Troy-Bilt Bronco Support Question
Troy-Bilt Bronco Support Question
Find answers below for this question about Troy-Bilt Bronco.Need a Troy-Bilt Bronco manual? We have 1 online manual for this item!
Question posted by ejordan74434 on August 16th, 2014
Carb Problem
my troy-bilt bronco lawn trsctor won't start. I have replaced the spark plug, cleaned the air filter and have clean gas in tank. When I had carb air filter off I sprayed starter fluid in the carb. Engine starts and runs until it burns all the starter fluid then dies. I see an electical connector coming from the bottom of carb. Is this some type of kill switch for backfire protection. Before I replaced spark plug and cleaned the air filter the engine backfired several times then quit runnung. How do I replace this carb switch?
Current Answers
Related Troy-Bilt Bronco Manual Pages
Operation Manual - Page 1
...; Service • Troubleshooting • Warranty
Operator's Manual
Automatic Lawn Tractor -
BOX 361131 CLEVELAND, OHIO 44136-0019
Form No. 769-07568 (November 1, 2011) Bronco
WARNING
READ AND FOLLOW ALL SAFETY RULES AND INSTRUCTIONS IN THIS MANUAL BEFORE ATTEMPTING TO OPERATE THIS MACHINE. Printed In USA
TROY-BILT, P.O.
FAILURE TO COMPLY WITH THESE INSTRUCTIONS MAY RESULT...
Operation Manual - Page 2
...problems or questions concerning the machine, phone a authorized Troy-Bilt ... experts. Troy-Bilt reserves the right to the engine manufacturer's ...Replacement Parts 27 Attachments & Accessories 28 Warranty 31 Español 32
Record Product Information
Before setting up , operate and maintain your machine, for various models. Throughout this manual is responsible for purchasing a lawn...
Operation Manual - Page 3
...observe the following safety instructions could result in
5. Do not operate the mower
anyone . CALIFORNIA PROPOSITION 65
WARNING! Wash hands after handling
DANGER! ...to avoid discharge of California to State of material toward the operator.
3. Engine Exhaust, some of its
proper place.
11. Plan your eyes. Children ... replacement parts.
7. caught in personal injury.
Operation Manual - Page 4
...daylight or good artificial light.
17. Never leave a running machine unattended.
Check overhead clearances carefully before dismounting.
4....counterweights to start engine.
1. until the blade(s) come to cut normal residential grass of this machine on the mower deck presenting ...making any public roadway.
15. loaded dump cart, lawn roller, etc.) on the slopes slow and gradual...
Operation Manual - Page 5
... is not alert to prevent unintended starting the engine. Do not attach towed equipment except at least five minutes before starting .
Always place containers on a trailer with a plastic liner. e.
Never store the machine or fuel container inside a vehicle or on mower). Disconnect the spark plug wire and ground against the engine to the presence of Gasoline:
1. d. Use...
Operation Manual - Page 6
... to protect the environment.
15.
3. Repair the damage before starting and operating.
10. "Use of California the above is available through your machine should be sure the equipment is subjected to do not stop the engine, disconnect the spark plug wire(s) and ground against the engine.
Box 361131 Cleveland, Ohio 44136-0019.
12. Observe proper...
Operation Manual - Page 9
...cover, if present, from the terminals at the factory.
WARNING! Make sure the riding mower's engine is marked Pos. (+). Refer to set the parking brake before operating your equipment may ... lead and lead compounds, chemicals known
to the State of California to operate the riding mower without the discharge cover in the proper operating position could result in serious personal injury and...
Operation Manual - Page 11
... Fill-up to allow space for fuel expansion.
• Never remove gas cap or add fuel while the engine is hot or running . Read the instructions carefully. Do not overfill. Gasoline is shipped with gasoline. For best results, fill the fuel tank with only clean, fresh, unleaded gasoline with a pump sticker octane rating of filler...
Operation Manual - Page 12
... Switch
Parking Brake Lever
Drive Pedal
Shift Lever Cup Holder
PTO (Blade Engage) Lever
Deck Lift Lever
NOTE: Steering wheel not shown for clarity
Figure 4-1 Lawn Tractor controls and features are illustrated in personal injury.
12
Operation Manual - Page 13
... located on the left side of this manual for detailed instructions regarding the Ignition Switch Module. Refer to Safety Interlock Switches in serious damage to start the engine.
Doing so may result in the Operation section of the lawn tractor, along the running machine unattended.
Operation Manual - Page 15
...) position.
3. If the interlock system should ever malfunction, do not operate the tractor.
After the engine starts, release the key. IMPORTANT: Do NOT hold it down into the ignition switch.
2. Doing so may cause damage to run poorly.
15 Doing so will automatically move out of the cutting deck.
WARNING! Insert the tractor...
Operation Manual - Page 16
... the slope.
Turning up smoothly and carefully to stop the engine, disconnect the spark plug wire(s) and ground against the engine. IMPORTANT: First-time operators should become completely familiar with a slope in neutral, engage the parking brake, shut engine off and remove the key. The lawn tractor is necessary to reduce the possibility of approximately 2-1/2 feet...
Operation Manual - Page 17
... always be necessary to go back over the cut area a second time to get a clean cut the grass too short. Your tractor is running. Section 5 - Stop machine if anyone enters the area. Refer to Cutting Blades in... laps be cut with the engine at least 75 feet from the machine while it is moved to mow lawns, NOT clear brush.
• Keep the blades sharp and replace the blades when worn. The...
Operation Manual - Page 18
...engine Owner's Manual.
9. Replace the oil filter as follows:
1. Spark Plug
The spark plug should be removed from the axles once a season.
Engine
Lubricate the engine with your unit. Cleaning the Engine And Deck
Figure 6-1
Any fuel or oil spilled on the right side of the engine.
3. Changing Engine... starting . Air Cleaner
Service the pre-cleaner and cartridge/air cleaner...
Operation Manual - Page 20
...the Deck
NOTE: Check the tractor's tire pressure before performing any adjustments while the engine is running . With the tractor parked on the second to the top notch (second highest ...lower than the second measurement. The front of the deck should be adjusted to prevent unintended starting. Adjust if necessary as follows:
1. The first measurement taken should be between ¼" ...
Operation Manual - Page 24
...to tighten the blade spindle hex flange nut to prevent unintended starting before removing the belt.
Figure 7-5 3. To properly sharpen...replace the deck belt on the left idler pulley to the
spindle assembly. Remove the belt covers by removing the hex washer screws that secures the blade to get the belt off , remove ignition key, disconnect the spark plug wire(s) and ground against the engine...
Operation Manual - Page 26
... is so equipped. 1. Choke not activated. 5. Faulty spark plug. 6. Parking brake not engaged 9. Dirty air cleaner.
1. Engine speed too low. 2. Wet grass. 3. Unit running with clean, fresh
gasoline and replace fuel filter, is so equipped. 4. Spark plug fouled, faulty or gap too wide. 2. Connect wire to start
Engine runs erratic
Engine overheats Engine hesitates at desired height or make...
Operation Manual - Page 28
...Troy-bilt Service Dealer or phone (800) 828-5500 for the Troy-bilt Lawn Tractor.
Attachments & Accessories
10
The following attachments and accessories are compatible for information regarding price and availability. CAUTION: This Troy-Bilt Lawn... Front Dozer Blade Oil Siphon Arnold Tractor Cover Arnold Oil Filter Wrench Arnold Spark Plug Wrench 1 Gallon Tire &Tube Sealant By Tire Aid 24...
Operation Manual - Page 29
... in MTD Consumer Group Inc's application for that you including diagnosis, parts and labor. The outdoor equipment engine owner will repair your owner's manual. Such use of California, the California Air Resources Board (CARB) are responsible for replacement as follows:
1.
MANUFACTURER'S WARRANTY COVERAGE:
This emission control system is warranted for the period of outdoor...
Operation Manual - Page 31
... or replacement lawn care...engine or component parts thereof. Refer to applicable manufacturer's warranty for a period of charge, any part found to any implied warranty of the product sold through your Yellow Pages, or contact Troy-Bilt LLC at its territories and possessions (either entity respectively, "TroyBilt").
c.
d. Service completed by this warranty.
e. f. Replacement...
Similar Questions
Machine Will Start Run And Move But The Blades Will Not Come On
(Posted by gmorris 1 year ago)
My Tractor Just Quit In Mid Cycle Was On Mowing The Lawn Just Stopped And Won't
Mower stopped and mid-cycle was mowing my lawn and just stopped and won't start
Mower stopped and mid-cycle was mowing my lawn and just stopped and won't start
(Posted by thevanguilderfamily 2 years ago)
I Need The Part From The Air Filter To The Carb. Has An Outlet To The Gas Tank.
The air filter attaches to a plastic tube that connects to the carb. It also has a small connector w...
The air filter attaches to a plastic tube that connects to the carb. It also has a small connector w...
(Posted by clmeacha 8 years ago)
After Replacing Variable Speed Belt On Model 609 Bronco Pedal Drive. It Will Not
Stop. As soon as you put in forward or reverse it takes off. Prior. To belt install when u took foot...
Stop. As soon as you put in forward or reverse it takes off. Prior. To belt install when u took foot...
(Posted by rrobinson953 9 years ago)
How To Change Mower Blades On A Bronco 42' Riding Mower
(Posted by Anonymous-134542 10 years ago)