Troy-Bilt TB625 Support Question
Troy-Bilt TB625 Support Question
Find answers below for this question about Troy-Bilt TB625.Need a Troy-Bilt TB625 manual? We have 1 online manual for this item!
Question posted by axisbuck8point on April 8th, 2016
Fuel Tank Replacement On A Tb625 Ec
How do I replace the fuel tank on this model
Current Answers
Answer #1: Posted by Odin on April 8th, 2016 11:31 AM
Odin
Member since:
April 10th, 2010 Points: 41,236,670
Member since:
April 10th, 2010 Points: 41,236,670
Hope this is useful. Please don't forget to click the Accept This Answer button if you do accept it. My aim is to provide reliable helpful answers, not just a lot of them. See https://www.helpowl.com/profile/Odin.
Related Troy-Bilt TB625 Manual Pages
Operation Manual - Page 1
... OF PURCHASE WILL BE REQUIRED FOR WARRANTY SERVICE. When servicing, use only identical replacement parts.
769-08457 / 02
All information, illustrations, and specifications in this unit...'s Manual
Electric Start Capable 4-Cycle Trimmer
TB625 EC
TABLE OF CONTENTS Service 1 Safety 2 Know Your Unit 5 Specifications 5 Assembly 6 Oil and Fuel 8 Starting and Stopping 10 Operation 12 ...
Operation Manual - Page 2
... a SERIOUS hazard.
CALIFORNIA PROPOSITION 65
WARNING: Engine exhaust, some of its vapors
can result in any pressure in the tank before starting the unit. Replace damaged parts. Never remove the fuel tank cap or add fuel when the engine is highly flammable and its constituents and
certain finished components contain or emit chemicals known to...
Operation Manual - Page 3
...be performed by a authorized service dealer.
• Before inspecting, servicing, cleaning, storing, transporting or replacing any other than the speed needed to do a better, safer job when used at a height ...the unit out of the reach of children. • Never douse or squirt the unit with fuel in the tank, inside a building where
fumes may reach an open flame (pilot lights, etc.) or sparks...
Operation Manual - Page 4
...SAFETY & INTERNATIONAL SYMBOLS •
This operator's manual describes safety and international symbols and pictographs that fuel containing
greater than 10% ethanol will likely damage this engine and void the warranty. Read the...to operator's manual for the proper type of oil.
• DO NOT USE E85 FUEL IN THIS UNIT
WARNING: It has been proven that may get extremely hot from the operating...
Operation Manual - Page 5
...8226; 3/8" Socket
On/Off Switch
Muffler
Spark Plug
Starter Rope Grip
Primer Bulb
Fuel Cap
Handle Shaft Housing
Air Filter Cover
Throttle Control
Choke Lever
Cutting Head
Coupler... Lubrication SAE 30 Oil Crankcase Oil Capacity 2.03 oz. (60 ml) Fuel Tank Capacity 12 oz. (355 ml) Approximate Unit Weight (No fuel, with this unit. We reserve the right to make changes at the time of...
Operation Manual - Page 8
...OIL: INITIAL USE
WARNING: OVERFILLING THE CRANKCASE MAY
CAUSE SERIOUS PERSONAL INJURY. Change the oil according to the fuel tank. DO NOT
overfill. DO NOT mix oil with a 2.03 fluid oz. (60 ml) bottle of ... Remove the cap from the oil bottle. Use the bottle to Checking the Oil Level. OIL AND FUEL
USING THE RIGHT OIL
Use a high-quality SAE 30 weight oil. NOTE: This unit comes with gasoline...
Operation Manual - Page 9
... and allow it to avoid injury
from fuel spray. WARNING: Remove the fuel cap slowly to cool before filling the fuel tank. NOTE: Do not overfill the tank. 4.
Wipe up any spilled fuel immediately. Using Fuel Additives Use a fuel additive, such as ethanol, methanol or MTBE (ether).
Definition of Blended Fuels Today's fuels are often a blend of gasoline and oxygenates...
Operation Manual - Page 10
...10 Carbon monoxide exhaust fumes can be used during this time. Check the oil level. Fill the fuel tank. Refer to squeeze the throttle control. NOTE: There is in a confined area. Crouch in the... NOTE: SQUEEZE and HOLD the throttle control for 30 to squeeze the throttle control. Continue to Fueling the Unit. The unit may be in a well-ventilated
outdoor area. IF THE UNIT WAS RUN...
Operation Manual - Page 11
...accessory in the ON ( I ) position at all times (Fig. 9).
3.
Item No.
Fill the fuel tank. NOTE: There is in intervals no longer than 2 seconds each until the unit starts. Crouch in ...Check the oil level. Refer to squeeze the throttle control. Run the electric start . Continue to Fueling the Unit. Move the choke lever to Position 3.
IF...
IF... If it does not, ...
Operation Manual - Page 13
.... NOTE: Some maintenance procedures may not release properly if the line is running. NOTE: Maintenance, replacement, or repair of the emission control devices and system may cause the engine to prevent the unit ... came with the unit for a complete listing of new trimming line. 3.
REPLACING THE TRIMMING LINE
Only use the trimming line described in the table.
Always allow the unit ...
Operation Manual - Page 16
...and pull it with a 5/8-inch socket, turning counterclockwise. Do not over tighten.
6. If, after checking the fuel and cleaning the air filter, the engine still will not idle • the engine hesitates or stalls on ...If the spark plug is cracked, fouled or dirty, replace it from the cylinder head with replacement part #753-05784, a Champion RDZ4H or an equivalent spark plug.
4.
Operation Manual - Page 17
... Pull the starter rope slowly to run until it stalls. Remove the spark plug and drain all fuel has been drained from the cylinder. 2.
Allow the engine to cool before storing. • Lock ...Use a small brush to Changing the Oil. Reinstall the fuel cap.
2. Remove the spark plug and put 5 drops of the unit. Repair or replace damaged parts and tighten loose screws, nuts or bolts. ...
Operation Manual - Page 18
... assistance is extended
Clean or replace the air filter Drain the fuel tank and add fresh fuel Adjust the idle speed
Drain the fuel tank and add fresh fuel Stop the engine and clean the cutting head Clean or replace the air filter
Drain the fuel tank and add fresh fuel Clean or replace the air filter Replace the spark plug
Stop the...
Operation Manual - Page 20
...without limitation, expenses incurred for substitute or replacement lawn care services, for transportation or for related expenses, or for rental expenses to temporarily replace a warranted product. (Some states do ...Wear items - During the period of the Warranty, the exclusive remedy is repair or replacement of the product as set forth in material or workmanship. To locate your property and/...
Similar Questions
Fuel Tank
How do you remove the fuel tank on a troy built TB625EC leaf blower
How do you remove the fuel tank on a troy built TB625EC leaf blower
(Posted by Anonymous-172522 1 year ago)
Different Fuel Tank Than Is Shown In You Tube
My TB2BP EC has some different installion than the one shown on the video. It appears I have to remo...
My TB2BP EC has some different installion than the one shown on the video. It appears I have to remo...
(Posted by e2551 1 year ago)
How Do I Replace The Primer Bulb On Tb625 Ec
How do I get the cover off a Troy Bilt TB625 EC Trimmer so I can replace the Primer bulb
How do I get the cover off a Troy Bilt TB625 EC Trimmer so I can replace the Primer bulb
(Posted by Myers8708 2 years ago)
Where Can I Find The Service Repair Manual For Tb625 Ec
I need to work in the engine and need engine specs thanks
I need to work in the engine and need engine specs thanks
(Posted by floresluisg68 3 years ago)
How Do I Remove The Cutting Head Of The Tb625 Ec Trimmer
head removal instructions.
head removal instructions.
(Posted by Anonymous-150877 9 years ago)