Hardware Maintenance Manual
Page 5
...53 LCD-related symptoms 54 Intermittent problems 55 Undetermined problems 55 FRU replacement notices 56 Screw notices 56 © Copyright Lenovo 2007, 2008 Retaining serial numbers 56 Removing and replacing a FRU 59 1010 Battery pack 60 1020 Hard disk drive (2.5-inch) and HDD rubber rails... LCD cable 117 Locations 119 Front view for ThinkPad X60, X60s, X61, and X61s 119 Rear view for ThinkPad X60, X60s, X61, and X61s 120 Bottom view for ThinkPad X60, X60s, X61, and X61s 121 Rear View for ThinkPad X6 UltraBase . . . . 122 Bottom View for ThinkPad X6 UltraBase . . . 122 Parts list ...
...53 LCD-related symptoms 54 Intermittent problems 55 Undetermined problems 55 FRU replacement notices 56 Screw notices 56 © Copyright Lenovo 2007, 2008 Retaining serial numbers 56 Removing and replacing a FRU 59 1010 Battery pack 60 1020 Hard disk drive (2.5-inch) and HDD rubber rails... LCD cable 117 Locations 119 Front view for ThinkPad X60, X60s, X61, and X61s 119 Rear view for ThinkPad X60, X60s, X61, and X61s 120 Bottom view for ThinkPad X60, X60s, X61, and X61s 121 Rear View for ThinkPad X6 UltraBase . . . . 122 Bottom View for ThinkPad X6 UltraBase . . . 122 Parts list ...
Hardware Maintenance Manual
Page 33
...battery pack. (B) If an SVP has been set and is displayed. 3. General descriptions 27 Click Yes. The POP has been removed. 5. then, while the "To interrupt normal startup, press the blue ThinkVantage button" message is available, neither Lenovo nor Lenovo..., this function is displayed in the Enter Current Password field. Turn on the ThinkPad computer. 2. If the Using Passphrase item is available on the computer and wait... The hard disk drive can be replaced for access to remove the backup battery, see "1010 Battery pack" on page 82. 4. Attention: If the SVP ...
...battery pack. (B) If an SVP has been set and is displayed. 3. General descriptions 27 Click Yes. The POP has been removed. 5. then, while the "To interrupt normal startup, press the blue ThinkVantage button" message is available, neither Lenovo nor Lenovo..., this function is displayed in the Enter Current Password field. Turn on the ThinkPad computer. 2. If the Using Passphrase item is available on the computer and wait... The hard disk drive can be replaced for access to remove the backup battery, see "1010 Battery pack" on page 82. 4. Attention: If the SVP ...
Hardware Maintenance Manual
Page 40
... categories listed below to display symptoms and solutions: v CHECK SYSTEM HEALTH v SYSTEM AND DEVICE TESTS v LENOVO TROUBLESHOOTING v CENTER v SYSTEM REPORTS v UPDATES AND SUPPORT Power system checkout To verify a symptom, do the... the battery pack" on page 35 v "Checking the backup battery" on page 36 Checking the ac adapter You are here because the computer fails only when the ac adapter is used , replace the ... on, check the power cord of the following : 34 ThinkPad® X60, X60s, X61, and X61s Check that the battery pack supplies power when you power on the computer. Select one...
... categories listed below to display symptoms and solutions: v CHECK SYSTEM HEALTH v SYSTEM AND DEVICE TESTS v LENOVO TROUBLESHOOTING v CENTER v SYSTEM REPORTS v UPDATES AND SUPPORT Power system checkout To verify a symptom, do the... the battery pack" on page 35 v "Checking the backup battery" on page 36 Checking the ac adapter You are here because the computer fails only when the ac adapter is used , replace the ... on, check the power cord of the following : 34 ThinkPad® X60, X60s, X61, and X61s Check that the battery pack supplies power when you power on the computer. Select one...
Hardware Maintenance Manual
Page 41
... (V dc) 1 Ground 1 2 2 +19.5 to "Product overview" on , remove the battery pack and let it return to charge. Power off the computer. 2. See the following : v Replace the system board. If the battery status indicator or icon does not turn on page 38. If the charge indicator or icon..., reinstall and recharge it is displayed. See the following : 1. If the charge indicator still does not turn on , replace the system board. This protects the battery pack from being overcharged or from the ac adapter does not always indicate a defect. Remove it from the computer. 2. ...
... (V dc) 1 Ground 1 2 2 +19.5 to "Product overview" on , remove the battery pack and let it return to charge. Power off the computer. 2. See the following : v Replace the system board. If the battery status indicator or icon does not turn on page 38. If the charge indicator or icon..., reinstall and recharge it is displayed. See the following : 1. If the charge indicator still does not turn on , replace the system board. This protects the battery pack from being overcharged or from the ac adapter does not always indicate a defect. Remove it from the computer. 2. ...
Hardware Maintenance Manual
Page 42
... the voltage is still less than +14.4 V dc after replacement, replace the system board. 36 ThinkPad® X60, X60s, X61, and X61s If the voltage is correct, replace the system board. The resistance must be 4 to +3.2 Ground v If the voltage is more than +14.4 V dc, the battery pack has been discharged. If the resistance is not correct...
... the voltage is still less than +14.4 V dc after replacement, replace the system board. 36 ThinkPad® X60, X60s, X61, and X61s If the voltage is correct, replace the system board. The resistance must be 4 to +3.2 Ground v If the voltage is more than +14.4 V dc, the battery pack has been discharged. If the resistance is not correct...
Hardware Maintenance Manual
Page 43
...231 Common parts list 232 Tools 232 Power cords 232 Notices 234 Trademarks 235 © Copyright Lenovo 2007, 2008 37 ThinkPad X60, X60s, X61, and X61s Product overview 38 Specifications 38 Status indicators for X60, X60s, X61, and X61s . . 41 FRU tests 43 Fn key combinations 45 Symptom-to-FRU index 47 Numeric ... the serial number of the system unit 57 Retaining the UUID 57 Reading or writing the ECA information . . 57 Removing and replacing a FRU 59 1010 Battery pack 60 1020 Hard disk drive (2.5-inch) and HDD rubber rails 61 1030 DIMM cover 63 1040 DIMM 64 1050 Keyboard 65 ...
...231 Common parts list 232 Tools 232 Power cords 232 Notices 234 Trademarks 235 © Copyright Lenovo 2007, 2008 37 ThinkPad X60, X60s, X61, and X61s Product overview 38 Specifications 38 Status indicators for X60, X60s, X61, and X61s . . 41 FRU tests 43 Fn key combinations 45 Symptom-to-FRU index 47 Numeric ... the serial number of the system unit 57 Retaining the UUID 57 Reading or writing the ECA information . . 57 Removing and replacing a FRU 59 1010 Battery pack 60 1020 Hard disk drive (2.5-inch) and HDD rubber rails 61 1030 DIMM cover 63 1040 DIMM 64 1050 Keyboard 65 ...
Hardware Maintenance Manual
Page 49
...Replace the modem jack and the modem card in this test again. This drift can occur when a slight, steady pressure is applied to the computer while the test is running. Then, run Diagnostics --> Other Devices --> Analog Devices HDA CODEC Test Speaker Interactive Tests --> Internal Speaker Note: (For X61/X61s... modem is not a hardware problem. Place the computer on the screen for each FRU. Power Diagnostics --> ThinkPad Devices --> AC Adapter, Battery 1 (Battery 2) LCD unit 1. PC Card slot Diagnostics --> Systemboard --> PCMCIA Keyboard 1. If the docking station or ...
...Replace the modem jack and the modem card in this test again. This drift can occur when a slight, steady pressure is applied to the computer while the test is running. Then, run Diagnostics --> Other Devices --> Analog Devices HDA CODEC Test Speaker Interactive Tests --> Internal Speaker Note: (For X61/X61s... modem is not a hardware problem. Place the computer on the screen for each FRU. Power Diagnostics --> ThinkPad Devices --> AC Adapter, Battery 1 (Battery 2) LCD unit 1. PC Card slot Diagnostics --> Systemboard --> PCMCIA Keyboard 1. If the docking station or ...
Hardware Maintenance Manual
Page 54
... to continue. 1. Press to continue. 1. Run interactive tests of them. Extended RAM fails 2. Replace the backup battery and run BIOS Setup Utility to reset the time and date. 48 ThinkPad® X60, X60s, X61, and X61s Default configuration used. 1. Charge the backup battery for more modem devices are found . System board. 0199 System Security- Run BIOS...
... to continue. 1. Press to continue. 1. Run interactive tests of them. Extended RAM fails 2. Replace the backup battery and run BIOS Setup Utility to reset the time and date. 48 ThinkPad® X60, X60s, X61, and X61s Default configuration used. 1. Charge the backup battery for more modem devices are found . System board. 0199 System Security- Run BIOS...
Hardware Maintenance Manual
Page 55
... card. 2. System board. 1. Replace the backup battery and run BIOS Setup Utility to reset the time and date. 1. Load "Setup Default" in BIOS Setup Utility. 2. I/O card. 1. System board. 1. Shut down the computer and remove it from the docking station. 1. Remove the daughter card that you installed. 2. ThinkPad X60, X60s, X61, and X61s 49 Charge the...
... card. 2. System board. 1. Replace the backup battery and run BIOS Setup Utility to reset the time and date. 1. Load "Setup Default" in BIOS Setup Utility. 2. I/O card. 1. System board. 1. Shut down the computer and remove it from the docking station. 1. Remove the daughter card that you installed. 2. ThinkPad X60, X60s, X61, and X61s 49 Charge the...
Hardware Maintenance Manual
Page 61
... such as cosmic radiation, electrostatic discharge, or software errors. Determine whether the problem has been solved. 6. LCD assembly ThinkPad X60, X60s, X61, and X61s 55 Turn off the computer. 2. Remove or disconnect all attached devices are installed, or if the system simply is ... port replicator c. External diskette drive or optical drive g. Battery pack e. FRU replacement should be due to a variety of causes that have no defects). Non-ThinkPad devices b. System board b. If any error is detected, do not replace a nondefective FRU): a. DIMM h. Turn on page 34...
... such as cosmic radiation, electrostatic discharge, or software errors. Determine whether the problem has been solved. 6. LCD assembly ThinkPad X60, X60s, X61, and X61s 55 Turn off the computer. 2. Remove or disconnect all attached devices are installed, or if the system simply is ... port replicator c. External diskette drive or optical drive g. Battery pack e. FRU replacement should be due to a variety of causes that have no defects). Non-ThinkPad devices b. System board b. If any error is detected, do not replace a nondefective FRU): a. DIMM h. Turn on page 34...
Hardware Maintenance Manual
Page 65
... new FRU in the drawing. 6. ThinkPad X60, X60s, X61, and X61s 59 For information about connecting and arranging internal cables, see "Locations" on page 56. 3. Any such FRUs are listed at the top of damaging parts. 2. When turning a screw to replace a FRU, turn on the computer until...place, reverse the removal procedure and follow any notes that all power cords from electrical outlets, remove the battery pack, and then disconnect any FRUs that have to replacement. Do not try to observe the following general rules: 1. Follow the correct sequence in the drawing. ...
... new FRU in the drawing. 6. ThinkPad X60, X60s, X61, and X61s 59 For information about connecting and arranging internal cables, see "Locations" on page 56. 3. Any such FRUs are listed at the top of damaging parts. 2. When turning a screw to replace a FRU, turn on the computer until...place, reverse the removal procedure and follow any notes that all power cords from electrical outlets, remove the battery pack, and then disconnect any FRUs that have to replacement. Do not try to observe the following general rules: 1. Follow the correct sequence in the drawing. ...
Hardware Maintenance Manual
Page 66
Any other battery could ignite or explode. 1 2 3 60 ThinkPad® X60, X60s, X61, and X61s Removing and replacing a FRU 1010 Battery pack DANGER Use only the battery specified in the parts list for your computer.
Any other battery could ignite or explode. 1 2 3 60 ThinkPad® X60, X60s, X61, and X61s Removing and replacing a FRU 1010 Battery pack DANGER Use only the battery specified in the parts list for your computer.
Hardware Maintenance Manual
Page 67
...60 2 1 Step 1 Screw (quantity) M3 × 3 mm, wafer-head, nylon-coated (1) Color Black Torque 0.196 Nm (2 kgfcm) 3 ThinkPad X60, X60s, X61, and X61s 61 v Before removing the drive, have the user make a backup copy of data. Attention v Do not drop or apply any shock to physical ...shock. For access, remove following FRU: v "1010 Battery pack" on the drive if possible. The hard disk drive is in suspend mode. Removing and replacing...
...60 2 1 Step 1 Screw (quantity) M3 × 3 mm, wafer-head, nylon-coated (1) Color Black Torque 0.196 Nm (2 kgfcm) 3 ThinkPad X60, X60s, X61, and X61s 61 v Before removing the drive, have the user make a backup copy of data. Attention v Do not drop or apply any shock to physical ...shock. For access, remove following FRU: v "1010 Battery pack" on the drive if possible. The hard disk drive is in suspend mode. Removing and replacing...
Hardware Maintenance Manual
Page 69
Removing and replacing a FRU 1030 DIMM cover For access, remove following FRU: v "1010 Battery pack" on page 60 Note: Loosen the screws 1 , but do not remove them. 1 1 2 Step 1 Screw (quantity) M2 × 3 mm, wafer-head, nylon-coated (2) Color Black Torque 0.157 Nm (1.6 kgfcm) ThinkPad X60, X60s, X61, and X61s 63
Removing and replacing a FRU 1030 DIMM cover For access, remove following FRU: v "1010 Battery pack" on page 60 Note: Loosen the screws 1 , but do not remove them. 1 1 2 Step 1 Screw (quantity) M2 × 3 mm, wafer-head, nylon-coated (2) Color Black Torque 0.157 Nm (1.6 kgfcm) ThinkPad X60, X60s, X61, and X61s 63
Hardware Maintenance Manual
Page 70
Removing and replacing a FRU 1040 DIMM For access, remove following FRUs, in order: v "1010 Battery pack" on page 60 v "1030 DIMM cover" on page 63 b a 1 2 1 Note: If only one DIMM is used on the computer you are servicing, the card must be installed in SLOT-0 ( a ), but not in SLOT-1 ( b ). 64 ThinkPad® X60, X60s, X61, and X61s
Removing and replacing a FRU 1040 DIMM For access, remove following FRUs, in order: v "1010 Battery pack" on page 60 v "1030 DIMM cover" on page 63 b a 1 2 1 Note: If only one DIMM is used on the computer you are servicing, the card must be installed in SLOT-0 ( a ), but not in SLOT-1 ( b ). 64 ThinkPad® X60, X60s, X61, and X61s
Hardware Maintenance Manual
Page 71
When reinstalling the screw 1a , use a manual screwdriver. Do not secure this screw too tightly. 1 1a 1 1 Step Icon 1 1a (continued) Screw (quantity) M2 × 6 mm, wafer-head, nylon-coated (4) Color Black Torque 0.196 Nm (2 kgfcm) ThinkPad X60, X60s, X61, and X61s 65 Note: Place the system on page 60 Remove 4 screws with keyboard icon to remove keyboard. Removing and replacing a FRU 1050 Keyboard For access, remove following FRU: v "1010 Battery pack" on a hard flat table when you remove or reinstall the screws.
When reinstalling the screw 1a , use a manual screwdriver. Do not secure this screw too tightly. 1 1a 1 1 Step Icon 1 1a (continued) Screw (quantity) M2 × 6 mm, wafer-head, nylon-coated (4) Color Black Torque 0.196 Nm (2 kgfcm) ThinkPad X60, X60s, X61, and X61s 65 Note: Place the system on page 60 Remove 4 screws with keyboard icon to remove keyboard. Removing and replacing a FRU 1050 Keyboard For access, remove following FRU: v "1010 Battery pack" on a hard flat table when you remove or reinstall the screws.
Hardware Maintenance Manual
Page 75
ThinkPad X60, X60s, X61, and X61s 69 Removing and replacing a FRU 1060 Upper case For access, remove following FRUs, in order: v "1010 Battery pack" on page 60 v "1050 Keyboard" on page 65 1 1 1 1 1 1 Step 1 Screw (quantity) M2 × 6 mm, wafer-head, nylon-coated (6) Color Black Torque 0.196 Nm (2 kgfcm) Note: Place the system on a hard flat table when you remove or reinstall the screws.
ThinkPad X60, X60s, X61, and X61s 69 Removing and replacing a FRU 1060 Upper case For access, remove following FRUs, in order: v "1010 Battery pack" on page 60 v "1050 Keyboard" on page 65 1 1 1 1 1 1 Step 1 Screw (quantity) M2 × 6 mm, wafer-head, nylon-coated (6) Color Black Torque 0.196 Nm (2 kgfcm) Note: Place the system on a hard flat table when you remove or reinstall the screws.
Hardware Maintenance Manual
Page 78
Removing and replacing a FRU 1070 Fingerprint reader Note: This procedure is only for models with wireless WAN, copper and aluminum shielding are present on the upper case and the fingerprint reader cable. 72 ThinkPad® X60, X60s, X61, and X61s For access, remove following FRUs, in order: v "1010 Battery pack" on page 60 v "1050 Keyboard" on...
Removing and replacing a FRU 1070 Fingerprint reader Note: This procedure is only for models with wireless WAN, copper and aluminum shielding are present on the upper case and the fingerprint reader cable. 72 ThinkPad® X60, X60s, X61, and X61s For access, remove following FRUs, in order: v "1010 Battery pack" on page 60 v "1050 Keyboard" on...
Hardware Maintenance Manual
Page 79
Removing and replacing a FRU 1080 Hard disk (1.8-inch) Note: This procedure is sensitive to the hard disk drive. For access, remove following FRUs, in suspend mode. Attention v Do ... data. Incorrect handling can cause damage and permanent loss of all the information on page 69 1 2 ThinkPad X60, X60s, X61, and X61s 73 v Never remove the drive while the system is operating or is in order: v "1010 Battery pack" on page 60 v "1050 Keyboard" on page 65 v "1060 Upper case" on the drive if...
Removing and replacing a FRU 1080 Hard disk (1.8-inch) Note: This procedure is sensitive to the hard disk drive. For access, remove following FRUs, in suspend mode. Attention v Do ... data. Incorrect handling can cause damage and permanent loss of all the information on page 69 1 2 ThinkPad X60, X60s, X61, and X61s 73 v Never remove the drive while the system is operating or is in order: v "1010 Battery pack" on page 60 v "1050 Keyboard" on page 65 v "1060 Upper case" on the drive if...
Hardware Maintenance Manual
Page 80
For access, remove following FRUs, in order: v "1010 Battery pack" on page 60 v "1050 Keyboard" on page 65 v "1060 Upper case" on page 69 v "1080 Hard disk (1.8-inch)" on page 73 1 2 Step 1 Screw (quantity) M2 × 3.5 mm, wafer-head, nylon-coated (2) Color Silver Torque 0.196 Nm (2 kgfcm) 74 ThinkPad® X60, X60s, X61, and X61s Removing and replacing a FRU 1090 Hard disk housing (1.8-inch) Note: This procedure is only for models with a 1.8-inch hard disk drive.
For access, remove following FRUs, in order: v "1010 Battery pack" on page 60 v "1050 Keyboard" on page 65 v "1060 Upper case" on page 69 v "1080 Hard disk (1.8-inch)" on page 73 1 2 Step 1 Screw (quantity) M2 × 3.5 mm, wafer-head, nylon-coated (2) Color Silver Torque 0.196 Nm (2 kgfcm) 74 ThinkPad® X60, X60s, X61, and X61s Removing and replacing a FRU 1090 Hard disk housing (1.8-inch) Note: This procedure is only for models with a 1.8-inch hard disk drive.