Poulan HDR500L Support and Manuals
Get Help and Manuals for this Poulan item
View All Support Options Below
Free Poulan HDR500L manuals!
Problems with Poulan HDR500L?
Ask a Question
Free Poulan HDR500L manuals!
Problems with Poulan HDR500L?
Ask a Question
Popular Poulan HDR500L Manual Pages
User Manual - Page 1
HDR500L. 5 HP 17 Inch Tiller
• Assembly • Operation • Maintenance • Service and Adjustments • Storage • Troubleshooting • Repair Parts
For Parts and Service, contact our authorized distributor: call 1-800-849-1297 For Technical Assistance: call 1-800-829-5886
n
184877 Rev. 1 02.21.03 TR PRINTED IN U.S.A. FILE COPY
4t,
OWNER'S MANUAL
MODEL NO.
User Manual - Page 2
...guide instructions...set...Replace gasoline cap securely and clean up , transporting, adjusting or making repairs.
A WARNING
The engine exhaust from the spark plug, thoroughly inspect the tiller for any adjustments while the engine (motor) is generally a warning of trouble.
• Stop the engine (motor) when leaving the operating position.
• Take all moving parts...MANUAL...where specifically ...
User Manual - Page 3
... instructions under"Maintenance" and "Storage" sections of a new tiller. Should you experience any ). We have similar laws. Please read and retain this manual for spark arrester. TABLE OF CONTENTS
SAFETY RULES CUSTOMER RESPONSIBILITIES PRODUCT SPECIFICATIONS ASSEMBLY OPERATION MAINTENANCE SCHEDULE
2
MAINTENANCE
3
SERVICE & ADJUSTMENTS
3 STORAGE
4-6 TROUBLESHOOTING
7-11 REPAIR PARTS...
User Manual - Page 6
... "TO ADJUST HANDLE HEIGHT" in "N" position (See Fig. 7)
• Tilt tiller forward by lifting handle.
Correct and equal tire pressure is in the Service and Adjustments section of this manual).
6
SHIFT ROD
HAIRPIN CLIP
SHIFT LEVER INDICATOR
0
CONTROL BAR BRACKET
il
CLUTCH CABLE
FIG. 6
ALN
/
2°
CONTROL BAR
FIG. 7
REMOVE TILLER FROM...
User Manual - Page 9
...manual.
• Lift handle to raise tines out of the outer side shields are empty. See Storage Instructions...avoid engine problems, the fuel system should be to point of this manual.
Loosen ...oil should change engine oil, see "PRODUCT SPECIFICATIONS" on page 3 of overflowing when engine...; The engine in slot and nut "8". Service Classification SF-SJ.
9 OPERATION
TURNING
Release the...
User Manual - Page 10
...but does not start of your tiller. See "TO ADJUST CARBURETOR" in the Service and Adjustments section of this manual. A tiller will also clear the soil of sod or hard ground, apply ...ENGINE (See Fig. 13)
A
CAUTION: Keep drive control bar in "DISENGAGED" position when start , see troubleshooting points. Pull rope out slowly until engine reaches start , move choke control to 6" (10-15 cm)....
User Manual - Page 12
MAINTENANCE
MAINTENANCE SCHEDULE
FILL IN DATES AS YOU COMPLETE REGULAR SERVICE
4O . A..
.a co
co
Qd
OJQho
OJ O, o co
.14,o -1.cii .-',..
User Manual - Page 13
.... Check the crankcase oil level before starting the engine and after every 25 hours of this manual. Service air cleaner more freely when warm. • Use a funnel to prevent oil spill on ... these multi-viscosity oils will result in a clean cloth. • If very dirty or damaged, replace pre-cleaner. • Reinstall pre-cleaner into air cleaner cover. • Reinstall cover and secure ...
User Manual - Page 15
... SERVICE AND ADJUSTMENTS
A
CAUTION: Disconnect spark plug wire from wheel. • Remove wheel and tire. • Repair ...tire and reassemble. HANDLE (LOW POSITION)
0
FIG. 22
CLEVIS PIN
0
•
HAIRPIN CLIP
FIG. 23
15 HANDLE (HIGH POSITION)
HANDLE LOCK LEVER
TIRE CARE
CAUTION: When mounting tires, unless beads are not equal, tiller will be positioned at different settings...
User Manual - Page 18
... , no further adjustment is necessary. If the carburetor does need adjustment, contact your nearest authorized service center/department
IMPORTANT: NEVERTAMPERWITHTHEENGINEGOVERNOR, WHICH IS FACTORY SET FOR PROPER ENGINE SPEED. OVERSPEEDING THE ENGINE ABOVE THE FACTORY HIGH SPEED SETTING CAN BE DANGEROUS. TO ADJUST CARBURETOR
The carburetor has been preset at the factory and adjustment...
User Manual - Page 19
...; Inspect and replace belts, if necessary (See belt replacement instructions in the Service and Adjustments section of this manual).
• Lubricate as shown in the Maintenance section of this manual). sand lightly before painting. ENGINE
FUEL SYSTEM
IMPORTANT: IT IS IMPORTANT TO PREVENT GUM DEPOSITS FROM FORMING IN ESSENTIAL FUEL SYSTEM PARTS SUCH AS THE CARBURETOR, FUEL FILTER, FUEL...
User Manual - Page 20
... fuel tank and clean. 9. Clean cylinder fins, air screen. Check throttle control setting. 3. Dirty air cleaner. 3. Loose spark plug wire.
6. Tines jammed. Make necessary adjustments. 13. Replace spark plug or adjust gap. 9. Make necessary adjustments.
1. Water in fuel.
8. V-belt not correctly adjusted. 3. Carburetor out of power
Engine overheats
Excessive bounce/ difficult handling...
User Manual - Page 22
...Arm
33 74760616 Bolt, Hex 3/8-16 x 1
34 102383X Counterweight, L. inches. 1 inch = 25.4 mm
22 MODEL NUMBER HDR500L
MAINFRAME, LEFT SIDE
3
•t3(
.. DESCRIPTION
1 73510500 Nut, Keps 5/16-18
2 10040600 Washer, Lock 3/8
3 73220600 Nut, Hex 3/8-16
4 170127
Shield, Inner, Belt Guard
5 164329
Pin Spiro! Flared
6 110111X Lever, Shift
7 72110404 Bolt, Carriage 1/4-20 x 1/2 Gr. 5
8 8700J...
User Manual - Page 27
... 9 141906 10 156199 11 171078 12 162215 - - 184877
184878
DESCRIPTION
Decal, Logo Decal, Description Decal, Logo Decal, Instruction, Tilling Decal, Hand Placement Decal, Shift Indicator Decal, Briggs & Stratton Decal, OHV N-I/C Decal, Warning, Rotating Tines Deal, Reverse Decal, Rewind INTEK Decal, Tine Shield Wrng Dom Manual, Owner's (English) Manual, Owner's (Spanish) REPAIR PARTS
TILLER - -
User Manual - Page 28
... in replacing parts, any parts submitted for any part which we will repair or replace, at our option, without charge for the movement of any product which have a claim under this warranty must return the product to any power equipment unit or attachment are belts, tines, tine adapters, normal wear, normal adjustments, standard hardware and normal maintenance. 6. Poulan...
Poulan HDR500L Reviews
We have not received any reviews for Poulan yet.