Troy-Bilt TB225 Support Question
Troy-Bilt TB225 Support Question
Find answers below for this question about Troy-Bilt TB225.Need a Troy-Bilt TB225 manual? We have 1 online manual for this item!
Question posted by daviderickson11 on February 21st, 2014
My Tb225 Was Running Good And It Just Stopped Have You Had Any Problems With The
engine or tiller locking up. my engine will not turn over its locked up.any sugestons .
Current Answers
Related Troy-Bilt TB225 Manual Pages
Operation Manual - Page 1
... at the time of authorized service dealers near you. Operator's Manual
2-Cycle Gas Cultivator
TB225
TABLE OF CONTENTS Service Information 1 Rules for Safe Operation 2 Know Your Unit 5 Specifications 5 Assembly Instructions 6 Oil and Fuel Information 7 Starting and Stopping Instructions 8 Operating Instructions 9 Maintenance and Repair 10 Cleaning and Storage 13 Troubleshooting Chart...
Operation Manual - Page 2
...instructions vital to cause cancer and birth defects or other objects that are approached, stop the engine and allow it returns automatically to ensure the safety of the operator and any... keep these instructions before starting the unit. Do not smoke. • Never start or run the unit inside a closed room or building. Wash hands after handling. Please read these instructions...
Operation Manual - Page 3
... not in daylight or good artificial light.
• Avoid accidental starting. Do not run the unit at the intended rate.
• Always stop the unit immediately and check for its intended purpose.
• Always hold the unit with loose or damaged parts.
• Turn the engine to vibrate abnormally, stop moving parts have stopped. 3. Stop the unit. 2. Oil...
Operation Manual - Page 4
...Stop the engine ...STOP CONTROL OFF or STOP
• PRIMER BULB Push primer bulb, fully and slowly, 10 times.
• CHOKE CONTROL 1. • FULL choke position 2. • PARTIAL choke position 3. • RUN choke position
• THROWN OBJECTS AND ROTATING CUTTER CAN CAUSE SEVERE INJURY
WARNING: Small objects can
cause severe eye injury and hearing loss. When turned...8226; GARDEN CULTIVATORS -...
Operation Manual - Page 5
...
Handlebar Knobs
Upper Handle On/Off Control
Primer Bulb
Tine Guard Gear Box
Fuel Cap Lower Handle Wheel Assembly
Tines
SPECIFICATIONS*
Engine Type Air-Cooled, 2-Cycle Displacement 25 cc (1.52 cu. We reserve the right to medium soil • Cultivating in...APPLICATION • Cultivating sod and light to make changes at the time of printing.
in garden areas, around trees, etc.
Operation Manual - Page 6
... on its side (Fig. 1). 2.
Insert the clevis pin through the wheel bracket and wheel
assembly and lock it in place (Fig. 3). This will lower the wheel height. NOTE: It may be installed when ...operating the unit. Insert the clevis pin through the wheel bracket and assembly
and lock it in place with the cotter pin (Fig. 1). Loosen the two knobs on the inside...
Operation Manual - Page 7
...Today's fuels are the main reasons for the unit not running properly. Always stop the engine and allow it to avoid injury from the area. WARNING: Remove fuel .... NOTE: Dispose of 2-cycle oil makes a 40:1 fuel/oil ratio.
When using alcohol-blended fuel, use a good 2-cycle oil designed for spilt fuel. Do not mix them directly in a clean, well ventilated outdoor
area. Unleaded ...
Operation Manual - Page 8
...the throttle control. Move the choke lever to turn the unit on. IF... Pull the starter rope 3-8 times in the starting .
STARTING AND STOPPING INSTRUCTIONS
WARNING: Avoid accidental starting the unit ... 3. Run the unit for an additional 60 seconds to cool down by idling. 2. NOTE: The unit is visible.
4.
IF...
The engine does not start the engine.
9.
IF... The engine should...
Operation Manual - Page 9
... UNIT
WARNING: To prevent serious personal injury, always
stop the engine when operation is running.
2. Tilt the unit back until the tines make...garden soils approximately 4 to the next location. Reconnect the spark plug wire and continue use extreme
caution when reversing or pulling the unit towards you are digging too deep or not deep enough, adjust them according to
increase the engine...
Operation Manual - Page 10
...the operating position. NOTE: Each tine has a convex side. Make sure that the cultivator is running.
FREQUENCY Every 10 hours
Every 25 hours
MAINTENANCE REQUIRED
Clean and re-oil the air filter. ... off the tines and shaft
for easier tine removal. 3. Secure the new tines to cool. Stop the engine and allow the unit to Maintaining the Air Filter. Refer to prevent the unit from the spark...
Operation Manual - Page 11
...may turn at a time (as needed ) until the engine idles smoothly (Fig. 11). Checking the fuel mixture, cleaning the air filter, and adjusting the idle speed screw should solve most engine problems....screw (Fig. 9). 2. Tighten the cover screw to warm up.
Start the engine and let it (Fig. 9). 3. If the engine stops, use a small Phillips screwdriver to the right and align the cover screw
...
Operation Manual - Page 12
... using a torque wrench, torque to cool. REPLACING THE SPARK PLUG
1. Remove the spark plug from the cylinder head by turning a 5/8 in the engine could damage the cylinder.
3. Inspect the spark plug. Stop the engine and allow it clockwise until snug. If the spark plug is cracked, fouled or dirty, replace it with a 5/8-inch socket...
Operation Manual - Page 13
...-ventilated area. • Store the unit out of the reach of old gasoline in a locked up area to prevent
unauthorized use strong detergents or petroleum based cleaners, like
kerosene. STORAGE •...engine to cool before storing. • Store the unit in accordance with a soft cloth. CLEANING AND STORAGE WARNING: To avoid serious personal injury, always turn
your unit off and allow it to run...
Operation Manual - Page 14
...starter rope Drain the fuel tank and add fresh, properly mixed fuel Replace or clean the spark plug
ENGINE WILL NOT IDLE Air filter is plugged The fuel is old (over 30 days) and/or improperly mixed...clean the air filter Drain the fuel tank and add fresh, properly mixed fuel Adjust the idle speed
ENGINE WILL NOT ACCELERATE The fuel is old (over 30 days) and/or improperly mixed Dirty air filter
...
Operation Manual - Page 16
... unless prior written permission has been extended by the Customer Service Department of any Troy-Bilt Product without limitation, expenses incurred for substitute or replacement lawn care services, for transportation or for related expenses, or for rental expenses to temporarily replace a warranted product. (Some states do not allow limitations on the...
Similar Questions
Troy-bilt Tb225
I have this tiller model it was only used twice. It has new fuel and new spark plugs, getting fuel a...
I have this tiller model it was only used twice. It has new fuel and new spark plugs, getting fuel a...
(Posted by donniebailey1962 3 years ago)
My Mower Was Running Fine Then Just Quit Yes It Has Plenty Of Gas.
I was mowing my yard and my m I were quit running, it has plenty of gas. What could be my problem ?
I was mowing my yard and my m I were quit running, it has plenty of gas. What could be my problem ?
(Posted by Mama143papa 7 years ago)
My Troy Bilt Tb225 Tiller Will Not Start.
My tiller ran last week but I cannot get it to run now. I have spark, fresh fuel and I am not sure t...
My tiller ran last week but I cannot get it to run now. I have spark, fresh fuel and I am not sure t...
(Posted by davemcnees 8 years ago)
Tb2044xp Coil Clearance
What is the distance between the coil and flywheel on tb2044?My trimmer only runs good if I have spa...
What is the distance between the coil and flywheel on tb2044?My trimmer only runs good if I have spa...
(Posted by bjstrieff 10 years ago)
How To Repair Troy-bilt Tb225 Starter Rope
how to repair Troy-bilt tb225 starter rope
how to repair Troy-bilt tb225 starter rope
(Posted by Rrodock 10 years ago)