Poulan PR5524ESNHL Support and Manuals
Get Help and Manuals for this Poulan item
This item is in your list!
View All Support Options Below
Free Poulan PR5524ESNHL manuals!
Problems with Poulan PR5524ESNHL?
Ask a Question
Free Poulan PR5524ESNHL manuals!
Problems with Poulan PR5524ESNHL?
Ask a Question
Popular Poulan PR5524ESNHL Manual Pages
User Manual - Page 2
... the controls and the proper use a nozzle lock-open device.
(g) Replace gasoline cap securely and wipe up , transporting, adjusting or making any repairs, adjustments or inspections. WARNING: Always disconnect spark plug wire and place it where it cannot contact plug in the manual(s) before starting motors.
6.
Read, understand and follow all doormats, sleds...
User Manual - Page 3
... a regular schedule in maintaining, caring for proper tightness to service or repair this unit. TABLE OF CONTENTS
SAFETY RULES 2-3
MAINTENANCE 13-14
PRODUCT SPECIFICATIONS 3
SERVICE AND ADJUSTMENTS 15-17
CUSTOMER RESPONSIBILITIES 3
STORAGE 17
ASSEMBLY / PRE-OPERATION 4-6
TROUBLESHOOTING 18
OPERATION 7-12
REPAIR PARTS 20-37
MAINTENANCE SCHEDULE 13 3 WARRANTY BACK COVER When...
User Manual - Page 4
...these instructions and this manual ...SET UP YOUR SNOW THROWER
TOOL BOX (See Fig. 8)
REMOVE SNOW THROWER FROM CARTON
A toolbox is
1.
Remove the two (2) plastic ties securing the upper handle to ensure proper tightness.
2.
Reading the entire manual will assist you assemble must be tightened securely. Remove all four corners of those parts left unassembled for additional loose parts...
User Manual - Page 11
...the skid plates. To avoid engine problems, the fuel system should be used ...manual. Never use extra caution and be picked up and thrown by loosening the hex nuts, then moving parts...be reversed, providing additional service before storage of 87 octane. See Storage Instructions for a few seconds,...located on your parts bag may be emptied before requiring replacement. BEFORE STARTING ...
User Manual - Page 13
...manual.
BEFORE EACH USE
1. NOTE: Use only Original Equipment Manufacturer (OEM) parts to be purchased from the warranty, operator must maintain snow thrower as instructed in the Service and Adjustments section of this manual...manual. NOTE: To seal tire punctures and prevent flat tires due to properly maintain your local parts dealer... should replace the spark plug and check belts...
User Manual - Page 14
... in the Service and Adjustments...Install left side wheel may be replaced by original equipment manufacturer (OEM) belts available from wear. (See "TO REMOVE BELT COVER" in a suitable container.
4. Refill engine with plug.
2. For approximate capacity see "PRODUCT SPECIFICATIONS" section of your snow thrower. Use gauge on dipstick.
10.
Clean the outside of this manual... gap setting are ...
User Manual - Page 15
...manual.
Should a foreign object or ice become lodged in contact with plug.
3. To replace the shear bolts:
1. Disengage all moving parts have completely stopped.
4. Remove safety ignition key and disconnect spark plug wire from the operator. Install...AUGER SHEAR BOLTS
Both right and left-hand augers are secured to any service or adjustments:
1. If one or both augers do not turn when ...
User Manual - Page 17
... fumes may reach an open flame, spark or pilot light as shown in fuel tank or storage container. ENGINE
See engine manual.
• Replace your gasoline can if your local parts dealer.
IMPORTANT: When installing wheel, be purchased from dust and dirt. KLIK PIN
OUTER HOLE
WHEEL
FIG. 22
INNER HOLE
WHEEL HUB
NOTE: To...
User Manual - Page 18
... to spark plug.
9. Prime as instructed in the Operation section of drive speed 3. Empty fuel tank & carburetor, refill with fresh, clean gasoline. 5. Loss of this manual. Remove ice and snow on and around fuel tank cap.
4.
Engine is in STOP position 5. Clean or replace muffler.
Contact an authorized service centre/department.
Turn fuel shut...
User Manual - Page 21
... 25 26 27 28 29 30 31 32 33 34 35 36
PART NO. inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. Failure to do so could be hazardous, damage your snow thrower and void your warranty.
21 REPAIR PARTS SNOW THROWER - - DESCRIPTION
175321X479 196710 188909 191079 175322 178675X008 192199 405400...
User Manual - Page 22
... NO.
1 2
PART NO.
420493X479 420494X479
DESCRIPTION
AUGER ASSEMBLY LH 24 AUGER ASSEMBLY RH 24
01.07.017-A
NOTE: All component dimensions given in U.S. inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. Failure to do so could be hazardous, damage your snow thrower and void your warranty.
22 REPAIR PARTS SNOW THROWER - -
User Manual - Page 25
.... 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. ITEMS INDICATED WITH AN * ARE LISTED AS REFERENCE FOR SERVICE PARTS ONLY. Failure to do so could be hazardous, damage your snow thrower and void your warranty.
25 NOTE: All component dimensions given in U.S.
MODEL NUMBER PR5524ESNHL (96192002700) CONTROL PANEL / CHUTE
2 2
*3
1 *6
KEY NO...
User Manual - Page 26
... 1.50
8
751153
NUT 5/16−18
9
155415
WASHER
01.08.003-A
1
KEY PART NO. DESCRIPTION
1
419797X479 LOWER TUBE
2
418313X479 PIVOT SUPPORT
3
150078
BOLT 5/16−18 X .750
2
4
17000616
SCREW 3/8−16 X 1.00
4
3
4
4
01.05.004-B
4
NOTE: All component dimensions given in U.S.
MODEL NUMBER PR5524ESNHL (96192002700) HANDLES
5
1
6
8
5 8
6
2 39
7
8 49
7
KEY NO...
User Manual - Page 37
....
37 PART NO.
181037 187899 181035 181042 187898 181033 415390 415391 415475 425353 425354
DESCRIPTION
DECAL, DANGER DECAL, POULAN PRO 5.5 HP/24" DECAL, DANGER, DEFLECTOR DECAL, DANGER DECAL, PRO DECAL, INSTRUCTION DECAL, AUGER LEVER RT DECAL, TRACT/CLUTCH LEVER LT DECAL, SPEED CONTROL OWNER'S MANUAL, ENGLISH OWNER'S MANUAL, FRENCH
NOTE: All component dimensions given in U.S.
MODEL NUMBER...
User Manual - Page 40
... defined in replacing parts, any product which vary from locale to locale. This is a limited Warranty within the meaning of original purchase.
4. Please refer to the following limitations and exclusions.
1. This Warranty gives you specific legal rights, and you have a claim under this warranty must return the product to an authorized service dealer. This Warranty...
Poulan PR5524ESNHL Reviews
Do you have an experience with the Poulan PR5524ESNHL that you would like to share?
Earn 750 points for your review!
We have not received any reviews for Poulan yet.
Earn 750 points for your review!