Toro 38025 Support Question
Toro 38025 Support Question
Find answers below for this question about Toro 38025 - 18" Power Curve Electric Snow Thrower.Need a Toro 38025 manual? We have 2 online manuals for this item!
Question posted by Kevsmith0619 on February 13th, 2014
Blade???
How do I change the blade I have the sides off and have the white plastic wheel off but how do I get the bar out to replace blade??? Thanks for any help
Current Answers
Related Toro 38025 Manual Pages
Operation Manual - Page 1
...from an Authorized Service Dealer or at www.Toro.com for product and accessory information, help finding a dealer, or to operate and maintain your product ready.
It is not ... 3371-667 Rev A
Operator's Manual
Replacement parts are responsible for operating the product properly and safely. Introduction
Model No. This rotary-blade, walk-behind lawn mower is a violation of California to...
Operation Manual - Page 2
...death. Replacements may ricochet back toward anyone enters the area.
• Do not operate machine barefooted or while wearing sandals. Safety
This lawn mower meets or exceeds the CPSC blade safety ...if anyone .
Operation on the machine and in serious injury or death. Exercise extreme caution when changing direction on a slope, do not mow it.
• Mow across the face of objects...
Operation Manual - Page 3
...plastic liner. WARNING
Exhaust contains carbon monoxide, an odorless, deadly poison that children will remain where you last saw them .
• Do not change... clothing, change the engine governor setting or overspeed the engine.
• Maintain or replace safety and... frequently and replace with safety devices. Repair, if necessary, before filling.
• Remove gas-powered equipment from ...
Operation Manual - Page 4
... side on charging the battery; Lock
112-8867 2. Unlock
114-7982
1. Replace damaged decals.
contains lead; Thrown object hazard-keep bystanders a safe distance from the original machine manufacturer.
94-8072
104-7953
1. Cutting/dismemberment hazard of hand or foot, mower blade-do not discard. 2. and look behind you when backing up and down...
Operation Manual - Page 5
... on the dipstick, slowly pour a small amount of oil into the oil fill tube, then remove the dipstick.
5. Setup
Important: Remove and discard the protective plastic sheet that you install the handle.
2
Filling the Engine with Oil
No Parts Required
Procedure
Important: Your mower does not come with oil. Important: Route...
Operation Manual - Page 6
... yearly thereafter. Product Overview
3
Charging the Battery
No Parts Required
Procedure
Electric-start models only)
6 Bag-on the dipstick reads Full.
6. Grass bag 2. Important: Change the engine oil after the first 5 operating hours;
Figure 5
1. Blade control bar
9. Fuel tank cap
11. Side discharge chute
3. Drain the excess oil until the oil level on -demand lever...
Operation Manual - Page 8
...102 mm).
8
Figure 11 Turn the ignition key (Figure 11) (electric-start models only) or pull the recoil start handle, pull it sharply...); 3-5/8 inches (92 mm); Adjust the cutting height as the rear wheels (Figure 9). Set the front wheels to the same height as desired.
Raise the mower
Figure 9 2. ... contact with the moving blade, causing serious injury.
• Stop the engine and wait...
Operation Manual - Page 9
... personal injury or death to disengage the wheel drive.
If the bag-on the upper handle and your elbows at your sides, and the mower will automatically keep pace with you release the blade control bar, both the engine and blade should stop the engine, release the blade control bar. Note: Remove the ignition key when you...
Operation Manual - Page 10
...either collect or recycle grass and leaf clippings while the grass bag is sharp; WARNING
The blade is attached to the operator or bystanders. Removing the Grass Bag
To remove the bag,... reverse the steps above.
Grass bag pin (2)
2. Lower the rear deflector.
contacting the blade can result in bagging position)
1.
lever forward until the button on -demand door and the surrounding...
Operation Manual - Page 11
... tall grass. Figure 17
Removing the Side Discharge Chute
To remove the side discharge chute, lift up the side deflector and install the side discharge chute (Figure 17).
1.
Installing the Side Discharge Chute
Lift up the side deflector, remove the side discharge chute, and lower the side discharge deflector.
11 WARNING
The blade is in serious personal injury. contacting...
Operation Manual - Page 12
... are more than one pass over the lawn for damage.
• For best performance, install a new blade before the cutting season begins.
• Replace the blade when necessary with a Toro replacement blade. Overlap cutting swaths instead of cutting a full swath with the blade. Set the cutting height on the front wheels one notch lower than 5 inches (13 cm...
Operation Manual - Page 13
... can cause personal injury.
Important: Before tipping the mower to change the oil or replace the blade, allow the fuel tank to the spark plug.
Figure 18
3. clean it sharpened (more frequently in dusty operating conditions. Maintenance
Note: Determine the left and right sides of fuel, use or daily
Every 25 hours Before storage
Yearly...
Operation Manual - Page 15
... from the battery.
• A flashing light that alternates between red and green indicates that the charger is fully charged. Battery 4. Wash hands after handling.
Replacing the Fuse
Electric-start models only
WARNING
CALIFORNIA Proposition 65 Warning Battery posts, terminals, and related accessories contain lead and lead compounds, chemicals known to the State...
Operation Manual - Page 16
...
(Figure 25). Fuse
Figure 24
G017398
2.
Refer to install the blade properly. Tip the mower onto its side with the screw that you run out of wood, put your weight behind the
16 Lower the rear deflector. Replacing the Blade
Service Interval: Yearly
Important: You will need a torque wrench to Preparing for Maintenance. 2. Install...
Operation Manual - Page 18
...handle knobs until you fold the handle.
Loosely install the spark plug.
9. Charge the battery for 24 hours (electric-start model only). 2. WARNING
Folding or unfolding the handle improperly can explode.
• Do not store gasoline ... of the year, add fuel stabilizer to the spark plug.
18 Connect the wire to the fuel as shown in your automobile. Tighten all nuts, bolts, and screws...
Operation Manual - Page 20
... or if it is covered under "Lawn Mowers") or access our web site ...replacement parts. This express warranty does not cover the following:
• Cost of regular maintenance service or parts, such as filters, fuel,
lubricants, oil changes, spark plugs, air filters blade sharpening or worn blades...
Limited Warranty for Commercial Use*
Gas-powered Toro Products used for indirect, incidental,...
Parts Catalog - Page 1
Form No. 3362-566 Rev A
1800 Power Curve® Snowthrower
Model No. 38025-Serial No. 310000001 and Up
Parts Catalog
Register at www.Toro.com.
Original Instructions (EN)
Parts Catalog - Page 2
...Replacement Parts
To order replacement... thread forming PRH: phillips round head PTH: phillips truss head
PTO: power-take-off RH: right hand ROPS: roll-over protection system SFH:...wheel by reference number 6, you may also order any part individually. However, you receive all parts identified by reference number 37 are indicated.
List of Abbreviations
AR: as required ASM: assembly BBC: blade...
Parts Catalog - Page 4
... Description
1 73-9370
2 Plate-Side
2 94-4496
19 Screw-PPH
3 32112-1
2 Pushnut-Cap, Washer
4 73-5720
2 Wheel
7 73-0370
1 Shaft-Axle
...8 64-5820
1 Relief-Strain
9 73-0450
1 Decal-Danger
11 218-511
2 Connector
12 73-9320
1 Shroud-Housing
13 256-307
1 Bushing
14 73-0280
1 Tube-Lower Handle
15 73-3630
1 Wire Harness
17 73-1800
1 Filter-Foam
18...
Parts Catalog - Page 5
Part Number Qty. Description
1 73-3510
1 Bar-Switch
2 64-4930
1 Switch
3 73-5700
1 Handle-Control, Upper
4 73-5190
1 Key
5 73-5710
1 Handle-Control, ...2 Nut-Lock, NI 1 Decal-Escutcheon
15 73-0240 16 73-0230
1 Rod-Crank, Chute 1 Gear-Crank, Chute
17 73-0310 18 256-306
1 Plate-Escutcheon 1 Bushing-Nyliner
20 73-3450
2 Spring
21 73-3710
1 Brake-Gear
22 114-8986
1 Decal-Operation
3...
Similar Questions
Small Belt On 1800 Power Curve Snowthrower Model 38025 Keeps Shredding
The small belt on the small pulley on my Toro 1800 Power curve snowthrower model 38025 shreds after ...
The small belt on the small pulley on my Toro 1800 Power curve snowthrower model 38025 shreds after ...
(Posted by yebos 8 years ago)
Toro Power Shovel 38360 Manual
While using my unit today for snow removal from a deck, the snow-thrower rotor quit rotating. The el...
While using my unit today for snow removal from a deck, the snow-thrower rotor quit rotating. The el...
(Posted by jimfmuir 10 years ago)
15 Amp Circuit Breaker Blowing
I have one of the early Power Curve 1800’s. It has run flawlessly until this week. Yesterday, ...
I have one of the early Power Curve 1800’s. It has run flawlessly until this week. Yesterday, ...
(Posted by edabar 13 years ago)
Circuit Breaker Blowing (15 Amp)
I have one of the first Power Curve 1800's. This year, for the first time, after 30-60 minutes of us...
I have one of the first Power Curve 1800's. This year, for the first time, after 30-60 minutes of us...
(Posted by edabar 13 years ago)