Weber Genesis 2 NG Support and Manuals
Get Help and Manuals for this Weber item
View All Support Options Below
Free Weber Genesis 2 NG manuals!
Problems with Weber Genesis 2 NG?
Ask a Question
Free Weber Genesis 2 NG manuals!
Problems with Weber Genesis 2 NG?
Ask a Question
Popular Weber Genesis 2 NG Manual Pages
Owner Manual - Page 1
... number in registering your fire department.
98629
12/97 GENESIS® 2000 Series
Natural Gas Barbecue
Owner's Manual
WE
BER
BER
WE
®
WARNING: Follow all leak check procedures carefully in the vicinity of this manual.
THIS GAS APPLIANCE IS DESIGNED FOR OUTDOOR USE ONLY.
NOTICE TO INSTALLER: These instructions must be left with the factory.
Shut off...
Owner Manual - Page 2
... rock in your Weber Gas Barbecue. ƽ Never lean over open grill or place hands or fingers on the front edge of the cooking box. ƽ Should a grease fire occur, turn all gas valves off all burners and leave lid closed until fire is not natural gas. Do not attempt to correct the problem yourself. 3. It will...
Owner Manual - Page 3
... CO. If you are limited in accordance with the sale, installation, use, removal, return, or replacement of parts which prove defective under normal use and service and which on Weber. Deterioration or damage due to severe weather conditions such as set out in connection with the printed instructions accompanying it any special, indirect or consequential damages. There...
Owner Manual - Page 6
... . If there are for assembling your Weber Gas Barbecue when the gas supply is being tested at the natural gas supply when the Weber Gas Barbecue is being tested at the pressure equal to be installed in use by closing its individual manual shutoff valve during any pressure testing of the grill.
s When the Weber Gas Barbecue is a portable outdoor cooking appliance...
Owner Manual - Page 7
... threads to our products, unfortunately an occasional error may occur. Hose Bottom tray Two work tables...manual and serial number of nuts, bolts and screws is missing, do not go back to receive immediate assistance. For example "1/4-20 x 2 inch bolt" means a bolt 1/4 inch in diameter with 32 threads to check for gas leaks. (See Step "Check for reference.
Call the Weber Customer Service...
Owner Manual - Page 12
...are misaligned. Put the washer on the bolt. Set the cooking box into the ends of the bolt...
Frame brace
Your Weber Gas Barbecue burner assembly has been factory assembled, pressure and flame tested.
Contact Weber-Stephen Customer Service. Figure 6. Do...are correctly aligned. Guide screw
Figure 6
Slide the cooking box to a, b and c, the burners are only guides. Tighten by holding...
Owner Manual - Page 14
... must be visible. Step 10
Install gas supply
General Specifications for building codes regulating outdoor gas barbecue installations. WE RECOMMEND THAT THIS INSTALLATION BE DONE BY A PROFESSIONAL....installed horizontally, or pointing downward.
s Pipe compound should be used which can be installed outdoors, immediately ahead of 18" cover.
Typical natural gas supply installation. Gas...
Owner Manual - Page 15
... do not turn they are off, proceed to manifold
You will need : one burner control knob.
(Valves are off
You will need : the 12 foot natural gas supply hose and a 3/4 inch wrench.
Check by pushing down and turning clockwise. Thread fitting end of hose onto manifold. Step 11
Check that all burner...
Owner Manual - Page 16
...Note - The burners have loosened or damaged a gas fitting.
ƽWARNING: Perform these leak checks even if your Weber Genesis Gas Barbecue.
Since some leaks test solutions, including ... disconnect connection. Contact Weber-Stephen Customer Service. As a safety precaution you should recheck all connections should be slightly corrosive, all fittings for gas leaks.
Gas will need: a ...
Owner Manual - Page 23
...Weber Gas Barbecue, make sure that the inside of storage and/or nonuse the Weber Gas Grill should also be checked for gas... or ventilation air.
Preheating
Your Weber Genesis Gas Barbecue is secured in your Flavorizer...Replace thermometer in lid when not in the catch pan under the control panel and the bottom tray are available through your Weber cookbook for detailed cooking instructions...
Owner Manual - Page 24
... only Weber authorized replacement hose. Check: a) Hose to manifold connections. Figure 3 (b). Order from Weber-Stephen Products Co., Customer Service Center or authorized dealer. If bubbles form or if a bubble grows there is a leak at connections (b) or (c), turn OFF the gas. Since some leak test solutions, including soap and water, may be slightly corrosive, all gas fittings...
Owner Manual - Page 27
... fit around the burners and valves. s Check to see Step "Install igniter" for gas leaks".)
Black wire
Figure 15
s Check that the Crossover Ignition button pushes the igniter (button) down, and returns to light, See Section "Manual Lighting", and contact Weber-Stephen Customer Service.
27 Slightly rotate the Spider Stopper Guards so that both the...
Owner Manual - Page 28
... be "peeling." (Resembles paint peeling.)
The lid is porcelain-on-steel, not paint.
TROUBLESHOOTING & MAINTENANCE
Problem
Check
Burners burn with a yellow or orange flame, in Inspect Weber Spider Stopper
conjunction with the smell of holes.)
Cure
Clean Weber Spider Stopper Guards. (See Section "Annual Maintenance".)
Burner does not light, or flame is low in...
Owner Manual - Page 31
... lock nut 53 Igniter wire (black) 54 Igniter wire (white) 55 Gas catcher ignition chamber 56 Hose 57 Control panel inserts (2)
ƽWARNING:
Use only Weber factory authorized parts. without first contacting the Customer Service Center by phone or mail. Note - Do not return parts to our products, unfortunately an occasional error may not be dangerous.
Owner Manual - Page 32
... also welcome
any problems with parts or assembly.
A FINAL WORD OF THANKS
Thank you
with any comments or suggestions you might have your owner's manual available for choosing a Weber Barbecue. While we give much attention to help you for reference.
Our knowledgeable Customer Service staff is prepared to our products, an occasional error may occur. We...
Weber Genesis 2 NG Reviews
We have not received any reviews for Weber yet.