions.
2. Pull the starter rope 3-5 times to...
Operation Manual - Page 9
... slowly lower the
unit until the tines make contact with the controls and the handling of the cultivator.
7. WARNING: To prevent serious personal injury, use .
ADJUSTING THE TINE DEPTH The tines should penetrate most garden soils approximately 4 to Adjusting Tine Depth. Reconnect the spark plug wire and continue use extreme
caution when...
Operation Manual - Page 10
...
convex sides are facing as the spark arrestor, muffler, carburetor, etc. Work on a flat level surface with the ...new tines with the handles
touching the ground so that the cultivator is running. NOTE: Each tine has a convex side.
... starting accidentally. Clean and oil the shaft. 5.
NOTE: Maintenance, replacement, or repair of the shaft. 4.
MAINTENANCE AND REPAIR
WARNING: To...
Operation Manual - Page 11
...by an authorized service dealer. Replace the air filter and the... or stalls on the air filter cover (Fig. 10). 8. Checking the fuel mixture, cleaning the air filter, and adjusting the idle speed screw should solve...high
speed (full throttle) to warm up.
NOTE: The tines should make carburetor adjustments. AIR FILTER MAINTENANCE
Cleaning the Air Filter
Failure to maintain your air filter...
Operation Manual - Page 12
... cap from around the spark plug. If the spark plug is cracked, fouled or dirty, replace it clockwise until snug. Install the spark plug in the engine could damage the cylinder.
...tighten.
6. Remove the spark plug from the cylinder head by turning a 5/8 in . (0.635 mm)
Fig. 12
12
REPLACING THE SPARK PLUG
1. Inspect the spark plug. Use a feeler gauge to : 110-120 in . (0.635 mm) (...
Operation Manual - Page 13
... lemon that all of the oil from the carburetor. 3. Reinstall the fuel cap. Start the engine and allow it to... keep
the air vents free of children. CLEANING • Use a small brush to clean off the outside of the unit and to cool before you clean or service it stalls. Long-term Storage 1. Pull the starter rope slowly to cool. Repair or replace...
Operation Manual - Page 14
...) and/or improperly mixed Fouled spark plug
ACTION
Fill fuel tank with properly mixed fuel Press the primer bulb 10 times or until fuel is visible Place choke lever into position 3, squeeze the throttle trigger and pull the starter rope Drain the fuel tank and add fresh, properly mixed fuel Replace or clean the spark plug
ENGINE WILL NOT IDLE...
Operation Manual - Page 16
... the following cases: A. Spark Plugs, Carburetor Adjustments, Filters B. No implied warranty,...Line, Inner Reels, Starter Pulley, Starter Ropes, Drive Belts, Saw Chains, Guide Bars,
Cultivator Tines, Blades. During the period of merchantability or fitness for rental expenses to temporarily replace..., expenses incurred for substitute or replacement lawn care services, for transportation or for...
Similar Questions
How To Replace Primer Bulb Lines On Tb675ec With A Two Port Primer
how do you replace the primer bulb lines on a tb676ec with a two bulb prime
how do you replace the primer bulb lines on a tb676ec with a two bulb prime
(Posted by dsnyder488 9 months ago)
Is The Throttle Cable Adjustable On The Troy Bilt Tb225 Tiller? Also What Would
is the throttle cable adustable on the tb225 tiller and also what would make the fuel not stay in th...
is the throttle cable adustable on the tb225 tiller and also what would make the fuel not stay in th...
(Posted by tw285j 1 year ago)
Tb225 Starter Rope Replacement. How To Replace The Starter Rope On A Troy-bilt T
how to replace the starter rope on a Troy-Bilt TB 225 garden cultivator?
how to replace the starter rope on a Troy-Bilt TB 225 garden cultivator?
(Posted by hamptona0000 6 years ago)
I Just Replaced The Tank And Primer Bul On My Tb575ec And Cannot Get Fuel Into T
I cannot get fuel into the primer bulb. I replaced the tank and the bulb but still nothing
I cannot get fuel into the primer bulb. I replaced the tank and the bulb but still nothing
(Posted by jcb5797 8 years ago)
