Poulan P524ESA Support and Manuals
Get Help and Manuals for this Poulan item
This item is in your list!
View All Support Options Below
Free Poulan P524ESA manuals!
Problems with Poulan P524ESA?
Ask a Question
Free Poulan P524ESA manuals!
Problems with Poulan P524ESA?
Ask a Question
Popular Poulan P524ESA Manual Pages
User Manual - Page 1
Always Wear Eye Protection During Operation
185156 Rev. 1 11.01.02 BY Printed in serious injury.
Failure to do so can result in U.S.A. IMPORTANT MANUAL
Do Not Throw Away
OWNER'S MANUAL
MODEL NUMBER:
P524ESA
SNOW THROWER
WARNING:
Read the Owner's Manual and follow all Warnings and Safety Instructions.
User Manual - Page 2
... snow. Replace fuel cap securely and wipe up , transporting, adjusting or making repairs.
CAUTION: Muffler and other ground level surfaces. To avoid severe burns on slippery surfaces. If fuel is for expansion as the heat of the equipment. Use only with local inspection authorities.
• Read the operating and service instruction manual
•...
User Manual - Page 3
... proper tightness to be stored for an extended period.
• Maintain or replace safety and instruction labels, as necessary.
• Run the snow thrower, with fuel in any repairs, adjustments, or inspections.
• When cleaning, repairing, or inspecting, make certain all moving parts have competent, well-trained technicians and the proper tools to clear snow...
User Manual - Page 5
...-OPERATION
Read these instructions and this manual in its entirety before you assemble must be used for assembly of the belt cover. To ensure safe and proper operation of carton and lay panels flat the factory with retainer spring. Cut down all four corners of your snow thrower, all parts and hardware...
User Manual - Page 12
...problems...recommended to be emptied before requiring replacement. ADD GASOLINE (See Fig. 18... can be reversed, providing additional service before storage of tank fi...can damage the fuel system of this manual.
OPERATION
TO ADJUST SKID PLATES (See... hex nut only, then moving parts to give a 1/8" clearance between ... it may occur. See Storage Instructions for a few seconds, remove ...
User Manual - Page 14
...Maintain proper air pressure in both tires (See "PRODUCT SPECIFICATIONS" section in the Service and Adjustments section of injury to do so can harm ...instructed in this manual.
SNOW THROWER
Always observe the safety rules when performing any maintenance.
• Keep tires free of gasoline and oil, which can cause the unit to malfunction and pose a risk of this manual should replace...
User Manual - Page 15
...service classification SF-SJ.
• Be sure snow thrower is not used above components can cause contamination of this manual...the "PRODUCT SPECIFICATIONS" section of a suitable container. Install left side wheel may be replaced by original...manual. Pour slowly. Do not overfill. Keep oil at the factory. Wipe off any spilled oil.
Spark plug type and gap setting...
User Manual - Page 16
... hex nut. Connect spark plug wire to STOP position. To replace the capscrew/shear bolts:
16
FRAME
FIG. 20
SCREWS Remove belt cover.
• Replace belt cover by installing cover and screws and tighten securely. Install 1/4-20 locknuts and tighten securely. Disengage all moving parts to see "TO CONTROL SNOW DISCHARGE" in contact with your...
User Manual - Page 17
...belt around pulleys and inside the groove of this manual. torque). HANDLES
1.
TheV-belts on crankshaft. Tighten securely.
15. INSTALL DISCHARGE CHUTE - REMOVE GASOLINE FROM FUEL TANK -...SERVICE AND ADJUSTMENTS
TO REPLACE BELTS (See Fig. 21)
The auger and traction drive belts are damaged or begin to slip from wear, they should be replaced. It is inside belt keeper.
14. INSTALL...
User Manual - Page 18
... a qualified service center. Allow the engine to form and will void the warranty. Clean entire snow thrower (See "CLEANING" in essential fuel system parts such as on stabilizer container. Inspect moving parts for your snow thrower indoors and cover it from forming in the Maintenance section of this manual.
4. Replace with a suitable protective...
User Manual - Page 19
... Operation section of this manual. 7. Spark plug wire is flooded. 8. Bad spark plug. 10. Insert safety ignition key.
3. Engine idles or runs roughly
1. Drain tank and refill with fresh gasoline. Loose parts or damaged augers or impeller.
1. Replace damaged parts. If vibration remains, contact a qualified service center.
Loss of snow...
User Manual - Page 21
MODEL NUMBER P524ESA
AUGER HOUSING / IMPELLER ASSEMBLY
KEY PART NO. inches 1 inch = 25.4 mm
21 DESCRIPTION
1 183578
Bag, Weight
2 183577
Bracket, Weight Bag
3 74520524 Screw, Hex Head 5/16-18 x 1-1/2
4 181083... Screw, Hex Head 1/4-20 x 1-5/8
50 175311
Gasket, Gearbox
51 7836M
Pin, Roll 3/16 x 1-1/8
NOTE: All component dimensions given in U.S. REPAIR PARTS
SNOW THROWER - NO.
User Manual - Page 23
NO. MODEL NUMBER P524ESA
CONTROL PANEL / DISCHARGE CHUTE
KEY PART NO. inches 1 inch = 25.4 mm
23 REPAIR PARTS
SNOW THROWER -
DESCRIPTION
1 183334
Knob, Lever
2 17501010 Screw #10-24 x 5/8
3 179096X479 Strap, Slotted
4 73800600 Nut, Lock 3/8-16
5 19131316 Washer, Flat 3/8
6 178659
Control Assembly, Chute Rotater
7 178638X479 Support, Pivot
8 150078
Screw, Hex Head 5/16-18 x ...
User Manual - Page 27
... Assembly, Drive
27 179352
Shaft, Axle
28 175340
Shaft, Short Hex
29 175350X479 Lever, Shifter Plate
30 175349X479 Bracket, Shifter Support
31 72270505 Bolt, Carriage 5/16-18 x 5/8
32 178879
Key, Square 1/4 x 1/4 x 7/8
33 175323
Bearing, Flange... Head 5/16-18 x 3/4
NOTE: All component dimensions given in U.S. NO. MODEL NUMBER P524ESA
KEY PART NO. REPAIR PARTS DRIVE
SNOW THROWER -
User Manual - Page 31
... 8 155800 9 181039 - - 185156 - - 185158
DESCRIPTION
Decal, Danger Decal, Poulan, 5.5HP/24" Decal, Danger, Deflector Decal, Danger Decal, Poulan Decal, Instruction Decal, Traction Lever Decal, Auger Lever Decal, Speed Control Owner's Manual, English Owner's Manual, French
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
31 MODEL NUMBER P524ESA
KEY PART NO.
Poulan P524ESA Reviews
Do you have an experience with the Poulan P524ESA that you would like to share?
Earn 750 points for your review!
We have not received any reviews for Poulan yet.
Earn 750 points for your review!