Scheduled Maintenance Guide 6th Printing
Page 25
Rotation recommended for : Natural Gas Drain coalescent fuel filter bowl and replace filter Clean injectors 25 2003 Universal Service Guide (usg) Universal Service Guide USA English (fus) Replace spark plugs Change Premium Gold coolant (see exceptions page 34 and record page 48) ... 100,000 miles Cars, Minivans, Light Trucks, Sport Utilities, Vans, 4x4, Natural Gas, Propane, and Diesel Vehicles Change engine oil and replace oil filter Inspect accessory drive belt(s) Inspect tires for wear.
Rotation recommended for : Natural Gas Drain coalescent fuel filter bowl and replace filter Clean injectors 25 2003 Universal Service Guide (usg) Universal Service Guide USA English (fus) Replace spark plugs Change Premium Gold coolant (see exceptions page 34 and record page 48) ... 100,000 miles Cars, Minivans, Light Trucks, Sport Utilities, Vans, 4x4, Natural Gas, Propane, and Diesel Vehicles Change engine oil and replace oil filter Inspect accessory drive belt(s) Inspect tires for wear.
Scheduled Maintenance Guide 6th Printing
Page 33
... registered in California, the California Air Resources Board has determined that all rear wheel drive (RWD) vehicles (see page 35-36) Replace accessory drive belt(s) (if not replaced within last 100,000 miles) Replace climate-controlled seat filters (Navigator, Aviator, and LS if equipped) Additional... filter Change rear axle lubricant on all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded. 33 2003 Universal Service Guide (usg) Universal Service Guide USA English (fus) We, however, urge that the failure to perform this maintenance...
... registered in California, the California Air Resources Board has determined that all rear wheel drive (RWD) vehicles (see page 35-36) Replace accessory drive belt(s) (if not replaced within last 100,000 miles) Replace climate-controlled seat filters (Navigator, Aviator, and LS if equipped) Additional... filter Change rear axle lubricant on all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded. 33 2003 Universal Service Guide (usg) Universal Service Guide USA English (fus) We, however, urge that the failure to perform this maintenance...
7.3L Diesel Supplement 3rd Printing
Page 10
... . If the engine fails to operate the starter. This practice creates a serious fire hazard and causes engine performance problems. 1. Make sure the headlamps and vehicle accessories are off , turn the key. Depress the clutch pedal and place the gearshift in order to start your vehicle. COLD WEATHER STARTING Do not crank...
... . If the engine fails to operate the starter. This practice creates a serious fire hazard and causes engine performance problems. 1. Make sure the headlamps and vehicle accessories are off , turn the key. Depress the clutch pedal and place the gearshift in order to start your vehicle. COLD WEATHER STARTING Do not crank...
Diesel Supplement 2nd Printing
Page 10
... not started before you start , turn the key. Such fluid could cause immediate explosive damage to operate the starter. Make sure the headlamps and vehicle accessories are off , turn the key. Do not press the accelerator during starting . Do not press the accelerator during starting . This practice creates a serious fire hazard...
... not started before you start , turn the key. Such fluid could cause immediate explosive damage to operate the starter. Make sure the headlamps and vehicle accessories are off , turn the key. Do not press the accelerator during starting . Do not press the accelerator during starting . This practice creates a serious fire hazard...
Diesel Supplement 2nd Printing
Page 55
... filter • Inspect tires for wear and measure tread depth • Rotate tires • Inspect engine air filter minder, replace filter as required • Inspect accessory drive belt(s) • Change rear wheel drive (RWD) axle fluid - General Owner's Information Inspect engine cooling system and hoses Inspect brake system Inspect exhaust system...
... filter • Inspect tires for wear and measure tread depth • Rotate tires • Inspect engine air filter minder, replace filter as required • Inspect accessory drive belt(s) • Change rear wheel drive (RWD) axle fluid - General Owner's Information Inspect engine cooling system and hoses Inspect brake system Inspect exhaust system...
Diesel Supplement 2nd Printing
Page 57
... equipped, driveshaft and ball joints • Inspect engine cooling system and hoses • Inspect brake system • Inspect exhaust system and heat shields • Replace accessory drive belt(s) • Change engine coolant • Change automatic transmission fluid and external filter element • Change rear wheel drive (RWD) axle fluid -
... equipped, driveshaft and ball joints • Inspect engine cooling system and hoses • Inspect brake system • Inspect exhaust system and heat shields • Replace accessory drive belt(s) • Change engine coolant • Change automatic transmission fluid and external filter element • Change rear wheel drive (RWD) axle fluid -
Owner Guide 5th Printing
Page 3
... in whole or part is not permitted without incurring obligation. Ford may change the contents without notice and without written authorization from Ford Motor Company. Copyright © 2003 Ford Motor Company 3 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt...) USA English (fus) Table of Contents Maintenance and Specifications Engine compartment Engine oil Battery Fuel information Air filter(s) Part numbers Refill capacities Lubricant specifications 215 217 218 221 229 246 253 254 257 Accessories...
... in whole or part is not permitted without incurring obligation. Ford may change the contents without notice and without written authorization from Ford Motor Company. Copyright © 2003 Ford Motor Company 3 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt...) USA English (fus) Table of Contents Maintenance and Specifications Engine compartment Engine oil Battery Fuel information Air filter(s) Part numbers Refill capacities Lubricant specifications 215 217 218 221 229 246 253 254 257 Accessories...
Owner Guide 5th Printing
Page 52
...shade that it toward the front of obstructions and ensure that children and/or pets are designed for accessory plugs only. The auxiliary power point is shut. • To close the shade, pull it ...free of the rocker switch to open the window. Use the power point. To close the window. 52 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus) Press and hold the... in the proximity of the rocker switch to close from the plug. Do not plug optional electrical accessories into the vent position (when the glass panel is closed when the glass panel is located on ...
...shade that it toward the front of obstructions and ensure that children and/or pets are designed for accessory plugs only. The auxiliary power point is shut. • To close the shade, pull it ...free of the rocker switch to open the window. Use the power point. To close the window. 52 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus) Press and hold the... in the proximity of the rocker switch to close from the plug. Do not plug optional electrical accessories into the vent position (when the glass panel is closed when the glass panel is located on ...
Owner Guide 5th Printing
Page 53
...(IF EQUIPPED) To adjust your mirrors: 1. Window lock (if equipped) The window lock feature allows only the driver to disable the adjust function. 53 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus) Driver Controls One touch down Allows the driver's window to open fully... the right side to stop. Move the control in the direction you wish to the OFF position or until any door is opened. Accessory delay (if equipped) With accessory delay, the window switches may be used for the driver's press the left mirror or R to adjust the right mirror. 2. Press ...
...(IF EQUIPPED) To adjust your mirrors: 1. Window lock (if equipped) The window lock feature allows only the driver to disable the adjust function. 53 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus) Driver Controls One touch down Allows the driver's window to open fully... the right side to stop. Move the control in the direction you wish to the OFF position or until any door is opened. Accessory delay (if equipped) With accessory delay, the window switches may be used for the driver's press the left mirror or R to adjust the right mirror. 2. Press ...
Owner Guide 5th Printing
Page 63
... eight seconds, the trip computer will remain lit until the CAL indicator turns off all electrical accessories (heater/air conditioning, wipers, etc.) and make sure all vehicle doors are shut. 1. CAL mode is now calibrated. 63 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus) For optimum...
... eight seconds, the trip computer will remain lit until the CAL indicator turns off all electrical accessories (heater/air conditioning, wipers, etc.) and make sure all vehicle doors are shut. 1. CAL mode is now calibrated. 63 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus) For optimum...
Owner Guide 5th Printing
Page 106
... move it side to remove any slack in tether strap anchors located behind the seats as an accessory for information about ordering a tether strap. Check to the body shell on the back panel. 106 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus) Tether straps are available...
... move it side to remove any slack in tether strap anchors located behind the seats as an accessory for information about ordering a tether strap. Check to the body shell on the back panel. 106 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus) Tether straps are available...
Owner Guide 5th Printing
Page 110
... circuits operational. For more information on starting . For vehicle equipped with a manual transmission, you have difficulty starting is in this chapter. 110 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus) Key position when driving. 5. START, cranks the engine... brake pedal being depressed. LOCK, locks the steering wheel, automatic transmission gearshift lever and allows key removal. ACCESSORY, allows the electrical accessories such as the engine starts. Warning lights illuminated. Only use the accelerator when you must depress the ignition release...
... circuits operational. For more information on starting . For vehicle equipped with a manual transmission, you have difficulty starting is in this chapter. 110 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus) Key position when driving. 5. START, cranks the engine... brake pedal being depressed. LOCK, locks the steering wheel, automatic transmission gearshift lever and allows key removal. ACCESSORY, allows the electrical accessories such as the engine starts. Warning lights illuminated. Only use the accelerator when you must depress the ignition release...
Owner Guide 5th Printing
Page 111
... door before you smell exhaust fumes. Do not drive if you start the engine. The following starting the vehicle: 1. Before starting instructions are off. 111 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus) Do not park, idle, or drive your vehicle immediately. If the engine... not start a fire. Make sure all occupants buckle their proper usage, refer to the Seating and Safety Restraints chapter. 2. Make sure the headlamps and electrical accessories are for more information on safety belts and their safety belts.
... door before you smell exhaust fumes. Do not drive if you start the engine. The following starting the vehicle: 1. Before starting instructions are off. 111 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus) Do not park, idle, or drive your vehicle immediately. If the engine... not start a fire. Make sure all occupants buckle their proper usage, refer to the Seating and Safety Restraints chapter. 2. Make sure the headlamps and electrical accessories are for more information on safety belts and their safety belts.
Owner Guide 5th Printing
Page 116
... set the parking brake, press the parking brake pedal down until the parking brake is recommended that wheel chocks be required to run while power accessories operate and the parking brake is full released. The BRAKE warning lamp in 1 (First) (manual transmission). You may be used during this operation. 116...
... set the parking brake, press the parking brake pedal down until the parking brake is recommended that wheel chocks be required to run while power accessories operate and the parking brake is full released. The BRAKE warning lamp in 1 (First) (manual transmission). You may be used during this operation. 116...
Owner Guide 5th Printing
Page 170
... Vehicles and will help avoid possible powertrain and chassis damage from snowplowing. The front and rear GAWR, GVWR, Total Accessory Reserve Capacity (TARC) and tire inflation pressures are available through your Ford dealer; If a distance of 80 km (50 miles) or a speed of the vehicle with the exception of... must never exceed the front and rear GAWR or the GVWR. 170 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus) Note: Ford does not install snowplows. For low speed snow removal, Ford offers a Snowplow Package Option on the Incomplete Vehicle Label. This label is...
... Vehicles and will help avoid possible powertrain and chassis damage from snowplowing. The front and rear GAWR, GVWR, Total Accessory Reserve Capacity (TARC) and tire inflation pressures are available through your Ford dealer; If a distance of 80 km (50 miles) or a speed of the vehicle with the exception of... must never exceed the front and rear GAWR or the GVWR. 170 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus) Note: Ford does not install snowplows. For low speed snow removal, Ford offers a Snowplow Package Option on the Incomplete Vehicle Label. This label is...
Owner Guide 5th Printing
Page 171
... Compliance Certification Label to find your dealer for snowplow-equipped vehicles. Consult your vehicle's front GAWR. • The Front Axle Accessory Reserve Capacity and the TARC listed on the Safety Compliance Certification Label. • The total weight of the snowplow and aftermarket equipment...weight to the vehicle, ensure the vehicle's front toe alignment and front ride height are located in the vehicle's Workshop Manual. 171 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus) These specifications are within specification (reset if required...
... Compliance Certification Label to find your dealer for snowplow-equipped vehicles. Consult your vehicle's front GAWR. • The Front Axle Accessory Reserve Capacity and the TARC listed on the Safety Compliance Certification Label. • The total weight of the snowplow and aftermarket equipment...weight to the vehicle, ensure the vehicle's front toe alignment and front ride height are located in the vehicle's Workshop Manual. 171 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus) These specifications are within specification (reset if required...
Owner Guide 5th Printing
Page 180
...) Front wiper Brake on-off switch Instrument cluster PCM Memory Horn Trailer tow park lamps Trailer tow back-up lamps Fuel pump Instrument cluster Delayed accessory Fog lamps Not used Ignition switch Run/Start feed Left-hand lowbeam Right-hand lowbeam Not used Trailer tow electric brake Door locks/Body security... on the fly Left-hand power seats 104 105 106 107 108 109 110 111 112 40A** 30A** 30A** 40A** - 30A** 50A** 30A** 30A** 180 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus)
...) Front wiper Brake on-off switch Instrument cluster PCM Memory Horn Trailer tow park lamps Trailer tow back-up lamps Fuel pump Instrument cluster Delayed accessory Fog lamps Not used Ignition switch Run/Start feed Left-hand lowbeam Right-hand lowbeam Not used Trailer tow electric brake Door locks/Body security... on the fly Left-hand power seats 104 105 106 107 108 109 110 111 112 40A** 30A** 30A** 40A** - 30A** 50A** 30A** 30A** 180 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus)
Owner Guide 5th Printing
Page 181
... used Front blower motor relay Powertrain Control Module (PCM) relay Fuel heater relay (Diesel engine only) Heated backlight relay Trailer tow battery charge relay Delayed accessory relay Starter relay ***Circuit Breaker 304 - 305 - 306 - 307 - * Mini Fuses ** Maxi Fuses Note: (Diesel engine only) The Fuel Injection Control Module (FICM) logic 15A... mini-fuse is not recommended and may compromise the integrity of your tires. 181 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus)
... used Front blower motor relay Powertrain Control Module (PCM) relay Fuel heater relay (Diesel engine only) Heated backlight relay Trailer tow battery charge relay Delayed accessory relay Starter relay ***Circuit Breaker 304 - 305 - 306 - 307 - * Mini Fuses ** Maxi Fuses Note: (Diesel engine only) The Fuel Injection Control Module (FICM) logic 15A... mini-fuse is not recommended and may compromise the integrity of your tires. 181 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus)
Owner Guide 5th Printing
Page 192
Automatic transmissions do not touch. Park the booster vehicle close to the hood of the engine cooling fan and other accessories off. 192 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus) Turn the heater fan on both vehicles to flames, sparks, or lit ...
Automatic transmissions do not touch. Park the booster vehicle close to the hood of the engine cooling fan and other accessories off. 192 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus) Turn the heater fan on both vehicles to flames, sparks, or lit ...
Owner Guide 5th Printing
Page 208
... Motorcraft Detail Wash (ZC-3-A), which is available from your vehicle every six months will "gray" or stain the parts over time. • Remove any exterior accessories, such as antennas, before entering a car wash. • Suntan lotions and insect repellents can damage any non-body (low-gloss black) colored trim, such as... during the winter months, as dirt and road salt are difficult to remove and cause damage to the vehicle's paintwork and trim over time. 208 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus)
... Motorcraft Detail Wash (ZC-3-A), which is available from your vehicle every six months will "gray" or stain the parts over time. • Remove any exterior accessories, such as antennas, before entering a car wash. • Suntan lotions and insect repellents can damage any non-body (low-gloss black) colored trim, such as... during the winter months, as dirt and road salt are difficult to remove and cause damage to the vehicle's paintwork and trim over time. 208 2003 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus)