LG LW5200ER Support and Manuals
Most Recent LG LW5200ER Questions
How Do I Set Up The Timer For This ?
i am trying to fiqure out how to use the timer
i am trying to fiqure out how to use the timer
(Posted by illstr8slapyuh 11 years ago)
Popular LG LW5200ER Manual Pages
Service Manual - Page 1
website http://www.lgservice.com
LG
LG Room
Air Conditioner
SERVICE MANUAL
MODEL: ACQ058PL KG5200ER LW5200ER WG5200ER WG6000R KG6000R M5404R WG5200R M6004R HBLG6000R HBLG5200E ACQ052PK
LW7000R WM-5031 LW050CE LWJ0515PAG LW5200R
CAUTION
• BEFORE SERVICING THE UNIT, READ THE SAFETY PRECAUTIONS IN THIS MANUAL.
• ONLY FOR AUTHORIZED SERVICE PERSONNEL.
Service Manual - Page 3
... to be over 1 MΩ.
-3- This room air conditioner was manufactured and assembled under a strict quality control system. The grounding conductor (green or green and yellow) is found, replace all Mode [except POWER OFF].
4. PREFACE
This service manual provides various service information, including the mechanical and electrical parts, etc. Measure the resistance value with an ohm...
Service Manual - Page 4
...7Hours 8Hours 9Hours 10Hours 11Hours 12Hours
Cancel)
POWER
• To turn on and check the room air to determine if cooling is set within a range of the room. later and by 2°F(1°C) after another 30 min.
.... • When you push this button, when the unit is operating, timer is on , the unit is set as follows. {High(F2) Low(F1) High(F2)...} or {High(F3) Mid(F2) Low(F1) High(...
Service Manual - Page 5
... sure that the (+) and (-) directions are correct.
• Be sure that both batteries are new.
3. Remove the cover from the remote controller if the air conditioner is set as follow. (1Hour 2Hours 3Hours 4Hours 5Hours 6Hours 7Hours 8Hours 9Hours 10Hours 11Hours 12Hours
Cancel)
ENERGY SAVER
The fan stops when the compressor stops cooling...
Service Manual - Page 6
...base pan and air guide. (See Figure 4) 5.
Re-install components by placing the tabs in this manual or inside ...install by referring to the procedures above . (Refer to procedures above .
2.1.3 CONTROL BOARD
1. NOTE : Controls, wires, and capacitor are now accessible for procedures.
6. Discharge the capacitor before servicing.
DISASSEMBLY INSTRUCTIONS
2.1 MECHANICAL PARTS...
Service Manual - Page 11
... interconnecting tube of the refrigeration cycle.
1. When replacing the refrigerating cycle, be closed and left in
figure 20A. 6-2. Solder service valves into the vacuum pump.
6-3. Start the vacuum.... 3. Remove the air guide upper. (Refer to the lowside. After completing the above . The vacuum pump is now pulling through the access valve which is installed as the system is...
Service Manual - Page 13
... secured to raise the height of the air conditioner. INSTALLATION
This air conditioner is installed securely and firmly.
2. To prevent vibration...AIR
OUTSIDE AWNING
FENCE
HEAT RADIATION
30"-60"
Figure 21
ABOUT
/ 1 4
"
Over 20"
3.2 HOW TO INSTALL
3.2.1 WINDOW REQUIREMENTS
INNER SILL
NOTE: All supporting parts should be thick enough to firm
wood, masonry, or metal.
1.
Install...
Service Manual - Page 14
... of the L bracket. INSTALL THE AIR CONDITIONER IN THE WINDOW a.
Installation Kit (Some models)
HARDWARE
TYPE A: 11EA (SHORT SCREW)
TYPE B: 5EA (WOOD SCREW)
TYPE C: 3EA (L BACKET)
DRAIN PIPE
10mm 16mm
TYPE D: 1EA (SEAL STRIP)
(Adhesive backed)
TYPE E: 1EA (SASH SEAL)
(Not adhesive backed)
TYPE F: 2EA (GUIDE PANEL)
TYPE G: 1EA (SUPPORT BACKET)
3.2.2 BEFORE INSTALLATION
1. The bracket...
Service Manual - Page 15
... 31
Support Bracket (TYPE G)
1 hang
2 push
3.2.4 HOW TO SECURE THE DRAIN PIPE
In humid weather, excess water may cause the BASE PAN to secure them, as shown in Figure. 30.
6.
b. SECURE THE GUIDE PANELS Extend the guide panels (TYPE F) to fill the window opening as shown in Figure. 29.
4. Window installation of the air conditioner, as...
Service Manual - Page 16
... installed through the top and bottom of potential safety hazards, we strongly discourage the use a CSA certified/UL-listed 3-wire (grounding) extension cord, rated 15A, 125V.
4.
Keeping a firm grip on the air conditioner, raise the sash, and carefully tilt the air conditioner backward, draining any circumstances cut or remove the grounding prong from the plug. TROUBLESHOOTING GUIDE...
Service Manual - Page 18
...caused by a defect in two kinds.
Check clogging in refrigeration circuit. 4.3 TROUBLESHOOTING GUIDE
In general, possible trouble is classified in the refrigeration circuit and improper application. Adjust refrigerant charge. Replacement of compressor.
Dirty indoor coil (heat exchanger)
Malfunction of inlet & outlet air; 44~50°F (7~10°C)
-18- Check gas leakage.
Obstruction...
Service Manual - Page 21
....
-21-
• Exchange IC01M. • Exchange IC01M. YES
• Wait 3 Minutes
• Exchange MAIN P.W.B Ass'y.
Possible Trouble 2
• The compressor does not operate.
YES • Exchange IC01M.
setting set lower than Room
NO
Temp.-0.5°C?
• Set the Temp. YES
• Check the RY-COMP. • Check the wiring
Diagram. YES
• Check the...
Service Manual - Page 24
...; Check the continuity of balance, or partially missing, replace it .
if loose, repair or replace the terminal. Check the capacitor. Check the compressor for identification, and replace the wires.
If not at the lowest number, set screw Worn bearings
Compressor will not run, fan motor runs. Replace if not within these limits, call an electrician. Check...
Service Manual - Page 25
... the condenser fins are closed over a large area on overload
CAUSE Fan motor
Condenser air flow restriction
Insufficient cooling. Determine if the unit is hitting scroll or barrier, rearrange the air handling parts. Replace if required. If loose, repair or replace. Check the set screw, or clamp. If loose or missing, correct.
If restricted, clean carefully with...
Service Manual - Page 27
5.2 ELECTRONIC CONTROL DEVICE
-27- ROOM-TH 1 2 3 ...WOR
C01J 0.1/275V
R01J 120 1/2W
R02E 20
R01E 1K
ZNR01J SVC271D-14A
RY-COMP G4A-1A-E-LG
FUSE 250V/T2A
POWER TRANS
1
7
D02D
D05D
2
D03D 4
D04D + C01D
D02D~D05D
1000...5 4 12
TEMP UP
SW7
D07F
ENERGY SAVER
SW3 D03F 5V
11
A/SWING
10
A/RESTART
9
8
7
AIR PURIFIER
6
3 2
CN-DISP
TEMP DOWN SW5
D05F TIMER
SW2 D02F
COOL DEFROST DRY/HEAT
TIMER FAN
...
LG LW5200ER Reviews
Do you have an experience with the LG LW5200ER that you would like to share?
Earn 750 points for your review!
We have not received any reviews for LG yet.
Earn 750 points for your review!