Poulan PR208 Support and Manuals
Get Help and Manuals for this Poulan item
This item is in your list!
View All Support Options Below
Free Poulan PR208 manuals!
Problems with Poulan PR208?
Ask a Question
Free Poulan PR208 manuals!
Problems with Poulan PR208?
Ask a Question
Popular Poulan PR208 Manual Pages
User Manual - Page 1
Failure to do so can result in U.S.A.
IMPORTANT MANUAL
Do Not Throw Away
OWNER'S MANUAL
MODEL NUMBER:
PR208
SNOW THROWER
WARNING:
Read the Owner's Manual and follow all Warnings and Safety Instructions. Always Wear Eye Protection During Operation
421888 Rev. 1 08.29.08 AP Printed in serious injury.
User Manual - Page 2
...Know how to observe the following safety instructions could result in contact with electric drive motors or electric starting when setting up spilled fuel.
(h) If fuel is to make any repairs, adjustments or inspections. Disengage all persons, particularly small children.
4. Operation
1. Always place
restarting and operating the snow thrower. Avoid loose fitting clothing that may...
User Manual - Page 3
...OF CONTENTS
SAFETY RULES 2-3
MAINTENANCE 13-14
PRODUCT SPECIFICATIONS 3
SERVICE AND ADJUSTMENTS 15-17
CUSTOMER RESPONSIBILITIES 3
STORAGE 17
ASSEMBLY / PRE-OPERATION 4-7
TROUBLESHOOTING 18
OPERATION 7-12
REPAIR PARTS 20-37
MAINTENANCE SCHEDULE 13 3 WARRANTY BACK COVER 6. When cleaning, repairing or inspecting the snow thrower, stop the engine and make certain the...
User Manual - Page 4
...)
(2) LOCKNUTS 1/4-20
(73800400)
ASSEMBLY / PRE-OPERATION
Read these instructions and this manual in the toolbox. HOW TO SET UP YOUR SNOW THROWER
TOOL BOX (See Fig. 8)
REMOVE SNOW THROWER FROM CARTON
A toolbox is
1. Remove snow thrower from carton.
4
located on your snow thrower, all accessible loose parts and parts boxes from carton and check carton thoroughly for shipping...
User Manual - Page 11
...Instructions for a few seconds, remove and read oil level.
Tighten securely. Check engine oil with gasoline. WARNING: Wipe off engine and wait for all moving skid plate to bottom of 30 days or longer. To avoid engine problems, the fuel system should be used within 30 days to the edge of this manual.... Do not mix oil with snow thrower on your snow thrower has been shipped, from the ...
User Manual - Page 13
....
• Follow the maintenance schedule in this manual.
• At least once a year, you should replace the spark plug and check belts for loose fasteners.
3.
NOTE: Use only Original Equipment Manufacturer (OEM) parts to be purchased from the warranty, operator must maintain snow thrower as instructed in the Service and Adjustments section of injury to malfunction and...
User Manual - Page 14
... the "PRODUCT SPECIFICATIONS" section of this manual).
7. CAUTION: Any lubricating of the above 32°F. NOTE: Although multi-viscosity oils (5W30, 10W30 etc.) improve starting the engine and after each time you check the oil level.
Install left side wheel may be replaced by original equipment manufacturer (OEM) belts available from your snow thrower unless the...
User Manual - Page 15
...or distance snow is engaged, check to any service or adjustments:
1. SERVICE AND ADJUSTMENTS
...replace the capscrew/shear bolts:
15
FRAME
FIG. 19
SCREWS SNOW THROWER
TO ADJUST SNOW THROWER HEIGHT
See "TO ADJUST SKID PLATES" and "SCRAPER BAR" in auger shaft and install a new 1/4-20 x 2" shoulder/shear bolt and spacer. Disengage all moving parts have sheared. Wait for all moving parts...
User Manual - Page 17
...Cover your local parts dealer. system of oil through spark plug hole
into the outermost hole in axle only.
STORAGE
Immediately prepare your snow thrower to use the...problems, take your can damage the fuel
IMPORTANT: Never cover snow thrower while engine/ex-
Inspect and replace belts, if necessary (See "TO REPLACE BELTS" in the Service and Adjustments section of this manual...
User Manual - Page 18
... key.
3. Empty fuel tank & carburetor, refill with fresh, clean gasoline. 4. Replace damaged parts. drive / slowing 2. Check / reinstall drive belt. Auger belt is
disconnected. 9. Spark plug wire is worn. 3.
TROUBLESHOOTING
See appropriate section in manual unless directed to FAST position 5. PROBLEM
CAUSE
CORRECTION
Does not start
1. Safety ignition key is in the...
User Manual - Page 20
MODEL NUMBER PR208 (96192002101) AUGER HOUSING / IMPELLER ASSEMBLY
5
11 6
15 14 13
4
12
16
11
12 3 11
1 9
10 2
11 7
8
17
33 32
34...20 21 22 23
2 (EXPLODED)
NOTE: All component dimensions given in U.S. inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. REPAIR PARTS SNOW THROWER - - Failure to do so could be hazardous, damage your...
User Manual - Page 21
MODEL NUMBER PR208 (96192002101) AUGER HOUSING / IMPELLER ASSEMBLY
KEY NO.
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36
PART NO. REPAIR PARTS SNOW THROWER... do so could be hazardous, damage your snow thrower and void your warranty.
21 inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts.
User Manual - Page 25
REPAIR PARTS SNOW THROWER - - NOTE: All component dimensions given in U.S.
MODEL NUMBER PR208 (96192002101) CONTROL PANEL / CHUTE
2
2 *3
1 *6
KEY NO.
1 2 *3 *4 *5 *6
PART...FOR SERVICE PARTS ONLY. Failure to do so could be hazardous, damage your snow thrower and void your warranty.
25 inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts....
User Manual - Page 26
.... DESCRIPTION
1
419797X479 LOWER HANDLE
2
405784X479 PIVOT SUPPORT WELDMENT
3
150078
SCREW 5/16−18 X .750
4
17000616
SCREW 3/8−16 X 1.00
2
4
3
4
4
01.05.002-B
NOTE: All component dimensions given in U.S. MODEL NUMBER PR208 (96192002101) HANDLES
5
1
6
8
2
5 8
6
39 7
8 49
7 KEY PART NO. NO. REPAIR PARTS SNOW THROWER - - DESCRIPTION
1
419800X479 PLOW HANDLE LH...
User Manual - Page 37
..., POULAN DECAL, INSTRUCTION DECAL, SPEED CONTROL DECAL, LH TRIGGER DECAL, RH TRIGGER OWNER'S MANUAL, ENGLISH OWNER'S MANUAL, FRENCH
NOTE: All component dimensions given in U.S.
MODEL NUMBER PR208 (96192002101)
DECALS
1
2
4
9
12
6
1
3
5
11
KEY NO.
1 2 3 4 5 6 9 11 12 - - - Failure to do so could be hazardous, damage your snow thrower and void your warranty.
37 REPAIR PARTS SNOW...
Poulan PR208 Reviews
Do you have an experience with the Poulan PR208 that you would like to share?
Earn 750 points for your review!
We have not received any reviews for Poulan yet.
Earn 750 points for your review!