Poulan PR20PH42STD Support and Manuals
Get Help and Manuals for this Poulan item
View All Support Options Below
Free Poulan PR20PH42STD manuals!
Problems with Poulan PR20PH42STD?
Ask a Question
Free Poulan PR20PH42STD manuals!
Problems with Poulan PR20PH42STD?
Ask a Question
Popular Poulan PR20PH42STD Manual Pages
User Manual - Page 1
Always Wear Eye Protection During Operation
186914 Rev. 1 08.21.03 MH/TR Printed in serious injury. IMPORTANT MANUAL
Do Not Throw Away
02153
OWNER'S MANUAL
MODEL:
PR20PH42STD
LAWN TRACTOR
WARNING:
Read this Owner's Manual and follow all Warnings and Safety Instructions. Failure to do so can result in U.S.A.
User Manual - Page 4
... to give you to service or repair this manual). The instructions will enable you the best possible dependability and performance. TABLE OF CONTENTS
SAFETY RULES 2-3 PRODUCT SPECIFICATIONS 4 CUSTOMER RESPONSIBILITIES 4 ASSEMBLY 6-9 OPERATION 10-15 MAINTENANCE SCHEDULE 16
MAINTENANCE 16-19 SERVICE AND ADJUSTMENTS 20-23 STORAGE 24 TROUBLESHOOTING 25-26 REPAIR PARTS - CCA: Case Size...
User Manual - Page 6
... accessible loose parts and parts cartons from tractor hood and grill.
TOOLS REQUIRED FOR ASSEMBLY
A socket wrench set will make assembly easier. IMPORTANT: CHECK FOR AND REMOVE ANY STAPLES IN SKID THAT MAY PUNCTURE TIRES WHERE TRACTOR IS TO ROLL OFF SKID. Standard wrench sizes are in this manual for any additional loose parts or cartons and...
User Manual - Page 8
... "TO LEVEL MOWER HOUSING" in "PRODUCT
SPECIFICATIONS" section of this manual). CHECK BRAKE SYSTEM
After you learn how to operate your tractor, check to PSI shown in the Service and Adjustments section of this manual. Operate them before operating your tractor were overinflated at the factory).
✓ Be sure mower deck is properly adjusted. INSTALL MULCHER PLATE...
User Manual - Page 12
...push or tow tractor at the rear drawbar of this manual). • Remove...Replace retainer spring into the slot and release
so it is at level surface. • Adjust mower to desired cutting height (See "TO AD- JUST MOWER...mowers so equipped,or the deflector shield in the Operation section of tractor. • Raise attachment lift to slowest set- For healthier and better looking lawns...
User Manual - Page 14
...set .
• Disengage transmission by placing freewheel control in freewheeling position (See "TO TRANSPORT" in this manual...mower should be noticed. Mow north to the first cut relatively high; IMPORTANT: SHOULD YOUR TRANSMISSION REQUIRE REMOVAL FOR SERVICE OR REPLACEMENT, IT SHOULD BE PURGED AFTER REINSTALLATION BEFORE OPERATING THE TRACTOR.
• Place tractor...onto the lawn they will...
User Manual - Page 16
... and interlock systems are not. • Slide blade on your local parts dealer.
IF BOLT NEEDS REPLACING, REPLACE ONLY WITH APPROVE BOLT SHOWN IN THE REPAIR PARTS. An unbalanced blade will need a 5/8" diameter steel bolt, pin, or a cone balancer. (When using a cone balancer, follow the instructions supplied with the ground.
NOTE: To seal tire punctures and prevent...
User Manual - Page 18
... cause engine damage due to remove grass, leaves and trash from tractor and mower.
KNOBS
COVER
CARTRIDGE
FOAM PRE-CLEANER
MUFFLER
Inspect and replace corroded muffler and spark arrester (if equipped) as necessary. FIG. 16
18
Use compressed air or a leaf blower to overheating. Clean the foam pre-cleaner after every 100 hours...
User Manual - Page 19
... SERVICE OR ADJUSTMENTS:
• Depress clutch/brake pedal fully and set parking brake. • Place motion control lever in neutral (N) position. • Place attachment clutch in "DISENGAGED" position. • Turn ignition key to raise suspension arms. Slide mower
out from under tractor with deflector shield to right
side of this manual).
TO LEVEL MOWER...
User Manual - Page 20
...at front than the rear when the mower is in all pulley grooves and inside all
belt guides. • Install mower (See "To Install Mower" in this section of manual). • Work belt off both ...and adjusted.
SERVICE AND ADJUSTMENTS
NOTE: Each full turn of the transaxle.
To obtain the best cutting results, the mower housing should be replaced without tools. BELT INSTALLATION • ...
User Manual - Page 23
...NEVERTAMPER WITHTHE ENGINE GOVERNOR, WHICH IS FACTORY SET FOR PROPER ENGINE SPEED. TO REPLACE FUSE
Replace with 20 amp automotive-type plug-in the
Repair Parts section. If it is not, loosen...engine and lift off of tractor. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment.
Grasp ...
User Manual - Page 24
... thoroughly, remove all dirt, grease, leaves, etc. placement instructions in the Service and Adjustments section of this manual). • Inspect and replace belts, if necessary (See belt re- ENGINE
FUEL SYSTEM
IMPORTANT: IT IS IMPORTANT TO PREVENT GUM DEPOSITS FROM FORMING IN ESSENTIAL FUEL SYSTEM PARTS SUCH AS CARBURETOR, FUEL FILTER, FUEL HOSE, OR TANK...
User Manual - Page 26
...broken. 3. Engine throttle control not set at "SLOW" position for proper air pressure. 6. Replace motion drive belt. 3. Clogged mower deck vent holes from buildup of
...TROUBLESHOOTING POINTS
PROBLEM
CAUSE
Engine continues to run when operator leaves seat with blades listed in this manual. 11. Check wiring, switches and connections. Bent blade mandrel. 5. Replace blade mandrel. 5.
Mower...
User Manual - Page 43
... Brkt Asm Whl Ga. inches 1 inch = 25.4 mm
43 REPAIR PARTS
TRACTOR - MODEL NUMBER PR20PH42STD, PRODUCT NO. 954 56 78-33
MOWER DECK
KEY PART NO. R.LH
136 155986
Bar Adjusting Gauge Wheel
137 72110505 Bolt ...
Spring Ext.
ing, Shaft and Shaft Hardware Only
- Pulley Not Included)
- - 181542
Replacement Mower, Complete
(Std. LH
143 157109
Bracket Arm Idler 42"
144 173441
Keeper Belt 42"...
User Manual - Page 48
... the life of your local dealer(s).
Model Number/Manufacturer's I.D. For replacement parts, have available the following information:
a. If the operating characteristics or the appearance of your product differs from those described in this Manual, please contact your dealer/place of the nearest service dealer (under "saws" for
Chain Saws or under "lawn mowers" for the name of purchase...
Poulan PR20PH42STD Reviews
We have not received any reviews for Poulan yet.