Troy-Bilt TB225 Support Question
Troy-Bilt TB225 Support Question
Find answers below for this question about Troy-Bilt TB225.Need a Troy-Bilt TB225 manual? We have 1 online manual for this item!
Question posted by Nayrons on August 27th, 2014
Engine Won't Run Unless Choke Is On
The person who posted this question about this Troy-Bilt product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related Troy-Bilt TB225 Manual Pages
Operation Manual - Page 1
Operator's Manual
2-Cycle Gas Cultivator
TB225
TABLE OF CONTENTS Service Information 1 Rules for Safe Operation 2 Know Your Unit 5 Specifications 5 Assembly Instructions 6 Oil and Fuel Information 7 Starting and Stopping Instructions 8 Operating Instructions 9 ...
Operation Manual - Page 2
... prevention measures. Failure to obey a safety WARNING signal CAN result in effective working order, or the engine be thrown or become entangled with the unit. • Clear the area of children, bystanders and ... fuel tank cap slowly to relieve any danger. Do not smoke. • Never start or run the unit inside a closed room or building. RULES FOR SAFE OPERATION
The purpose of safety symbols...
Operation Manual - Page 3
... than the maintenance procedures described in this unit. Always keep proper footing and balance. Do not run the unit at high speed when not in the starting . Do not operate the unit before ...you.
• Keep hands, face, and feet away from debris. The tines remain stationary when the engine is dusty.
• Wear heavy long pants, boots, gloves and a long sleeve shirt. These are...
Operation Manual - Page 4
... protection meeting current ANSI Z87.1 standards and ear protection when operating this engine and void the warranty.
Keep away from the rotating rotor.
•...bulb, fully and slowly, 10 times.
• CHOKE CONTROL 1. • FULL choke position 2. • PARTIAL choke position 3. • RUN choke position
• THROWN OBJECTS AND ROTATING CUTTER CAN ...GARDEN CULTIVATORS -
Operation Manual - Page 5
...Starter Rope Grip
Choke Lever
Throttle Control
Handlebar Knobs
Upper Handle On/Off Control
Primer Bulb
Tine Guard Gear Box
Fuel Cap Lower Handle Wheel Assembly
Tines
SPECIFICATIONS*
Engine Type Air-...product information available at any time without notice.
5 in garden areas, around trees, etc.
APPLICATION • Cultivating sod and light to make changes at the time of printing...
Operation Manual - Page 7
...8226; Always agitate the fuel mix before fueling the unit • Drain the tank and run the engine dry before storing the unit
Using Fuel Additives
The bottle of 2-cycle oil that may ...unleaded fuel. Avoid creating a source of ignition for the unit not running properly. Mixing the Fuel
CAUTION: For proper engine operation and maximum
reliability, pay strict attention to use fresh fuel (less...
Operation Manual - Page 8
... Position 2 and continue the warm-up .
The engine hesitates, return the choke lever to start .
The engine does not start after 2 attempts, move the choke lever to complete the warm-up .
Make sure... the Unit.
Continue to step 3. Run the unit for ALL further steps.
Fully press and release the primer bulb 10 times, slowly. Allow the engine to hold the On/Off Control in...
Operation Manual - Page 9
... to
increase the engine speed. 4. With the tines off the ground, squeeze the throttle control to Moving the Unit. ADJUSTING THE TINE DEPTH The tines should penetrate most garden soils approximately 4... plug. 2. MOVING THE UNIT
WARNING: To prevent serious personal injury, always
stop the engine when operation is running.
2. Push or pull the unit to the next location. Once the ground has been...
Operation Manual - Page 10
...replacement, or repair of the shaft. 4. Check the spark plug condition and gap.
Stop the engine and allow the unit to the shaft with the hubs facing in towards each end of the
convex...accidentally. Make sure that came with the handles
touching the ground so that the cultivator is running. Click Pin
Convex Side
Hubs
Hubs Click Pin
Direction of terms and coverage for easier tine ...
Operation Manual - Page 11
...a turn at a time (as needed ) until the engine idles smoothly (Fig. 11). Remove the air filter and the screen that sits behind it run for about 2-3 minutes at a high
speed (full throttle)...Failure to maintain your air filter properly can result in poor performance or can seriously damage your engine. 1. Open the air filter cover by an authorized service dealer. Apply enough clean SAE ...
Operation Manual - Page 12
...or equivalent spark plug.
4. Remove the spark plug from the cylinder head by turning a 5/8 in the engine could damage the cylinder.
3. Grit in . Do not over tighten.
6. REPLACING THE SPARK PLUG
1.... Use a feeler gauge to cool. Inspect the spark plug. Stop the engine and allow it clockwise until snug.
If the spark plug is cracked, fouled or dirty, replace...
Operation Manual - Page 13
... cap, tip the unit and drain the fuel into the cylinder. Dispose of children. Allow the engine to distribute the oil. Repair or replace damaged parts and tighten loose screws, nuts or bolts. ... to keep
the air vents free of any loose or damaged parts. Start the engine and allow it to run until it stalls. Thoroughly clean the unit and inspect for any high quality motor oil...
Operation Manual - Page 14
... the primer bulb 10 times or until fuel is visible Place choke lever into position 3, squeeze the throttle trigger and pull the starter rope Drain the fuel tank and add fresh, properly mixed fuel Replace or clean the spark plug
ENGINE WILL NOT IDLE Air filter is plugged The fuel is old...
Operation Manual - Page 16
... or consequential loss or damages including, without limitation, expenses incurred for substitute or replacement lawn care services, for transportation or for related expenses, or for a period of two ... guaranty, whether written or oral, except as identified. Troy-Bilt shall not be accepted unless prior written permission has been extended by any person or entity, including a dealer or retailer...
Similar Questions
No Start,no Spark
tiller was running great and then the tines got bound up with roots. I cleared the jam and then no s...
tiller was running great and then the tines got bound up with roots. I cleared the jam and then no s...
(Posted by fredo2369 3 years ago)
My Troy Bilt Won't Stay Running Unless I Keep Pumping Primer. What To Do.
(Posted by Tayl8kr 3 years ago)
It Runs Great But When I Pull The Trigger, The Head Won't Spin.
The head quit spinning, the engine starts and runs great but when I pull the trigger , the head won'...
The head quit spinning, the engine starts and runs great but when I pull the trigger , the head won'...
(Posted by Rjkaplan7 8 years ago)
My Tb225 Was Running Good And It Just Stopped Have You Had Any Problems With The
engine or tiller locking up. my engine will not turn over its locked up.any sugestons .
engine or tiller locking up. my engine will not turn over its locked up.any sugestons .
(Posted by daviderickson11 10 years ago)