Makita MAC700 Support and Manuals
Get Help and Manuals for this Makita item
View All Support Options Below
Free Makita MAC700 manuals!
Problems with Makita MAC700?
Ask a Question
Free Makita MAC700 manuals!
Problems with Makita MAC700?
Ask a Question
Makita MAC700 Videos
Makita MAC700 Air Compressor
Duration: :33
Total Views: 845
Duration: :33
Total Views: 845
Makita MAC700 compressor "break in"
Duration: 7:51
Total Views: 48,104
Duration: 7:51
Total Views: 48,104
Makita MAC700 Big Bore 2.0 HP Air Compressor.wmv
Duration: :57
Total Views: 6,142
Duration: :57
Total Views: 6,142
Makita MAC700 Compressor Setup
Duration: 11:10
Total Views: 9,032
Duration: 11:10
Total Views: 9,032
Popular Makita MAC700 Manual Pages
Owners Manual - Page 1
... and ALL instructions carefully before operating. If the air compressor is preferred.
www.makitatools.com OWNERS MANUAL FOR
Oil Lubricated Air Compressor
MODEL No MAC700
SPECIFICATION CHART
Model # Horsepower SCFM @ 40 PSIG SCFM @ 90 PSIG Cut-In Pressure Cut-Out Pressure Bore Stroke Voltage -Single Phase Motor RPM Amperage @ max pressure Tank Size CSA/US Listed
MAC700 2 3.8 3.3
100 PSI...
Owners Manual - Page 2
...8 INSTALLATION and BREAK-IN PROCEDURES 9
Location Of the Air Compressor 9 Lubrication and Oil 9 Initial Start Up Procedure 10 Extension Cords 10 Piping 10 Grounding Instruction 10 OPERATING PROCEDURES 11 Daily Start-up Checklist 11 MAINTENANCE 12 Filling with Oil 12 Changing the Oil 12 ROUTINE MAINTENANCE SCHEDULE 12 COLD WEATHER CONDITIONS 12 SERVICE INSTRUCTIONS 13 TROUBLESHOOTING...
Owners Manual - Page 7
... your accessory or air tool.
DUTY CYCLE
All Makita manufactured air compressors are recommended to use your air compressor, it will restart automatically re-started is called "cut -out pressure". When the tank pressure drops to the shipping container. The pressure at which combine the functions of damage to a certain level the motor will give you long, trouble-free...
Owners Manual - Page 8
... unit to drain water from the compressor head and the outlet tube when the air compressor This filter must always be left unattended. PRESSURE SWITCH UNLOADING VALVE: The pressure switch unloading valve located on or run over).
product was shipped directly to you do the following: 1. Protect the electrical cord and air hose from obstructions.
Review the...
Owners Manual - Page 9
... a change in the tank. Depending on a level surface, please fill the crankcase to decrease pressure.
The air filter must be adjusted while you are operating the accessory. Follow the instructions packaged with oil and broken in correctly.
The air compressor should be installed on the sight glass.
See "Operating Procedures". INSTALLATION AND
BREAK-IN
PROCEDURES
LOCATION OF THE AIR...
Owners Manual - Page 10
... the air receiver's drain
valve. 2.Plug power supply cord into
correct power source. 3.Run the compressor for a
minimum of twenty (20) minutes in good condition. Your compressor is the same size, or larger than, the air tank outlet. Grounding Instruction WARNING: Risk of its indicated pressure rating, plastic pipe can burst from air pressure. Use air compressor oil only. Regardless...
Owners Manual - Page 11
... Start-up Checklist 1. Before attaching air hose or
accessories, make sure the pressure switch lever is closed. 2. The regulator outlet pressure must have the same configuration as the plug. Using the air tool or
accessory, bleed the tank pressure down to "OFF" and the air regulator or shut-off valve is set to zero. 8. Drain water from air tank by a qualified...
Owners Manual - Page 12
... followed. WHEN DOING MAINTENANCE, YOU MAY BE EXPOSED TO VOLTAGE SOURCES, COMPRESSED AIR OR MOVING PARTS. BEFORE PERFORMING ANY MAINTENANCE OR REPAIR, UNPLUG THE COMPRESSOR AND BLEED OFF ALL AIR PRESSURE. The following routine maintenance schedule is geared to make sure they are operating properly.
4. Check for leaks; Manually check all maintenance checks. Inspect air filter...
Owners Manual - Page 13
.... Units with the recommended oil to the proper level. Remove shroud. 3. Replace the outlet tube and tighten top and bottom nuts. 10.
Allow oil to drain completely. 2.Replace the oil drain plug (The
use the compressor, check the air filter to operate at all air pressure from
air tank and unplug outfit. 2. SERVICE
INSTRUCTIONS
Air Filter - Inspection and Replacement: • Keep the air...
Owners Manual - Page 14
... unit doesn't shut off, unplug.
Remove and clean or replace check valve.
If the electrical contacts are welded together, replace the pressure switch.
• If the contacts are
fittings.
Contact a trained service technician.
TROUBLESHOOTING GUIDE
PERFORMING REPAIRS MAY EXPOSE VOLTAGE SOURCES, MOVING PARTS OR COMPRESSED AIR SOURCES. PERSONAL INJURY MAY OCCUR. Tighten...
Owners Manual - Page 15
...If it should be replaced.
enough air to occur. Page 15 CORRECTION
If there is an excessive amount of troubleshooting guide). Note:Adjust the regulated pressure under flow conditions (while accessory is used .
Compressor • Prolonged
is used , adjust the regulator following the instructions. If valve still leaks, it is normal for "some" pressure drop to operate...
Owners Manual - Page 17
... (prepaid) to one of the Makita Factory Service Centers listed, or to the outside of the carton detailing the problem with your tool. Page 17 Louis, MO 63126 (314) 909-9889
NEBRASKA
4129 S. 84th Street Omaha, NE 68127 (402) 597-2925
NEVADA
3375 S.
Date Purchased Dealer's Name and Address
Model No. Portland, OR 97209...
Owners Manual - Page 18
... exclusion or limitation of these chemicals: work in a well ventilated area, and work . WARNING
Some dust created by defective workmanship or material, Makita will repair, (or at our option, replace), without charge. Some examples of incidental or consequential damages, so the above limitation may not apply to these chemicals are: • lead from...
Owners Manual - Page 19
...SERIAL NO. LAST NAME/COMPANY NAME
MODEL NO. STATUS Married Single
SEX M F
STREET ADDRESS CITY
STATE
ZIP CODE
PHONE
AREA CODE
AGE: Under 19
20-29
30...
3. MAIL THIS PORTION
Your answers to the following questions are :
Design
Repair Service
Features
Durability
Size
Power
Price
Other (
)
Makita Brand
DATE PURCHASED
MONTH
DAY
YEAR
INTL. How did you learn about this...
Parts Breakdown - Page 1
... Piston pin snap ring Cylinder to crankcase gasket Set nut (cylinder to crankcase) Spring washer (cyl to crankcase) Double head screw Crankcase cover gasket Crankshaft Crankcase cover Connecting rod Oil sight gauge Oil draining plug Motor cover Motor / crankcase cover bolt Air filter assembly Oil filler/crankcase breather
Makita Air Compressor Part Breakdown - Model MAC700
PB-MKTA-072605
www...
Makita MAC700 Reviews
We have not received any reviews for Makita yet.