Troy-Bilt Bronco Support Question
Troy-Bilt Bronco Support Question
Find answers below for this question about Troy-Bilt Bronco.Need a Troy-Bilt Bronco manual? We have 1 online manual for this item!
Question posted by marshallgreen1109 on May 26th, 2021
Carburetor Solenoid
i bought a used troy bilt bronco last year and it hust died on me yesterday and after checking it out the plug had been un plugged and a wire was wrapped around the top of the solenoid and gas was dripping out of the bottom of the solenoid. Whats the point in that
Current Answers
Answer #1: Posted by Vikram1984 on May 26th, 2021 8:20 AM
Vikram1984
Member since:
May 22nd, 2021 Points: 1,100
Member since:
May 22nd, 2021 Points: 1,100
Definition
A solenoid is a mini-electromagnet. It contains a piston surrounded by a metal coil. When "activated" by an electrical charge, the piston snaps into place between two electrical contacts and completes the circuit that sends electrical energy to the component it is attached to. There is a starter solenoid, and, in some vehicles, a carburetor solenoid.
Starting the EngineYour carburetor's power source is the battery in your vehicle. Without the action of the solenoid, the battery would power that carburetor even when the engine is shut off. The solenoid receives a charge when you turn the ignition which activates the small electromagnet inside and completes the circuit, turning on the carburetor. This allows you to start the vehicle because the carburetor is ready to start mixing the fuel and air combination that makes the engine turn on.
Stopping the EngineWhen the engine is shut off, the solenoid cylinder falls to the bottom of the coil surrounding it, ending the power flow to the carburetor. With no power to continue mixing the fuel and air, the engine chokes and stops running altogether.
REFERENCES
WRITER BIO
More ArticlesRochester Carburetor Troubleshooting
How Does a Carburetor Cold Start Work?
What Is a Carburetor Dashpot?
How to Start Engines With Starting Fluid
Cleaning Instructions for a Honda ...
What Is the Purpose of a Solenoid?
How a Small Engine Primer Works
Troubleshooting a Quadrajet Carburetor
Signs and Symptoms of a Sticking ...
Related Troy-Bilt Bronco Manual Pages
Operation Manual - Page 1
..., OHIO 44136-0019
Form No. 769-07568 (November 1, 2011) Bronco
WARNING
READ AND FOLLOW ALL SAFETY RULES AND INSTRUCTIONS IN THIS MANUAL BEFORE ATTEMPTING TO OPERATE THIS MACHINE. FAILURE TO COMPLY WITH THESE INSTRUCTIONS MAY RESULT IN PERSONAL INJURY.
Printed In USA
TROY-BILT, P.O. Safe Operation Practices • Set-Up • Operation •...
Operation Manual - Page 2
... the controls, operation, or maintenance of the machine are observed from the experts. Troy-Bilt reserves the right to change product specifications, designs and equipment without notice and without... power-rating, specifications, warranty and service. Table of product specifications for purchasing a lawn tractor manufactured by looking beneath the seat. To The Owner
1
Thank You
Thank ...
Operation Manual - Page 3
...not operate the mower
anyone . Important Safe Operation Practices
2
WARNING! This machine is capable of the mower and attachment ...wire, bones, toys, and other reproductive harm.
Do not put hands or feet near rotating parts or under 14 years... of material toward the operator.
3. This symbol points out important safety instructions which could be used. Engine...
Operation Manual - Page 4
... cause the front of the machine. unusually tall, dry grass (e.g., pasture) or piles of riding mower-related
injuries.
12. Never carry passengers. All slopes require extra caution.
For your safety, use on that operators, age 60 years and above, are reduced, attachment may cause you feel uneasy on it, do not operate this...
Operation Manual - Page 5
... practical, remove gas-powered equipment from your skin and change clothes immediately. d. Do not use extreme care in or on mower).
Never over ...liner. Travel slowly and allow children under 14 years of grass, leaves, or other debris build-up...exhaust contains carbon monoxide, an odorless, and deadly gas.
2. Disconnect the spark plug wire and ground against the engine to the presence of...
Operation Manual - Page 6
...Wrap the blade or wear gloves, and use of this product has an Average Useful Life of seven (7) years, or 270 hours of the Average Useful...plug wire(s) and ground against the engine. If the blades do not modify engine in any damage. Federal laws apply on the machine. Periodically check to make adjustments or repairs to the machine while the engine is used, it should not be used...
Operation Manual - Page 8
... 1
15° Slope
(TOO STEEP) Figure 2
15° Slope
15° dashed line
USE THIS SLOPE GAUGE TO DETERMINE IF A SLOPE IS TOO STEEP FOR SAFE OPERATION! Locate a vertical...caution. If you cannot back up the slope or if you feel uneasy on or behind the slope (e.g. To check the slope, proceed as follows: 1. Align either side of slopes. 8
Slope Gauge
Section 2 - WARNING! ...
Operation Manual - Page 9
...deck. For shipping reasons, both battery cables on the right side of the mower, between your right hand by the NEGATIVE (Black) wire. Remove the plastic cover, if present, from the terminals at the factory... the date shown on how to operating the tractor. The shipping brace, used for instructions on top/side of battery, charge the battery as follows:
NOTE: The positive battery terminal...
Operation Manual - Page 11
...operating tire pressure is spilled, wipe it counterclockwise.
2. Service and check the engine oil as E85, are not approved.
• Methyl ... (up to allow space for fuel expansion.
• Never remove gas cap or add fuel while the engine is located under the hood.... in well-ventilated area.
• Do not overfill fuel tank. Use only clean, fresh (no more than 1/2 inch below bottom of ...
Operation Manual - Page 12
... Switch
Parking Brake Lever
Drive Pedal
Shift Lever Cup Holder
PTO (Blade Engage) Lever
Deck Lift Lever
NOTE: Steering wheel not shown for clarity
Figure 4-1 Lawn Tractor controls and features are illustrated in personal injury.
12 Read and follow all safety rules and instructions in this manual, including the entire Operation...
Operation Manual - Page 13
...must not be certain that the throttle lever is always in the Operation section of the lawn tractor, along the running machine unattended.
See Fig. 4-4.
WARNING! Figure 4-4
Brake Pedal... to prevent unintended starting the engine. Activating the choke control closes the choke plate on the carburetor and aids in the Operation section of the tractor's dash panel, see Fig. 4-1.
See ...
Operation Manual - Page 14
..., then place in the disengaged (PTO OFF) position when starting the engine.
14
Section 4-
To use, move the shift lever into the PTO OFF position disengages power to the cutting deck. The pedal...the parking brake position on the tractor's right fender, the PTO (blade engage) lever is used to engage power to the cutting deck. To operate, move out of this manual for your tractor's...
Operation Manual - Page 16
.... Avoid sudden starts, excessive speed and sudden stops.
The lawn tractor is necessary to stop the engine, disconnect the spark plug wire(s) and ground against the engine. Place the shift lever in...
Section 5- Keep the throttle lever in reverse, and if the operator leaves the seat. Always use of a roll over accident.
1. WARNING!
Turning up to a complete stop by hot exhaust ...
Operation Manual - Page 17
... is installed.
• For best results it in the notch best suited for your tractor:
WARNING! Using the Deck Lift Lever
Headlights
To raise the cutting deck, move the deck lift lever to the lawn.
• Do not cut the grass too short. This will be necessary to go back over the...
Operation Manual - Page 24
...Use a torque wrench to tighten the blade spindle hex flange nut to 30° angle. To properly sharpen the cutting blades, remove equal amounts of metal from the heavy side until it ) facing the ground when the mower...left idler pulley to get the belt off , remove ignition key, disconnect the spark plug wire(s) and ground against the engine to wear and should be dangerous by routing the belt ...
Operation Manual - Page 26
... or replace cap if damaged. 5. Remove spark plug and reset the gap.
1. Tighten blade and spindle. Check tire pressure in disengaged (OFF) position.
2. Faulty spark plug. 6. Blocked fuel line. 7. Unit running with clean, fresh (less than 30 days
old) gas. 4. Spark plug gap too close.
1. Uneven tire pressure. Connect wire to FAST position.
1. Refill with clean...
Operation Manual - Page 28
CAUTION: This Troy-Bilt Lawn Tractor is NOT designed for the Troy-bilt Lawn Tractor. Use of this type of ground-engaging attachments (e.g.
tiller or plow). Model Number
...Chains, 20 x 8 Tires 42-inch Front Dozer Blade Oil Siphon Arnold Tractor Cover Arnold Oil Filter Wrench Arnold Spark Plug Wrench 1 Gallon Tire &Tube Sealant By Tire Aid 24 Oz Tire & Tube Sealant By Tire Aid Deluxe Tire/ ...
Operation Manual - Page 29
...equipment engine to the first scheduled replacement point for two years. The outdoor equipment engine owner will be repaired or...repaired or replaced by the Air Resources Board may be used . MTD Consumer Group Inc is not scheduled for ... Group Inc's distribution center or service center as soon as the carburetor, fuel-injection system, the ignition system, catalytic converter, fuel tanks...
Operation Manual - Page 30
... Carburetor and internal parts (or fuel injection system) • Fuel pump • Fuel tank (2) Air Induction System • Air cleaner • Intake manifold (3) Ignition System • Spark plug(s) ...• Magneto ignition system (4) Exhaust System • Catalytic converter • SAI (Reed valve) (5) Miscellaneous Items Used in Above System • ...
Operation Manual - Page 31
... defects in accordance with the Operator's Manual furnished with respect to use . Attachments - Check your Yellow Pages, or contact Troy-Bilt LLC at www.troybilt.com.
Routine maintenance items such as : ...including, without limitation, expenses incurred for substitute or replacement lawn care services or for a period of two (2) years commencing on how long an implied warranty lasts, so...
Similar Questions
Need New Motor Engine For Troy Bitl Riding Lawn Mower 15.5
(Posted by janicesutton60 2 years ago)
My Tractor Just Quit In Mid Cycle Was On Mowing The Lawn Just Stopped And Won't
Mower stopped and mid-cycle was mowing my lawn and just stopped and won't start
Mower stopped and mid-cycle was mowing my lawn and just stopped and won't start
(Posted by thevanguilderfamily 2 years ago)
Lower Drive Belt Issue,
I replaced the lower drive belt on my 2011 Bronco mower, cut the yard over an hour job parked the mo...
I replaced the lower drive belt on my 2011 Bronco mower, cut the yard over an hour job parked the mo...
(Posted by duttonmary24 2 years ago)
Lawn Mower
What kind of oil do I use in my troy bilt 140cc 110b push behind mower is it ok to use 10w30
What kind of oil do I use in my troy bilt 140cc 110b push behind mower is it ok to use 10w30
(Posted by sgilbert491974 9 years ago)
Carb Problem
my troy-bilt bronco lawn trsctor won't start. I have replaced the spark plug, cleaned the air filter...
my troy-bilt bronco lawn trsctor won't start. I have replaced the spark plug, cleaned the air filter...
(Posted by ejordan74434 9 years ago)