Hardware Maintenance Manual
Page 5
... Intermittent problems 55 Undetermined problems 55 FRU replacement notices 56 Screw notices 56 © Copyright Lenovo 2007, 2008 Retaining serial numbers 56 Removing and replacing a FRU 59 1010 Battery pack 60 1020 Hard disk drive (2.5-inch) and HDD rubber rails 61 1030 DIMM cover... and LCD cable 117 Locations 119 Front view for ThinkPad X60, X60s, X61, and X61s 119 Rear view for ThinkPad X60, X60s, X61, and X61s 120 Bottom view for ThinkPad X60, X60s, X61, and X61s 121 Rear View for ThinkPad X6 UltraBase . . . . 122 Bottom View for ThinkPad X6 UltraBase . . . 122 Parts list 123 ...
... Intermittent problems 55 Undetermined problems 55 FRU replacement notices 56 Screw notices 56 © Copyright Lenovo 2007, 2008 Retaining serial numbers 56 Removing and replacing a FRU 59 1010 Battery pack 60 1020 Hard disk drive (2.5-inch) and HDD rubber rails 61 1030 DIMM cover... and LCD cable 117 Locations 119 Front view for ThinkPad X60, X60s, X61, and X61s 119 Rear view for ThinkPad X60, X60s, X61, and X61s 120 Bottom view for ThinkPad X60, X60s, X61, and X61s 121 Rear View for ThinkPad X6 UltraBase . . . . 122 Bottom View for ThinkPad X6 UltraBase . . . 122 Parts list 123 ...
Hardware Maintenance Manual
Page 24
...and built, required safety items were installed to measure third-wire ground continuity for cracked or bulging batteries. 5. If any unsafe conditions are any obvious non-ThinkPad alterations. Power off , and the power cord disconnected. Insulation must determine how serious the apparent hazard... addresses only those items. You should be frayed or worn. 4. Check for worn, frayed, or pinched cables. 18 ThinkPad® X60, X60s, X61, and X61s Safety information v Do not service the following checklist at the beginning of any obvious unsafe conditions, such as loose or ...
...and built, required safety items were installed to measure third-wire ground continuity for cracked or bulging batteries. 5. If any unsafe conditions are any obvious non-ThinkPad alterations. Power off , and the power cord disconnected. Insulation must determine how serious the apparent hazard... addresses only those items. You should be frayed or worn. 4. Check for worn, frayed, or pinched cables. 18 ThinkPad® X60, X60s, X61, and X61s Safety information v Do not service the following checklist at the beginning of any obvious unsafe conditions, such as loose or ...
Hardware Maintenance Manual
Page 25
Handling devices that are all at the same charge. v Wear a grounded wrist strap against your skin to eliminate static on a double-insulated or battery-operated system, use coax or connector-outside shells on ac-operated computers. Attach the ESD ground clip to provide a static-free work surface. When working ...
Handling devices that are all at the same charge. v Wear a grounded wrist strap against your skin to eliminate static on a double-insulated or battery-operated system, use coax or connector-outside shells on ac-operated computers. Attach the ESD ground clip to provide a static-free work surface. When working ...
Hardware Maintenance Manual
Page 33
...SVP has been set: 1. The hard disk drive can be made available to the servicer, there is no master HDP is appearing on the ThinkPad computer. 2. For how to move down the menu. 5. then, while the "To interrupt normal startup, press the blue ThinkVantage button" ...prompt does not appear. Reinstall the backup battery and the battery pack. (B) If an SVP has been set . The Rescue and Recovery screen opens. For models supporting the Passphrase function, press F1 while the POP icon is available, neither Lenovo nor Lenovo authorized servicers provide any services to reset ...
...SVP has been set: 1. The hard disk drive can be made available to the servicer, there is no master HDP is appearing on the ThinkPad computer. 2. For how to move down the menu. 5. then, while the "To interrupt normal startup, press the blue ThinkVantage button" ...prompt does not appear. Reinstall the backup battery and the battery pack. (B) If an SVP has been set . The Rescue and Recovery screen opens. For models supporting the Passphrase function, press F1 while the POP icon is available, neither Lenovo nor Lenovo authorized servicers provide any services to reset ...
Hardware Maintenance Manual
Page 35
...the hard disk, the parallel connector, or the diskette drive within that time. v If you are stored on the power switch. v If the battery indicator blinks orange, indicating that action. - Also, in either of the following events, the computer automatically returns from standby mode and resume operation, ...To cause the computer to return from standby mode and resumes operation: v The ring indicator (RI) is low. (Alternatively, if Hibernate when battery becomes low has been selected in screen blank mode: v The LCD is docked to the docking station, do not undock it is powered off ...
...the hard disk, the parallel connector, or the diskette drive within that time. v If you are stored on the power switch. v If the battery indicator blinks orange, indicating that action. - Also, in either of the following events, the computer automatically returns from standby mode and resume operation, ...To cause the computer to return from standby mode and resumes operation: v The ring indicator (RI) is low. (Alternatively, if Hibernate when battery becomes low has been selected in screen blank mode: v The LCD is docked to the docking station, do not undock it is powered off ...
Hardware Maintenance Manual
Page 40
... DOS Shell v Tech Support Form v Battery Rundown v View Test Log v Print ...battery pack. 3. If you troubleshoot and resolve problems related to display symptoms and solutions: v CHECK SYSTEM HEALTH v SYSTEM AND DEVICE TESTS v LENOVO... TROUBLESHOOTING v CENTER v SYSTEM REPORTS v UPDATES AND SUPPORT Power system checkout To verify a symptom, do the following power supply checkouts: v "Checking the ac adapter" v "Checking operational charging" on page 35 v "Checking the battery pack" on page 35 v "Checking the backup battery...install the charged battery pack. 7. v...the battery pack ...
... DOS Shell v Tech Support Form v Battery Rundown v View Test Log v Print ...battery pack. 3. If you troubleshoot and resolve problems related to display symptoms and solutions: v CHECK SYSTEM HEALTH v SYSTEM AND DEVICE TESTS v LENOVO... TROUBLESHOOTING v CENTER v SYSTEM REPORTS v UPDATES AND SUPPORT Power system checkout To verify a symptom, do the following power supply checkouts: v "Checking the ac adapter" v "Checking operational charging" on page 35 v "Checking the battery pack" on page 35 v "Checking the backup battery...install the charged battery pack. 7. v...the battery pack ...
Hardware Maintenance Manual
Page 41
...power remains; Note: Noise from having a shortened life. Perform operational charging. If the charge indicator still does not turn on , replace the battery pack. under this condition the battery pack can charge to +21.0 3. See the following figure: Pin Voltage (V dc) 1 Ground 1 2 2 +19.5 to 100% ...the plug of its capacity. Power off the computer. 2. v If the problem persists, go to room temperature. Then reinstall the battery pack. See the following figure: General descriptions 35 Unplug the ac adapter cable from the computer and leave it may not be able...
...power remains; Note: Noise from having a shortened life. Perform operational charging. If the charge indicator still does not turn on , replace the battery pack. under this condition the battery pack can charge to +21.0 3. See the following figure: Pin Voltage (V dc) 1 Ground 1 2 2 +19.5 to 100% ...the plug of its capacity. Power off the computer. 2. v If the problem persists, go to room temperature. Then reinstall the battery pack. See the following figure: General descriptions 35 Unplug the ac adapter cable from the computer and leave it may not be able...
Hardware Maintenance Manual
Page 42
...). 4. If the voltage is correct, replace the system board. If the resistance is still less than +14.4 V dc after replacement, replace the system board. 36 ThinkPad® X60, X60s, X61, and X61s Power off the computer, and unplug the ac adapter from it. 2. v If the backup battery discharges quickly after recharging, replace the...
...). 4. If the voltage is correct, replace the system board. If the resistance is still less than +14.4 V dc after replacement, replace the system board. 36 ThinkPad® X60, X60s, X61, and X61s Power off the computer, and unplug the ac adapter from it. 2. v If the backup battery discharges quickly after recharging, replace the...
Hardware Maintenance Manual
Page 43
... Retaining the UUID 57 Reading or writing the ECA information . . 57 Removing and replacing a FRU 59 1010 Battery pack 60 1020 Hard disk drive (2.5-inch) and HDD rubber rails 61 1030 DIMM cover 63 1040 DIMM 64 ... 117 Locations 119 Front view for ThinkPad X60, X60s, X61, and X61s 119 Rear view for ThinkPad X60, X60s, X61, and X61s 120 Bottom view for ThinkPad X60, X60s, X61, and X61s 121 Rear View for ThinkPad X6 UltraBase . . . . 122 Bottom View for ThinkPad X6 UltraBase . . . 122 ... 232 Tools 232 Power cords 232 Notices 234 Trademarks 235 © Copyright Lenovo 2007, 2008 37
... Retaining the UUID 57 Reading or writing the ECA information . . 57 Removing and replacing a FRU 59 1010 Battery pack 60 1020 Hard disk drive (2.5-inch) and HDD rubber rails 61 1030 DIMM cover 63 1040 DIMM 64 ... 117 Locations 119 Front view for ThinkPad X60, X60s, X61, and X61s 119 Rear view for ThinkPad X60, X60s, X61, and X61s 120 Bottom view for ThinkPad X60, X60s, X61, and X61s 121 Rear View for ThinkPad X6 UltraBase . . . . 122 Bottom View for ThinkPad X6 UltraBase . . . 122 ... 232 Tools 232 Power cords 232 Notices 234 Trademarks 235 © Copyright Lenovo 2007, 2008 37
Hardware Maintenance Manual
Page 46
...) v ThinkPad Modem (MDC-1.5) v 65-watt type v USB diskette drive v 1 parallel of 4 series of cells (1P4S) Li-Ion battery pack (2.0 AH) (Prismatic) v 1 parallel of 4 series of cells (1P4S) Li-Ion battery pack (2.6 AH) (Standard) v 2 parallel of 4 series of cells (2P4S) Li-Ion battery pack (5.2 AH) (Hybrid) Note: The prismatic battery is not available on the ThinkPad X61 and X61s...
...) v ThinkPad Modem (MDC-1.5) v 65-watt type v USB diskette drive v 1 parallel of 4 series of cells (1P4S) Li-Ion battery pack (2.0 AH) (Prismatic) v 1 parallel of 4 series of cells (1P4S) Li-Ion battery pack (2.6 AH) (Standard) v 2 parallel of 4 series of cells (2P4S) Li-Ion battery pack (5.2 AH) (Hybrid) Note: The prismatic battery is not available on the ThinkPad X61 and X61s...
Hardware Maintenance Manual
Page 48
This indicator is on ac power. Green: Caps Lock mode is resuming normal operation. 42 ThinkPad® X60, X60s, X61, and X61s Sudden physical shock could cause drive errors. Green: The ac adapter is connected and the computer is operating on when the data is transmitted. 2 Bluetooth ... is entering standby mode or hibernation mode, or is enabled. This indicator is on when R the Bluetooth is on and not in use 7 Power on 8 Battery status 9 AC power status Green: Data is being charged, but still has enough power to operate. (At regular intervals, the indicator light turns off the...
This indicator is on ac power. Green: Caps Lock mode is resuming normal operation. 42 ThinkPad® X60, X60s, X61, and X61s Sudden physical shock could cause drive errors. Green: The ac adapter is connected and the computer is operating on when the data is transmitted. 2 Bluetooth ... is entering standby mode or hibernation mode, or is enabled. This indicator is on when R the Bluetooth is on and not in use 7 Power on 8 Battery status 9 AC power status Green: Data is being charged, but still has enough power to operate. (At regular intervals, the indicator light turns off the...
Hardware Maintenance Manual
Page 49
Power Diagnostics --> ThinkPad Devices --> AC Adapter, Battery 1 (Battery 2) LCD unit 1. Replace the modem jack and the modem card in Diagnostics --> Communication: a. PC Card slot Diagnostics --> Systemboard --> PCMCIA Keyboard 1. This symptom is attached to Compatibility, and run Diagnostics --> ThinkPad Devices --> HDD Active Protection Test.... correct the problem, continue with the following: v Interactive Tests --> Mouse (continued) ThinkPad X60, X60s, X61, and X61s 43 Diagnostics --> Systemboard 3. If the pointer stops after a short time, no sound is necessary.
Power Diagnostics --> ThinkPad Devices --> AC Adapter, Battery 1 (Battery 2) LCD unit 1. Replace the modem jack and the modem card in Diagnostics --> Communication: a. PC Card slot Diagnostics --> Systemboard --> PCMCIA Keyboard 1. This symptom is attached to Compatibility, and run Diagnostics --> ThinkPad Devices --> HDD Active Protection Test.... correct the problem, continue with the following: v Interactive Tests --> Mouse (continued) ThinkPad X60, X60s, X61, and X61s 43 Diagnostics --> Systemboard 3. If the pointer stops after a short time, no sound is necessary.
Hardware Maintenance Manual
Page 54
.... Embedded Security hardware tamper detected. Remove the wireless LAN device that you installed. 2. Charge the backup battery for more than 8 hours by pressing F10. 2. Press to reset the time and date. 48 ThinkPad® X60, X60s, X61, and X61s Reseat the hard disk drive. 2. Hard disk drive. 4. Security password retry count exceeded. 1. System board...
.... Embedded Security hardware tamper detected. Remove the wireless LAN device that you installed. 2. Charge the backup battery for more than 8 hours by pressing F10. 2. Press to reset the time and date. 48 ThinkPad® X60, X60s, X61, and X61s Reseat the hard disk drive. 2. Hard disk drive. 4. Security password retry count exceeded. 1. System board...
Hardware Maintenance Manual
Page 55
...is set in sequence Reset the password by running BIOS Setup Utility. 1. CPU. 2. Replace the backup battery. 3. Remove the daughter card that you installed. 2. Replace the backup battery and run BIOS Setup Utility to reset the time and date. 3. I/O card. 1. Load Setup Defaults...board. System board. DIMM. 3. System board. 1. DIMM. 2. Replace the backup battery and run BIOS Setup Utility to reset the time and date. 1. System board. 1. DIMM. 2. ThinkPad X60, X60s, X61, and X61s 49 Default configuration used. 02B2 Incorrect drive A type. 02F0 CPU ID:xx Failed....
...is set in sequence Reset the password by running BIOS Setup Utility. 1. CPU. 2. Replace the backup battery. 3. Remove the daughter card that you installed. 2. Replace the backup battery and run BIOS Setup Utility to reset the time and date. 3. I/O card. 1. Load Setup Defaults...board. System board. DIMM. 3. System board. 1. DIMM. 2. Replace the backup battery and run BIOS Setup Utility to reset the time and date. 1. System board. 1. DIMM. 2. ThinkPad X60, X60s, X61, and X61s 49 Default configuration used. 02B2 Incorrect drive A type. 02F0 CPU ID:xx Failed....
Hardware Maintenance Manual
Page 57
...System board. 1. System board. 1. DIMM. 2. System board. 1. ThinkPad X60, X60s, X61, and X61s 51 Ensure that your HDD is supported on this system and that the latest HDD firmware is available at http://www.lenovo.com/support 2100 Initialization error on HDD0 (Main hard disk drive) 1. ...System board. 2112 Read error on HDD1 (Ultrabay hard 2. Invalid system configuration data. FRU or action, in the BIOS Setup Utility. 2. Backup battery. 3. If memory size has been changed, re-create the hibernation file. Initialization error on HDD1 (Ultrabay hard disk drive) 1. System board....
...System board. 1. System board. 1. DIMM. 2. System board. 1. ThinkPad X60, X60s, X61, and X61s 51 Ensure that your HDD is supported on this system and that the latest HDD firmware is available at http://www.lenovo.com/support 2100 Initialization error on HDD0 (Main hard disk drive) 1. ...System board. 2112 Read error on HDD1 (Ultrabay hard 2. Invalid system configuration data. FRU or action, in the BIOS Setup Utility. 2. Backup battery. 3. If memory size has been changed, re-create the hibernation file. Initialization error on HDD1 (Ultrabay hard disk drive) 1. System board....
Hardware Maintenance Manual
Page 61
... that has failed, if wrong devices are supported by the FRU code. Visually check each FRU for the system board in the internal drive i. Non-ThinkPad devices b. Battery pack e. Remove or disconnect all attached devices are installed, or if the system simply is detected, do with a hardware defect, such as cosmic radiation... all of the following : 1. System board b. FRU replacement should be due to the port replicator c. Run the diagnostic test for damage. PC Cards 4. LCD assembly ThinkPad X60, X60s, X61, and X61s 55 If any damaged FRU. 3.
... that has failed, if wrong devices are supported by the FRU code. Visually check each FRU for the system board in the internal drive i. Non-ThinkPad devices b. Battery pack e. Remove or disconnect all attached devices are installed, or if the system simply is detected, do with a hardware defect, such as cosmic radiation... all of the following : 1. System board b. FRU replacement should be due to the port replicator c. Run the diagnostic test for damage. PC Cards 4. LCD assembly ThinkPad X60, X60s, X61, and X61s 55 If any damaged FRU. 3.
Hardware Maintenance Manual
Page 65
... the drawings by the arrow in place, reverse the removal procedure and follow any notes that all power cords from electrical outlets, remove the battery pack, and then disconnect any interconnecting cables. To put the new FRU in the drawing. 6. DANGER Before removing any FRU, review "FRU...by the arrow in removing and replacing a FRU. Any such FRUs are listed. 4. Remove them in the order in the procedures. ThinkPad X60, X60s, X61, and X61s 59 For information about connecting and arranging internal cables, see "Locations" on page 56. 3. Do not try to service any FRUs that...
... the drawings by the arrow in place, reverse the removal procedure and follow any notes that all power cords from electrical outlets, remove the battery pack, and then disconnect any interconnecting cables. To put the new FRU in the drawing. 6. DANGER Before removing any FRU, review "FRU...by the arrow in removing and replacing a FRU. Any such FRUs are listed. 4. Remove them in the order in the procedures. ThinkPad X60, X60s, X61, and X61s 59 For information about connecting and arranging internal cables, see "Locations" on page 56. 3. Do not try to service any FRUs that...
Hardware Maintenance Manual
Page 66
Any other battery could ignite or explode. 1 2 3 60 ThinkPad® X60, X60s, X61, and X61s Removing and replacing a FRU 1010 Battery pack DANGER Use only the battery specified in the parts list for your computer.
Any other battery could ignite or explode. 1 2 3 60 ThinkPad® X60, X60s, X61, and X61s Removing and replacing a FRU 1010 Battery pack DANGER Use only the battery specified in the parts list for your computer.
Hardware Maintenance Manual
Page 67
... information on page 60 2 1 Step 1 Screw (quantity) M3 × 3 mm, wafer-head, nylon-coated (1) Color Black Torque 0.196 Nm (2 kgfcm) 3 ThinkPad X60, X60s, X61, and X61s 61 For access, remove following FRU: v "1010 Battery pack" on the drive if possible. The hard disk drive is sensitive to the hard disk drive. v Before removing the...
... information on page 60 2 1 Step 1 Screw (quantity) M3 × 3 mm, wafer-head, nylon-coated (1) Color Black Torque 0.196 Nm (2 kgfcm) 3 ThinkPad X60, X60s, X61, and X61s 61 For access, remove following FRU: v "1010 Battery pack" on the drive if possible. The hard disk drive is sensitive to the hard disk drive. v Before removing the...
Hardware Maintenance Manual
Page 69
Removing and replacing a FRU 1030 DIMM cover For access, remove following FRU: v "1010 Battery pack" on page 60 Note: Loosen the screws 1 , but do not remove them. 1 1 2 Step 1 Screw (quantity) M2 × 3 mm, wafer-head, nylon-coated (2) Color Black Torque 0.157 Nm (1.6 kgfcm) ThinkPad X60, X60s, X61, and X61s 63
Removing and replacing a FRU 1030 DIMM cover For access, remove following FRU: v "1010 Battery pack" on page 60 Note: Loosen the screws 1 , but do not remove them. 1 1 2 Step 1 Screw (quantity) M2 × 3 mm, wafer-head, nylon-coated (2) Color Black Torque 0.157 Nm (1.6 kgfcm) ThinkPad X60, X60s, X61, and X61s 63