Husqvarna RZ5424 Support Question
Husqvarna RZ5424 Support Question
Find answers below for this question about Husqvarna RZ5424.Need a Husqvarna RZ5424 manual? We have 2 online manuals for this item!
Question posted by krismaksym on June 10th, 2021
Routing Diagram
Is there a drive belt routing diagram for rz5424
Current Answers
Answer #1: Posted by SonuKumar on June 10th, 2021 7:31 PM
SonuKumar
Member since:
May 9th, 2021 Points: 16,633,680
Member since:
May 9th, 2021 Points: 16,633,680
https://www.manualslib.com/manual/502617/Husqvarna-Rz5424.html
Please respond to my effort to provide you with the best possible solution by using the "Acceptable Solution" and/or the "Helpful" buttons when the answer has proven to be helpful.
Regards,
Sonu
Your search handyman for all e-support needs!!
Related Husqvarna RZ5424 Manual Pages
Owners Manual - Page 1
Operator Manual
RZ4621 / 966659101
RZ4621 CA / 966659201
RZ5424 / 966659301
RZ4222F / 966659401
RZ4621 BF / 966676501
RZ4623 / 966678201
RZ4824F / 966678301
RZ5424 / 966691901
Please read the operator's manual carefully and make sure you
understand the instructions before using the machine.
Owners Manual - Page 3
Contents
INTRODUCTION 5 Driving and Transport on Public Roads 5 Towing 5 Operating 5 Good Service 6
Symbols and Decals 7 Safety 9
Safety ...Safety System 37 Fuel Pump Air Filter 37 Tire Pressures 38 Parking Brake 38 V-belts 39
Deck Belt 39 Cutting Blades 40
Blade replacement 40 Adjusting the Mower Deck 41
Leveling deck 41 Anti-scalp Rollers 42 Caster Wheels 43 Cleaning 43...
Owners Manual - Page 5
... this operator's manual provides a Service Journal.
Make wide turns to the machine's normal driving direction. Do not tow on public roadways.
Never allow extra distance to improve our products... safety of the machine may cause loss of traction and loss of this machine.
Lawn mowers and all who are used improperly.
A control panel easily accessible to the new owner...
Owners Manual - Page 13
... fill containers inside a vehicle or on clothing, change clothing immediately.
• Never overfill fuel tank. If this is removed.
There is risk for the mower deck's drive belt is not possible, refuel such equipment with a portable container, rather than from the truck or trailer and refuel it on the ground away from the...
Owners Manual - Page 14
... repairs with the engine running the engine with manufacturer's recommended parts, when necessary.
• Mower blades are considered to cause cancer, birth defects, and other debris buildup. Allow machine to...all nuts and bolts tight to be sure the equipment is in good condition.
8011-515
Never drive the machine in an enclosed space
WARNING! Repair, if necessary, before storing.
• If ...
Owners Manual - Page 16
....
• Do not tow this machine, it may jackknife or overturn causing damage to the mower and possibly serious injury to transport the machine. If injured by the operator. If a spark ... infection or reaction can cause serious crushing injuries. WARNING! SAFETY
• Allow the machine to the drive system.
• Do not tow any trailers, etc. Be extra cautious when it should not be...
Owners Manual - Page 30
... the machine stands still. Do not drive up or down hills with slopes greater than 10 degrees. Engage the parking brake. Engage the mower deck by moving one control backward (behind...the unit. Set blade engagement and throttle control
Operating On Hills
Read the Safety Instructions "Driving on Slopes" in neutral position
IMPORTANT INFORMATION
Control levers return to the outside of the ...
Owners Manual - Page 31
... to side. Never drive the rider on top surface, engine and electrical components.
• When the mulching kit is used, it until the desired mowing result is important that can be raised into the soft lawn, clumps build, and the grass clippings fasten under the cowling.
• Hose the mower deck underside with...
Owners Manual - Page 33
... the deck into truck or trailer by hand.
To reengage the EZT's to be lifted by driving up and out of the frame, below the rear engine guard.
1.
operation
Manual Transport
When pushing or pulling the mower, engage the EZT (Integrated Zeroturn Transaxle) bypass linkages. DO NOT LIFT! The machine is not...
Owners Manual - Page 34
... Start the engine and blades, listen for unusual sounds Check for damage Thoroughly clean around the engine Clean around belts, belt pulleys Check the tire pressures
Before
After
Check battery connections
Sharpen3)/ Replace mower blades
Clean the engine's cooling air intake 2)
Clean the air cleaner's pre-filter 2) (foam)
Clean the air cleaner's filter...
Owners Manual - Page 35
... cable Check the condition of belts, belt pulleys Change the engine oil 1) Replace the engine oil filter Clean/replace the spark plugs Replace the fuel filter Replace air filter 2) (paper filter) Check the caster wheels (every 200 hours) Replace the air cleaner's pre-filter 2) (foam) Check/adjust the mower deck Check the engine...
Owners Manual - Page 37
...
MAINTENANCE
Safety System
The machine is equipped with a brush if necessary. Make daily inspections to drive, the driver must sit in the outer, locked neutral position.
3. Steering controls locked in neutral...attempting to be moved into the neutral position, otherwise the engine will stop. The mower deck is not engaged and the operator leaves the seated position. Change the conditions ...
Owners Manual - Page 39
Check for severe cracking and large nicks. Deck Belt 1. Remove bolts from wear.
Remove belt shields
Deck belt installation
NOTE: For ease in normal operation. Route the belt forward and up onto the deck.
3. Push inward on the idler arm and carefully route belt over the top of operation.
NOTE: The belt will show some small cracks in installing...
Owners Manual - Page 41
... a side-to ½" higher in a base measurement position. With a 5/8 or adjustable wrench, turn the lift link adjustment nuts on the discharge side of leveling procedure, mower deck drive belt must be properly adjusted. If tires are under Transmission.
If the front blade tip does not measure 1/8" to -side manner. 2.
MAINTENANCE
Adjusting the...
Owners Manual - Page 44
...it must be lubricated twice weekly.
Gasoline or other petroleum products must be used to clean belts.
44 When lubricating with grease, unless otherwise stated, use , the machine should be ...ignition key to clean them with spirits. If the belt continues to avoid getting lubricant on the belts or the drive surfaces on the belt pulleys. For daily use a high grade molybdenum disulphide...
Owners Manual - Page 45
... cutting deck completely. Lubricate with a grease gun, 2-3 strokes per spindle.
8058-068
Deck spindle
Transmission
The transmission is does not come into contact with belts or belt pulley drive surfaces. Lubricating the front wheels
IMPORTANT INFORMATION Use minimal lubrication and remove excess lubricant so that is maintenance free with no need for level...
Owners Manual - Page 47
... • Charging lead is disconnected • Parking brake on • Bypass valve on pump open • Drive belt for the transmission slack or
has come off • Air trapped in hydraulic system • Drive belt for the mower deck has come loose • Contact for the electromagnetic coupling has loosened • Blade switch is faulty...
Owners Manual - Page 54
...Speed reverse Brakes Front caster tires, smooth tread Rear tires, turf pneumatic Tire pressure
RZ5424 / 966691901
Kawasaki FR691V 24 hp 1,2) Pressure with oil filter Min 87 octane ... 0-5.6 km/h Mechanical parking brake
13 x 5.0-6, 4 ply 18 x 9.5-8
15 PSI / 103 kPa / 1 bar
RZ5424 / 966659301
Kohler SV720 24 hp 1,2) Pressure with oil filter Min 87 octane unleaded (Max ethanol 10%, Max MTBE 15%)...
Owners Manual - Page 55
... Base Machine Length Base Machine Height Base Machine Width Overall Width, Chute Up Overall Width, Chute Down
TECHNICAL DATA
RZ5424 / 966691901
54" / 137cm 1.5 - 4" / 3.8 - 10.2 cm
0 3 18¼" / 46...kg 75" / 191 cm 40" / 102 cm 43¾" / 112 cm 57" / 145 cm 67½" / 171 cm
RZ5424 / 966659301
54" / 137cm 1.5 - 4" / 3.8 - 10.2 cm
0 3 18¼" / 46.4 cm No Standard Standard Electromagnetic...
Owners Manual - Page 58
... fuel and open the fuel shut off valve Start the engine Check that there is drive to both wheels Check the mower deck adjustment Check:
The safety switch for the parking brake The safety switch for the mower deck The safety switch in the seat The safety switch in the steering controls Parking...
Similar Questions
What May Cause A Drive Belt To Come Off? What Would Make The Mower Backfire When
What may cause a drive belt to come off? What would also make the mower backfire when starting the m...
What may cause a drive belt to come off? What would also make the mower backfire when starting the m...
(Posted by dlseavey 1 year ago)
Drive Belt Tension
Is there a way to adjust the drive belt on a Husky 7022R? Even with a new belt the machine does not ...
Is there a way to adjust the drive belt on a Husky 7022R? Even with a new belt the machine does not ...
(Posted by basman19 2 years ago)
Rz5424 Husqvarna Running Issues
My zero turn starts and runs fine. The minute I release the brake it shuts off. I just replaced all ...
My zero turn starts and runs fine. The minute I release the brake it shuts off. I just replaced all ...
(Posted by Kevinhultgren 2 years ago)
After My Rz5424 Has Been For About An Hour, The Left Side Transaxel Get Sluggish
(Posted by dennisfulton1 3 years ago)
Husqvana Rz5424 Flat Pulley Replacement
The flat pulley on my zero turn falling off the Lawnmover I had ordered new one and installed but do...
The flat pulley on my zero turn falling off the Lawnmover I had ordered new one and installed but do...
(Posted by psonny9 4 years ago)