Home » Troy-Bilt » Lawn & Garden » Troy-Bilt TB4BP

Troy-Bilt TB4BP Support Question

Find answers below for this question about Troy-Bilt TB4BP.
Need a Troy-Bilt TB4BP manual? We have 1 online manual for this item!

Troy-Bilt Overview Questions Manuals Reviews Videos Research

Question posted by Lincoln21184 on August 17th, 2014

My Blower Started Running Hot And Blowing Oil From The Breather

The oil is at the bottom of the fill. It idles fine, but blow oil and runs hot. Never had a problem before. spark plug is Clean as is exhaust? Help!

I Know the Answer!

I have the same question
Request More Information

Current Answers

There are currently no answers that have been posted for this question.
Be the first to post an answer!

Remember that you can earn up to 1,100 points for every answer you submit. The better the quality of your answer, the better chance it has to be accepted.

Related Troy-Bilt TB4BP Manual Pages

Operation Manual - Page 1

... Know Your Unit 5 Assembly Instructions 6 Oil and Fuel 8 Starting/Stopping Instructions 9 Operating Instructions 10 Maintenance and Repair Instructions 11 Cleaning and Storage 13 Troubleshooting 14 Specifications 15 Warranty...Before beginning, locate the unit's model plate. Operator's Manual 4-Cycle Backpack Blower TB4BP SAVE THESE INSTRUCTIONS For service call 1-800-828-5500, or 1-800-668-...

Operation Manual - Page 2

...sparks and open flames away from oil and fuel. • Avoid accidental starting...starting . May be installed properly before filling the fuel tank. Please keep these requirements could subject you must follow the safety precautions to liability or a fine...; Never run the unit...Oregon and Washington. Breathing exhaust fumes can result in ...is hot. ...only in a clean, well-ventilated...

Operation Manual - Page 3

... disconnect the spark plug for maintenance or repair. • Never point the blower or blowing debris in ...operation is running. Always direct the blowing debris away from debris. Keep handles dry, clean, and ... use them . These parts get extremely hot from grass, leaves, excessive grease or ...in use , see Cleaning and Storage instructions. • Keep these problems. Users who operate ...

Operation Manual - Page 4

... / START / RUN • WARNING: READ OPERATOR'S MANUAL Read the operator's manual(s) and follow all warnings and safety instructions. Failure to do so can cause severe eye injury and hearing loss. Use a full face shield when needed . • CHOKE CONTROL 1. • FULL choke position 2. • PARTIAL choke position 3. • RUN choke position • HOT SURFACE...

Operation Manual - Page 5

KNOW YOUR UNIT Suspension System Shoulder Support Choke Lever Air Filter Cover Starter Rope Handle Gas Cap Shoulder Support Buckle Trigger Lock Throttle Grip Trigger Stand Waist Support Clip Waist Support Throttle Cables Blower Tube Primer Bulb Muffler Nozzle Gas Tank Oil Fill Plug Elbow Tube 5

Operation Manual - Page 6

... bump on it over the end of the hose with the clamp on the elbow tube (Fig. 1C). 4. Tighten the screw on the second lower blower tube (Fig. 4, A). 6. Align the bump on the Flex Tube with the clamp on the bottom end of the Flex Tube with the bump on the...

Operation Manual - Page 7

... the Handle 1. This may cause the throttle cables to disconnect from the backpack blower is pointing directly downward (Fig. 7, A). First Lower Blower Tube Second Lower Blower Tube Fig. 8 Nozzle Fig. 6 WARNING: To avoid serious personal injury, make sure that the blower tubes are locked in place or firmly installed. 7 WARNING: Do not rotate the...

Operation Manual - Page 8

...oil in the crankcase before starting the engine. Tilt the unit backwards 30° Oil Fill Hole (Fig. 11). 4. Refer to the unit's gas tank. CHECKING THE OIL LEVEL Check the oil only when the engine is off the funnel spout (Fig. 9). 2. Remove the oil fill plug... any oil that may have spilled. 4. Keep sparks and ... and run the engine dry before... use fresh, clean, unleaded gasoline...

Operation Manual - Page 9

... Unit. 3. To avoid serious personal injury, make sure that the blower tube is already hot, place the choke lever in a confined area. Some amount of fuel should be lethal in Position 3 and pull the starter rope to start engine. 6. IF... IF... Check the oil level in Position 1 (Fig. 14). Refer to a complete stop (Fig...

Operation Manual - Page 10

... any loose debris before starting the unit. • Verify that the unit is required. • Operate power equipment only at the lowest possible speed to do the job. • Check your equipment before you . 2. not early in dusty locations. Use the blower around buildings and for many lawn and garden applications, including areas such...

Operation Manual - Page 11

... to dry. 4. NOTE: If the unit is cold Change oil Clean and re-oil air filter Check rocker arm clearance and adjust Check spark plug condition and gap Clean spark arrestor SEE p 8 p 8 p 11 p 11 p 12 p 13 p 13 CHANGING THE OIL Change the oil every 25 hours of operation. Disconnect the spark plug wire to Federal, State and local regulations. 4. MAINTENANCE SCHEDULE...

Operation Manual - Page 12

... filter cover. Idle Adjustment Screw NOTE: Careless adjustments can seriously damage your unit. This is a loss of the back plate (Figs. 24 & 28). 8. Start the engine and let it run at the top of engine power Have the carburetor adjusted by turning a 5/8 in. Remove the engine cover (Fig. 30). 5. Check that: Spark Plug Hole •...

Operation Manual - Page 13

... and exhaust valves. Wipe off the outside of the oil from the spark plug. 3. Drain all gasoline from around the spark plug. Reinstall the spark plug. Repair...oil into a container. Start the engine and allow it . 6. Remove the spark plug and put 5 drops of children. NOTE: Remove the spark plug and drain all gasoline has been drained from the spark arrestor cover. 5. Thoroughly clean...

Operation Manual - Page 14

... NOT START CAUSE Empty fuel tank Primer bulb wasn't pressed enough Old fuel ACTION Fill fuel tank with fuel Press primer bulb fully and slowly 10 times Drain gas tank and add fresh fuel Fouled spark plug Plugged spark arrestor ENGINE WILL NOT IDLE CAUSE Air filter is plugged Old fuel Improper carburetor adjustment Replace or clean the spark plug Clean...

Operation Manual - Page 15

... Displacement 1.95 in.3 (32 cc) Operating RPM 5,500-6,500 rpm Idle Speed RPM 3,800-4,400 rpm Ignition Type Electronic Ignition Switch Rocker Switch Valve clearance 0.003-0.006 in. (0.076-0.152 mm) Spark Plug Gap 0.025 inch (0.635 mm) Lubrication SAE 30 Oil Crankcase Oil Capacity 3.04 oz (90 ml) Fuel ...Unleaded Carburetor Diaphragm, All-Position...

Operation Manual - Page 16

...on your small off -road engine to a Troy-Bilt Authorized Service Center as soon as a problem exists. Any replacement part that you warranty coverage if your small off -road engine or a...connectors and other engine components caused by the failure of time up / fuel filter, ignition module, spark plug, and muffler. The warranty repairs should however be performed at : 1-800-828-5500. • ...

Operation Manual - Page 17

... include parts such as the problem exists. The manufacturer issuing the warranty will not be warranted for the part. (4) Repair or replacement of your Lawn & Garden fuel tank to Troy-Bilt ...Requirements (a) The warranty period begins on your 2007 model year and later small off -road Lawn & Garden engine for the period listed below provided there has been no charge to the owner at ...

Operation Manual - Page 18

... design of any Troy-Bilt Product without limitation, expenses incurred for substitute or replacement lawn care services, for transportation or for related expenses, or for products sold or exported...arising out of express written warranty above as to ninety (90) days from the sales. Spark Plugs, Carburetor Adjustments, Filters B. How State Law Relates to this Warranty: This warranty gives you...

Operation Manual - Page 55

MODEL TB4BP 4-CYCLE GAS BACKPACK BLOWER 7 5 6 24 14 17 5 3 4 20 2 2 1 13 12 19 17 16 15 17 18 15 14 14 21 22 23 9 10 8 11 Item 1 ...753-05641 753-05642 753-05655 753-05656 753-05647 753-05646 753-05648 Description Nozzle Lower Blower Tube Throttle Grip Assembly Upper Blower Tube Clamp Flex Tube Elbow Tube Waist Support Clip Suspension System (includes 8) Nut Spacer Insulator Mount...