2002 Pontiac Sunfire Support Question
2002 Pontiac Sunfire Support Question
Find answers below for this question about 2002 Pontiac Sunfire.Need a 2002 Pontiac Sunfire manual? We have 1 online manual for this item!
Question posted by andyppolom on July 13th, 2014
How To Open Collant Surge Tank Cap 2002 Sunfire
The person who posted this question about this Pontiac automobile did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related Manual Pages
Owner's Manual - Page 2
Part Number 22673534 A First Edition
ECopyright General Motors Corporation 06/06/01
All Rights Reserved
i 2002 Pontiac Sunfire Owner's Manual
Litho in U.S.A.
Owner's Manual - Page 3
..., so it will be there if you ever need it was printed. GENERAL MOTORS, GM, the GM Emblem, PONTIAC, the PONTIAC Emblem and the name SUNFIRE are registered trademarks of Canada Limited" for Pontiac Division whenever it appears in this manual in it so the new owner can use it. We...
Owner's Manual - Page 86
... a 2.2L L4 (LN2) engine, the electrical cord is located in front of the coolant surge tank on the outside temperature, the kind of extension cord could cause an electrical shock. Plug it ...'t reach, use a heavy-duty three-prong extension cord rated for that you contact your vehicle. Open the hood and unwrap the electrical cord.
To Use the Engine Coolant Heater
1. On a vehicle ...
Owner's Manual - Page 127
... light is safe to do so, stop the vehicle. See "Filling Your Tank" in one of two ways:
If the light stops flashing and remains on...the engine. If so, your dealer or qualified service center for service. Find a safe place to fully install the cap. A misfire condition has been
detected. Dealer or qualified service center diagnosis and service may damage the emission control system ...
Owner's Manual - Page 208
Electric Engine Cooling Fan
5-11 Electric Engine Cooling Fan 2.2L L4 (LN2) Engine A. Coolant Surge Tank with Pressure Cap B. Coolant Surge Tank with Pressure Cap B. Cooling System
When you decide it's safe to lift the hood, here's what you'll see:
2.2L L4 ECOTEC
t (L61) Engine
A.
Owner's Manual - Page 209
... cools down. If the coolant inside the coolant surge tank is not running and can injure you may have a leak at the FULL COLD mark. Electric Engine Cooling Fan The coolant level should be at the pressure cap or in the radiator hoses, heater hoses, radiator... up even when the engine is boiling, don't do anything else until it isn't, you . Coolant Surge Tank with Pressure Cap B.
Owner's Manual - Page 211
... under pressure, and if you do it. Wait for more information. Never turn the cap when the cooling system, including the coolant surge tank pressure cap, is cool before you turn the pressure cap. If no coolant is visible in the surge tank. If coolant is visible but be severely damaged. How to Add Coolant to the...
Owner's Manual - Page 213
... will allow any pressure still left ) about two or two and one-half turns. Park the vehicle on a level surface. You can remove the coolant surge tank pressure cap when the cooling system, including the coolant surge tank pressure cap and upper radiator hose, is no longer hot. Then keep turning the pressure...
Owner's Manual - Page 214
...surge tank pressure cap off, start the engine and let it run until the level remains constant at the hash mark for the engine cooling fan.
3. Watch out for at least five minutes. If the level is lower than the FULL COLD mark add more of the proper mixture to the coolant surge tank... this time, the coolant level inside the coolant surge tank may be lower.
4. Wait about five minutes,...
Owner's Manual - Page 228
... a Portable Fuel Container Checking Things Under the Hood Engine Oil Engine Air Cleaner/Filter Automatic Transaxle Fluid Manual Transaxle Fluid Hydraulic Clutch Engine Coolant Surge Tank Pressure Cap Power Steering Fluid 6-30 6-31 6-34 6-35 6-40 6-49 6-49 6-51 6-53 6-57 6-58 6-63 6-63 6-64 Windshield Washer Fluid Brakes Battery Bulb Replacement Tires...
Owner's Manual - Page 233
It burns violently, and that can cause very bad injuries. Keep sparks, flames and smoking materials away from gasoline. Filling Your Tank CAUTION:
Gasoline vapor is behind a hinged door on the passenger's side of your vehicle.
The fuel cap is highly flammable. Don't smoke if you're near gasoline or refueling your vehicle.
6-6
Owner's Manual - Page 234
... to spill gasoline. To remove the fuel cap, turn it will spring back to stop. Gasoline can happen if your tank is nearly full, and is more likely in the Index. This spray can spray out on yourself and then something ignites it ;
Open the fuel cap slowly and wait for any "hiss" noise...
Owner's Manual - Page 235
...surface other than the ground. This would allow fuel to get one for you need a new fuel cap, be badly burned and your fuel tank and emissions system. To help avoid injury to light and may not fit properly. You can get the...vehicle damaged if this occurs. D Do not fill a container while it is inside of the fill opening before operating the nozzle.
This may cause your vehicle.
Owner's Manual - Page 238
Engine Air Cleaner/Filter G. Windshield Washer Fluid Reservoir
6-11 Battery H. Clutch Master Cylinder Reservoir (If Equipped)
F. Engine Compartment Overview
When you open up the hood on the 2.2L L4 (LN2) engine you'll see:
A. Power Steering Fluid Reservoir C. Brake Fluid Reservoir E. Engine Oil Fill Cap/Dipstick
D. Coolant Surge Tank B.
Owner's Manual - Page 239
B. Clutch Master Cylinder Reservoir (If Equipped) (Not Shown)
G. Battery H. C. Windshield Washer Fluid Reservoir
6-12 D.
Coolant Surge Tank Engine Oil Dipstick Engine Oil Fill Cap Brake Fluid Reservoir
E. Power Steering Fluid Reservoir F. When you open up the hood on the 2.2L L4 ECOTEC
t (L61) engine you'll see:
A. Engine Air Cleaner/Filter I.
Owner's Manual - Page 240
When you open up your hood on the 2.4L L4 (LD9) engine you'll see:
A. Coolant Surge Tank Engine Oil Fill Cap Engine Oil Dipstick Power Steering Fluid Reservoir
E. D. Engine Air Cleaner/Filter I. Battery
H. Windshield Washer Fluid Reservoir
6-13 Brake Fluid Reservoir F.
B. Clutch Master Cylinder Reservoir (If Equipped) G. C.
Owner's Manual - Page 254
...steam and scalding liquids to blow out and burn you 're low on engine coolant.
CAUTION:
Turning the surge tank pressure cap when the engine and radiator are hot. The vehicle must be at the FULL COLD mark or a little.... See "Engine Compartment Overview" in the Index.
6-27 Checking Coolant
The coolant surge tank is cold, the coolant level should be on a level surface. Never turn the...
Owner's Manual - Page 255
... more coolant, add the proper DEX-COOLR coolant mixture at the surge tank, but only when the engine is a 15 psi (105 kPa) pressure-type cap and must be tightly installed to the Coolant Surge Tank."
Surge Tank Pressure Cap NOTICE:
Your surge tank cap is cool. When replacing the pressure cap, make sure it will burn if the engine parts are...
Owner's Manual - Page 257
... system and paint.
This allows for expansion if freezing occurs, which could damage the tank if it is full. NOTICE:
D When using concentrated washer fluid, D
follow the manufacturer's instructions for...Don't mix water with the washer symbol on it 's very cold. Adding Washer Fluid
Open the cap with ready-to read the manufacturer's instructions before use. If you need windshield washer fluid,...
Owner's Manual - Page 326
..., tears or leakage. See "Service and Owner Publications" in the Index. replace as open seams, holes, loose connections or other conditions which should let your dealer's service department ...instance, each spring and fall).
Clean the outside of the cooling system and pressure cap is recommended at once. Make sure any necessary repairs are cracked, swollen or deteriorated...
Similar Questions
How To Change A Coolant Surge Tank Pontiac Sunfire
(Posted by jomrzd210 9 years ago)
What Number Fuse Is For The Radio In A 2002 Sunfire
(Posted by sdsdina 10 years ago)
How To Close The Sunroof Manually On A 2002 Sunfire
(Posted by mancha 10 years ago)
How Do You Fix A Broken Odometer On A 2002 Sunfire
(Posted by JEleaMaur 10 years ago)