Owners Manual
Page 6
... and warming up a cold engine ...5-1 Starting off ...5-2 Acceleration and deceleration ...5-2 Braking ...5-3 Engine break-in ...5-4 Parking ...5-4 PERIODIC MAINTENANCE AND MINOR REPAIR...6-1 Periodic maintenance and lubrication chart ...6-2 Removing and installing the panel ...6-4 Checking the spark plug ...6-4 Final transmission oil ...6-6 Cleaning the air filter sponge material ...6-7 Adjusting the carburetor ...6-8 Adjusting the throttle cable free play ...6-9 Tires ...6-9 Adjusting the front and rear brake lever free play ...6-11 Checking the front and rear brake shoes ...6-12 Checking...
... and warming up a cold engine ...5-1 Starting off ...5-2 Acceleration and deceleration ...5-2 Braking ...5-3 Engine break-in ...5-4 Parking ...5-4 PERIODIC MAINTENANCE AND MINOR REPAIR...6-1 Periodic maintenance and lubrication chart ...6-2 Removing and installing the panel ...6-4 Checking the spark plug ...6-4 Final transmission oil ...6-6 Cleaning the air filter sponge material ...6-7 Adjusting the carburetor ...6-8 Adjusting the throttle cable free play ...6-9 Tires ...6-9 Adjusting the front and rear brake lever free play ...6-11 Checking the front and rear brake shoes ...6-12 Checking...
Owners Manual
Page 8
...is veering wide on a turn due to occur. Many accidents involve inexperienced operators. G OBSERVE THE WARNINGS AND MAINTENANCE REQUIREMENTS IN THE OWNER'S MANUAL. Safe riding G Always ...driver's license. G OBTAIN PROFESSIONAL TECHNICAL SERVICE AS INDICATED BY THE OWNER'S MANUAL AND/OR WHEN MADE NECES- G This scooter is no traffic until you are the most likely places for scooter accidents to EXCESSIVE SPEED or undercornering (insufficient lean angle for G G G 1-1 SAFETY INFORMATION EAU10240 1 SCOOTERS ARE SINGLE TRACK VEHICLES. SARY BY MECHANICAL CONDITIONS. No passengers...
...is veering wide on a turn due to occur. Many accidents involve inexperienced operators. G OBSERVE THE WARNINGS AND MAINTENANCE REQUIREMENTS IN THE OWNER'S MANUAL. Safe riding G Always ...driver's license. G OBTAIN PROFESSIONAL TECHNICAL SERVICE AS INDICATED BY THE OWNER'S MANUAL AND/OR WHEN MADE NECES- G This scooter is no traffic until you are the most likely places for scooter accidents to EXCESSIVE SPEED or undercornering (insufficient lean angle for G G G 1-1 SAFETY INFORMATION EAU10240 1 SCOOTERS ARE SINGLE TRACK VEHICLES. SARY BY MECHANICAL CONDITIONS. No passengers...
Owners Manual
Page 9
Always signal before turning or changing lanes. The operator should be kept as low and close to minimize imbalance or instability. 1 G G Wind in mind: G Cargo and accessory weight should keep both hands on the handlebar and both sides of the scooter to the scooter as possible on -road use only. Always obey the speed limit and never travel...
Always signal before turning or changing lanes. The operator should be kept as low and close to minimize imbalance or instability. 1 G G Wind in mind: G Cargo and accessory weight should keep both hands on the handlebar and both sides of the scooter to the scooter as possible on -road use only. Always obey the speed limit and never travel...
Owners Manual
Page 10
... caution when adding electrical accessories. Gasoline and exhaust gas G GASOLINE IS HIGHLY FLAMMABLE: Always turn the engine off when refueling. Accessories Genuine Yamaha accessories have been specifically designed for the proper selection, installation and use on the engine or exhaust system when refueling. Make sure that may attempt to improper weight distribution or aerodynamic changes. Check accessory mounts and cargo restraints frequently. Accessories fitted to the handlebar...
... caution when adding electrical accessories. Gasoline and exhaust gas G GASOLINE IS HIGHLY FLAMMABLE: Always turn the engine off when refueling. Accessories Genuine Yamaha accessories have been specifically designed for the proper selection, installation and use on the engine or exhaust system when refueling. Make sure that may attempt to improper weight distribution or aerodynamic changes. Check accessory mounts and cargo restraints frequently. Accessories fitted to the handlebar...
Owners Manual
Page 11
... start the engine or let it run for any length of consciousness and death within a short time. When parking the scooter, note the following: The engine and exhaust system may be extremely difficult on a slope or soft ground, otherwise it could slide. Avoid hard braking, because the scooter could catch fire. Always operate your clothes. Do not park the scooter on a wet road...
... start the engine or let it run for any length of consciousness and death within a short time. When parking the scooter, note the following: The engine and exhaust system may be extremely difficult on a slope or soft ground, otherwise it could slide. Avoid hard braking, because the scooter could catch fire. Always operate your clothes. Do not park the scooter on a wet road...
Owners Manual
Page 19
... the key in loss of control or an accident. To lock the steering 2 3 1. The main switch/steering lock controls the ignition and lighting systems, and is started . EAU10660 LOCK OFF All electrical systems are supplied with power, the taillight and meter lighting come on as soon as the engine is used to "OFF" while still pushing it to lock the steering. INSTRUMENT AND CONTROL FUNCTIONS EAU10460 Main switch/steering lock OFF ON LOCK can...
... the key in loss of control or an accident. To lock the steering 2 3 1. The main switch/steering lock controls the ignition and lighting systems, and is started . EAU10660 LOCK OFF All electrical systems are supplied with power, the taillight and meter lighting come on as soon as the engine is used to "OFF" while still pushing it to lock the steering. INSTRUMENT AND CONTROL FUNCTIONS EAU10460 Main switch/steering lock OFF ON LOCK can...
Owners Manual
Page 20
... and a tripmeter. The speedometer shows riding speed. Turn signal indicator light " 3. High beam indicator light " Turn signal indicator light " " This indicator light flashes when the turn signal switch is equipped with YAMALUBE 2 or an equivalent 2-stroke engine oil. The warning light should go off after the 2-stroke engine oil tank has been refilled, have a Yamaha dealer check the electrical circuit. NOTE: If the 2-stroke engine oil level warning light does not come on . Tripmeter reset...
... and a tripmeter. The speedometer shows riding speed. Turn signal indicator light " 3. High beam indicator light " Turn signal indicator light " " This indicator light flashes when the turn signal switch is equipped with YAMALUBE 2 or an equivalent 2-stroke engine oil. The warning light should go off after the 2-stroke engine oil tank has been refilled, have a Yamaha dealer check the electrical circuit. NOTE: If the 2-stroke engine oil level warning light does not come on . Tripmeter reset...
Owners Manual
Page 21
Dimmer switch " 2. EAU12460 Turn signal switch " / " To signal a right-hand turn , push this switch to the center position. 3-3 Engine stop switch " / " 1. Horn switch 2. Dimmer switch " / " Set this switch to empty itself completely. Turn signal switch " 3. The needle moves towards "E" (Empty) as possible. When released, the switch returns to " " for the low beam. Start switch " " EAU12400 4 5 6 7 8 9 The fuel gauge indicates the amount of fuel in after it has returned to " ". NOTE: Do not allow the fuel tank to...
Dimmer switch " 2. EAU12460 Turn signal switch " / " To signal a right-hand turn , push this switch to the center position. 3-3 Engine stop switch " / " 1. Horn switch 2. Dimmer switch " / " Set this switch to empty itself completely. Turn signal switch " 3. The needle moves towards "E" (Empty) as possible. When released, the switch returns to " " for the low beam. Start switch " " EAU12400 4 5 6 7 8 9 The fuel gauge indicates the amount of fuel in after it has returned to " ". NOTE: Do not allow the fuel tank to...
Owners Manual
Page 24
... shown. Gasohol 3-6 EWA10880 8 9 G WARNING Do not overfill the fuel tank, otherwise it can be used if the ethanol content does not exceed 10%. Use of a different brand or premium unleaded fuel. Fill the fuel tank to use a gasoline of unleaded fuel will extend spark plug life and reduce maintenance costs. INSTRUMENT AND CONTROL FUNCTIONS EAU13210 Fuel 2 1 2 3 4 5 6 7 G fuel may overflow when the fuel warms up and expands...
... shown. Gasohol 3-6 EWA10880 8 9 G WARNING Do not overfill the fuel tank, otherwise it can be used if the ethanol content does not exceed 10%. Use of a different brand or premium unleaded fuel. Fill the fuel tank to use a gasoline of unleaded fuel will extend spark plug life and reduce maintenance costs. INSTRUMENT AND CONTROL FUNCTIONS EAU13210 Fuel 2 1 2 3 4 5 6 7 G fuel may overflow when the fuel warms up and expands...
Owners Manual
Page 25
... oil. 3-7 INSTRUMENT AND CONTROL FUNCTIONS EAU13540 EAU13680 2-stroke engine oil Make sure that the 2-stroke engine oil tank cap is sufficient oil in the 2-stroke engine oil tank. Oil quantity: 1.4 L (1.48 US qt) (1.23 Imp.qt) 3. Unlock. 4. If necessary, add the recommended 2-stroke engine oil as shown. 2. Kickstarter 2 1 1 3 4 5 6 7 8 9 3 2 1. 2-stroke engine oil tank cap 2. 2-stroke engine oil tank cap cover 3. Kickstarter 4 To start the engine, fold out the kickstarter lever, move it down lightly with your foot until the gears...
... oil. 3-7 INSTRUMENT AND CONTROL FUNCTIONS EAU13540 EAU13680 2-stroke engine oil Make sure that the 2-stroke engine oil tank cap is sufficient oil in the 2-stroke engine oil tank. Oil quantity: 1.4 L (1.48 US qt) (1.23 Imp.qt) 3. Unlock. 4. If necessary, add the recommended 2-stroke engine oil as shown. 2. Kickstarter 2 1 1 3 4 5 6 7 8 9 3 2 1. 2-stroke engine oil tank cap 2. 2-stroke engine oil tank cap cover 3. Kickstarter 4 To start the engine, fold out the kickstarter lever, move it down lightly with your foot until the gears...
Owners Manual
Page 32
... starter motor, try again. Exhaust fumes are poisonous, and inhaling them can cause loss of time. For safety, always start the engine or operate it in instructions prior to preserve the battery. Each starting attempt should be as short as possible to operating the vehicle for any one attempt. ECA11580 CAUTION: If the 2-stroke engine oil level warning light does not come on any length...
... starter motor, try again. Exhaust fumes are poisonous, and inhaling them can cause loss of time. For safety, always start the engine or operate it in instructions prior to preserve the battery. Each starting attempt should be as short as possible to operating the vehicle for any one attempt. ECA11580 CAUTION: If the 2-stroke engine oil level warning light does not come on any length...
Owners Manual
Page 37
... wet conditions, the air filter element should be performed by any repair establishment or individual that is designed for use on the following pages. Maintenance, replacement, or repair of the emission control devices and systems may result. The most efficient condition possible. EWA10320 rapid engine wear may be cleaned or replaced more frequently, otherwise 6-1 EWA10330 WARNING This scooter is certified (if applicable). Consult a Yamaha...
... wet conditions, the air filter element should be performed by any repair establishment or individual that is designed for use on the following pages. Maintenance, replacement, or repair of the emission control devices and systems may result. The most efficient condition possible. EWA10320 rapid engine wear may be cleaned or replaced more frequently, otherwise 6-1 EWA10330 WARNING This scooter is certified (if applicable). Consult a Yamaha...
Owners Manual
Page 38
... if necessary. • Moderately repack every 8,000 mi (12,000 km) or 24 months.** • Check operation/oil leakage. • Replace if necessary. √ INITIAL 300 mi (500 km) √ EVERY 2,000 mi 4,000 mi (3,000 km) or (6,000 km) or 6 months 12 months 1 2 3 4 Spark plug Air filter element * * * Carburetor Fuel line 5 Final transmission oil REPLACE. * Autolube pump Brakes 7 8 9 7 8 9 10 11 * * * * Wheels Wheel bearings Steering bearings Rear shock absorber 6-2
... if necessary. • Moderately repack every 8,000 mi (12,000 km) or 24 months.** • Check operation/oil leakage. • Replace if necessary. √ INITIAL 300 mi (500 km) √ EVERY 2,000 mi 4,000 mi (3,000 km) or (6,000 km) or 6 months 12 months 1 2 3 4 Spark plug Air filter element * * * Carburetor Fuel line 5 Final transmission oil REPLACE. * Autolube pump Brakes 7 8 9 7 8 9 10 11 * * * * Wheels Wheel bearings Steering bearings Rear shock absorber 6-2
Owners Manual
Page 41
Instead, have a Yamaha dealer check the vehicle. 2. Clean the surface of the spark plug is a medium-to the specified torque as soon as possible. 4. PERIODIC MAINTENANCE AND MINOR REPAIR necessary. 1 Specified spark plug: NGK/BPR7HS To install the spark plug 1. Install the spark plug cap. 2 3 4 5 6 7 1. Do not attempt to specification. 3. Check the spark plug for electrode erosion and excessive carbon or other deposits, and replace it to the...
Instead, have a Yamaha dealer check the vehicle. 2. Clean the surface of the spark plug is a medium-to the specified torque as soon as possible. 4. PERIODIC MAINTENANCE AND MINOR REPAIR necessary. 1 Specified spark plug: NGK/BPR7HS To install the spark plug 1. Install the spark plug cap. 2 3 4 5 6 7 1. Do not attempt to specification. 3. Check the spark plug for electrode erosion and excessive carbon or other deposits, and replace it to the...
Owners Manual
Page 42
... final transmission oil: See page .8-1 Oil quantity: 0.10 L (0.11 US qt) (0.09 Imp.qt) EWA11310 2 1. Start the engine, warm it to collect the used oil. 4. If any leakage is leaking, check for the cause. 6-6 Tightening torque: Final transmission oil drain bolt: 18 Nm (1.8 m·kgf, 13 ft·lbf) 6. Final transmission oil filler cap 2. PERIODIC MAINTENANCE AND MINOR REPAIR EAU20060 Final transmission oil 1 2 3 4 5 6 7 8 9 The final transmission case...
... final transmission oil: See page .8-1 Oil quantity: 0.10 L (0.11 US qt) (0.09 Imp.qt) EWA11310 2 1. Start the engine, warm it to collect the used oil. 4. If any leakage is leaking, check for the cause. 6-6 Tightening torque: Final transmission oil drain bolt: 18 Nm (1.8 m·kgf, 13 ft·lbf) 6. Final transmission oil filler cap 2. PERIODIC MAINTENANCE AND MINOR REPAIR EAU20060 Final transmission oil 1 2 3 4 5 6 7 8 9 The final transmission case...
Owners Manual
Page 44
.../or cylinder may become excessively worn. 6. PERIODIC MAINTENANCE AND MINOR REPAIR solvents with the clamp, then installing the screws. 7. ECA11470 EAU21300 Adjusting the carburetor The carburetor is properly seated in the original position, fastening it in the air filter case. Install the air filter case cover by placing it with a low flash point. Recommended oil: Yamaha foam air filter oil or other quality air filter oil 6-8 Apply oil...
.../or cylinder may become excessively worn. 6. PERIODIC MAINTENANCE AND MINOR REPAIR solvents with the clamp, then installing the screws. 7. ECA11470 EAU21300 Adjusting the carburetor The carburetor is properly seated in the original position, fastening it in the air filter case. Install the air filter case cover by placing it with a low flash point. Recommended oil: Yamaha foam air filter oil or other quality air filter oil 6-8 Apply oil...
Owners Manual
Page 46
...) Tire inspection Yamaha dealer immediately and have the tire replaced. If a tire tread shows crosswise lines (minimum tread depth), if the tire has a nail or glass fragments in tire damage, loss of rider, cargo, and accessories does not exceed the specified maximum load for the vehicle. Improper tire air pressure greatly affects tire life and handling. In addition, the tires could slip off the wheel rims during braking...
...) Tire inspection Yamaha dealer immediately and have the tire replaced. If a tire tread shows crosswise lines (minimum tread depth), if the tire has a nail or glass fragments in tire damage, loss of rider, cargo, and accessories does not exceed the specified maximum load for the vehicle. Improper tire air pressure greatly affects tire life and handling. In addition, the tires could slip off the wheel rims during braking...
Owners Manual
Page 53
... which have been in the following areas: seals (of wheel and swingarm bearings, fork and brakes), electric components (couplers, connectors, instruments, switches and lights), breather hoses and vents. If such products are used . Test the product on a small hidden part of the warranty, but never apply such products onto seals, gaskets and wheel axles. Before cleaning 1. Always rinse the dirt and degreaser...
... which have been in the following areas: seals (of wheel and swingarm bearings, fork and brakes), electric components (couplers, connectors, instruments, switches and lights), breather hoses and vents. If such products are used . Test the product on a small hidden part of the warranty, but never apply such products onto seals, gaskets and wheel axles. Before cleaning 1. Always rinse the dirt and degreaser...
Owners Manual
Page 57
... ) Clutch type: Dry, centrifugal automatic Rear tire: Type: Tubeless 8-1 engine oil Transmission: Primary reduction system: Helical gear Primary reduction ratio: 48/13 (3.692) Secondary reduction system: Spur gear Secondary reduction ratio: 42/13 (3.230) Transmission type: V-belt automatic Operation: Centrifugal automatic type Engine oil quantity: Quantity: 1.4 L (1.48 US qt) (1.23 Imp.qt) Transmission oil: Type: SAE10W30SE Oil change quantity: 0.10 L (0.11 US qt) (0.09 Imp.qt) 2 3 4 5 6 7 8 9 Air filter: Air filter element: Wet element Weight...
... ) Clutch type: Dry, centrifugal automatic Rear tire: Type: Tubeless 8-1 engine oil Transmission: Primary reduction system: Helical gear Primary reduction ratio: 48/13 (3.692) Secondary reduction system: Spur gear Secondary reduction ratio: 42/13 (3.230) Transmission type: V-belt automatic Operation: Centrifugal automatic type Engine oil quantity: Quantity: 1.4 L (1.48 US qt) (1.23 Imp.qt) Transmission oil: Type: SAE10W30SE Oil change quantity: 0.10 L (0.11 US qt) (0.09 Imp.qt) 2 3 4 5 6 7 8 9 Air filter: Air filter element: Wet element Weight...
Owners Manual
Page 58
..., passenger, cargo and accessories) Tire air pressure (measured on cold tires): Front: 150 kPa (22 psi) (1.50 kgf/cm2) Rear: 175 kPa (25 psi) (1.75 kgf/cm2) Rear suspension: Type: Unit swing Spring/shock absorber type: Coil spring/oil damper Wheel travel: 48.0 mm (1.89 in) Front wheel: Wheel type: Panel wheel Rim size: 10x2.15 Electrical system: Ignition system: DC. Charging system: A.C. magneto Fuses: Fuse: 7.5 A Rear wheel: Wheel type: Panel wheel Rim size: 10x2.15 Battery: Model: GT4B-5 Voltage, capacity: 12 V, 2.5 Ah Front brake: Type: Drum brake...
..., passenger, cargo and accessories) Tire air pressure (measured on cold tires): Front: 150 kPa (22 psi) (1.50 kgf/cm2) Rear: 175 kPa (25 psi) (1.75 kgf/cm2) Rear suspension: Type: Unit swing Spring/shock absorber type: Coil spring/oil damper Wheel travel: 48.0 mm (1.89 in) Front wheel: Wheel type: Panel wheel Rim size: 10x2.15 Electrical system: Ignition system: DC. Charging system: A.C. magneto Fuses: Fuse: 7.5 A Rear wheel: Wheel type: Panel wheel Rim size: 10x2.15 Battery: Model: GT4B-5 Voltage, capacity: 12 V, 2.5 Ah Front brake: Type: Drum brake...