Owners Manual
Page 2
... stances may not cover damage or liability caused by any nonroad engine repair establishment or individual. authorized accessories or replacement parts. The Emissions Compliance Period referred to on the Emissions Compliance label indicates the number of operating hours for future servicing of..., brushcutter or trimmer can be performed by the use of non- CONTENTS Contents CONTENTS Contents 2 Note the following before starting : Husqvarna AB has a policy of continuous product development and therefore reserves the right to modify the design and appearance of products without the ...
... stances may not cover damage or liability caused by any nonroad engine repair establishment or individual. authorized accessories or replacement parts. The Emissions Compliance Period referred to on the Emissions Compliance label indicates the number of operating hours for future servicing of..., brushcutter or trimmer can be performed by the use of non- CONTENTS Contents CONTENTS Contents 2 Note the following before starting : Husqvarna AB has a policy of continuous product development and therefore reserves the right to modify the design and appearance of products without the ...
Owners Manual
Page 8
.... tachment may increase the risk of spinning line. S Persons with both hands. Remove any other equipment described in moving parts. Check all parts of 50 feet (15 meters). SAFETY INSTRUCTIONS General safety precautions IMPORTANT! See instructions in daylight or good artificial light. ing... with this engine unit are not damaged. Replace damaged parts. S The machine is mounted and not damaged. 545196750 Rev. 3 2/17/09 English--- 8 S Never use a machine that all parts of your body. Carry out the checks, maintenance and service instructions...
.... tachment may increase the risk of spinning line. S Persons with both hands. Remove any other equipment described in moving parts. Check all parts of 50 feet (15 meters). SAFETY INSTRUCTIONS General safety precautions IMPORTANT! See instructions in daylight or good artificial light. ing... with this engine unit are not damaged. Replace damaged parts. S The machine is mounted and not damaged. 545196750 Rev. 3 2/17/09 English--- 8 S Never use a machine that all parts of your body. Carry out the checks, maintenance and service instructions...
Owners Manual
Page 9
... Store and transport the machine and fuel so that there is started . Basic safety rules 1. Starting WARNING: When the engine is no risk of any part of fire, explosion and inhaling fumes. S When storing the machine for complete instructions. S Ensure the machine is cleaned and that a complete service is...all of the engine covers and housings are properly fitted before the unit is no one is carried out before use a machine that has parts missing or has been changed in either the choke or start throttle positions the cutting attachment will start or attempt to evaporate. S To ...
... Store and transport the machine and fuel so that there is started . Basic safety rules 1. Starting WARNING: When the engine is no risk of any part of fire, explosion and inhaling fumes. S When storing the machine for complete instructions. S Ensure the machine is cleaned and that a complete service is...all of the engine covers and housings are properly fitted before the unit is no one is carried out before use a machine that has parts missing or has been changed in either the choke or start throttle positions the cutting attachment will start or attempt to evaporate. S To ...
Owners Manual
Page 15
... 3 2/17/09 English--- 15 S Check that the trimmer head and trimmer guard are in the working area, otherwise there is started, otherwise parts could come into contact with your left hand (CAUTION! Not with any object. Firmly grip the starter rope handle with a defective guard. gine...and shaft must be completely filled. STARTING AND STOPPING Check before starting . The primer bulb need not be fitted before each use. Replace damaged parts. Never use the machine without a guard nor with your hand. S Never use , for fuel leaks. Slowly pull out the cord until ...
... 3 2/17/09 English--- 15 S Check that the trimmer head and trimmer guard are in the working area, otherwise there is started, otherwise parts could come into contact with your left hand (CAUTION! Not with any object. Firmly grip the starter rope handle with a defective guard. gine...and shaft must be completely filled. STARTING AND STOPPING Check before starting . The primer bulb need not be fitted before each use. Replace damaged parts. Never use the machine without a guard nor with your hand. S Never use , for fuel leaks. Slowly pull out the cord until ...
Owners Manual
Page 16
...Wear your carburetor. When the unit is turned off, make sure the cutting attachments has stopped before the machine is started , otherwise parts could result in serious engine damage or in the carburetor. idle speed: See "Technical data" section. WARNING: Improper mainte- justed ...cutting attachment stops. Air and fuel are ad- Basic setting S The basic carburetor settings are mixed in serious injury. Carburetor Your Husqvarna product has been designed and manufactured to rotate immediately. Function S The carburetor governs the engine's speed via the throttle control. turning...
...Wear your carburetor. When the unit is turned off, make sure the cutting attachments has stopped before the machine is started , otherwise parts could result in serious engine damage or in the carburetor. idle speed: See "Technical data" section. WARNING: Improper mainte- justed ...cutting attachment stops. Air and fuel are ad- Basic setting S The basic carburetor settings are mixed in serious injury. Carburetor Your Husqvarna product has been designed and manufactured to rotate immediately. Function S The carburetor governs the engine's speed via the throttle control. turning...
Owners Manual
Page 18
... not rotate when the engine is filled three--quarters full with grease up to engine parts S Excessive fuel consumption Clean the filter every 25 hours, or more regularly if conditions... must therefore be regularly cleaned to remove dust and dirt in warm, soapy water. Bevel gear (128L) The bevel gear is not damaged. S Check that hold the bevel gear are tight. S... that the stop switch works correctly. S Clean the air filter. S Check electrical wires and connections. Use HUSQVARNA special grease. S Check that the harness is filled with a new one at the factory. S Replace the...
... not rotate when the engine is filled three--quarters full with grease up to engine parts S Excessive fuel consumption Clean the filter every 25 hours, or more regularly if conditions... must therefore be regularly cleaned to remove dust and dirt in warm, soapy water. Bevel gear (128L) The bevel gear is not damaged. S Check that hold the bevel gear are tight. S... that the stop switch works correctly. S Clean the air filter. S Check electrical wires and connections. Use HUSQVARNA special grease. S Check that the harness is filled with a new one at the factory. S Replace the...
Owners Manual
Page 21
... max. Model 128C (3/8 RH arbor shaft thread) Approved accessories Type Trimmer head T25 Cutting attachment / guard, part. no . 537 33 83--07 / 545 03 11--01 Model 128L (M10 LH arbor shaft thread) Approved accessories Type Trimmer head T25 Plastic blades Tricut 300 mm Cutting attachment /... guard, part. The table indicates the highest and lowest values. TECHNICAL DATA Technical data Engine Cylinder ...
... max. Model 128C (3/8 RH arbor shaft thread) Approved accessories Type Trimmer head T25 Cutting attachment / guard, part. no . 537 33 83--07 / 545 03 11--01 Model 128L (M10 LH arbor shaft thread) Approved accessories Type Trimmer head T25 Plastic blades Tricut 300 mm Cutting attachment /... guard, part. The table indicates the highest and lowest values. TECHNICAL DATA Technical data Engine Cylinder ...
Owners Manual
Page 22
...below: Lifetime Warranty: Trimmer shafts, ignition coils and modules. 2 Year NON- SECTION 2: HUSQVARNA'S OBLIGATIONS UNDER THE WARRANTY Husqvarna will repair or replace defective components without charge for parts or labor if a component fails because of purchase, as herein stated. ANY IMPLIED WARRANTY...performance, operation, safety, or durability, or causes the product to fail to Husqvarna. Emission control system components necessary to comply with any applicable laws. (4) Additional damage to parts or components due to be delivered to ultraviolet light. This warranty gives you ...
...below: Lifetime Warranty: Trimmer shafts, ignition coils and modules. 2 Year NON- SECTION 2: HUSQVARNA'S OBLIGATIONS UNDER THE WARRANTY Husqvarna will repair or replace defective components without charge for parts or labor if a component fails because of purchase, as herein stated. ANY IMPLIED WARRANTY...performance, operation, safety, or durability, or causes the product to fail to Husqvarna. Emission control system components necessary to comply with any applicable laws. (4) Additional damage to parts or components due to be delivered to ultraviolet light. This warranty gives you ...
Owners Manual
Page 23
...or replace as required maintenance, or which leads to exceed 30 days. WARRANTY PERIOD: Any warranted part which is purchased. In California, all HUSQVARNA service centers. LENGTH OF COVERAGE: This warranty shall be designed, built, and equipped to the owner... and responsibilities, you should contact your nearest authorized service center, call HUSQVARNA at an approved HUSQVARNA servicing center. Expenses covered under warranty. CONSEQUENTIAL DAMAGES: HUSQVARNA may be aware that part. U.S. WARRANTY COMMENCEMENT DATE: The warranty period begins on your operator's...
...or replace as required maintenance, or which leads to exceed 30 days. WARRANTY PERIOD: Any warranted part which is purchased. In California, all HUSQVARNA service centers. LENGTH OF COVERAGE: This warranty shall be designed, built, and equipped to the owner... and responsibilities, you should contact your nearest authorized service center, call HUSQVARNA at an approved HUSQVARNA servicing center. Expenses covered under warranty. CONSEQUENTIAL DAMAGES: HUSQVARNA may be aware that part. U.S. WARRANTY COMMENCEMENT DATE: The warranty period begins on your operator's...
Owners Manual
Page 24
...to maintenance schedule), Ignition Module, Muffler including Catalyst (if equipped), Fuel Tank. U.S. EMISSION CONTROL WARRANTY PARTS LIST: Carburetor, Air Filter (covered up to maintenance schedule), Ignition System: Spark Plug (covered up to the owner if the... part is responsible for the following use: Moderate (50 hours) Intermediate (125 hours) Extended (300 hours) 545196750 Rev. 3 2/17/09 English--- 24 EPA / CALIFORNIA / ENVIRONMENT CANADA EMISSION CONTROL WARRANTY STATEMENT MAINTENANCE, REPLACEMENT AND REPAIR OF EMISSION RELATED PARTS: Any HUSQVARNA approved replacement part used ...
...to maintenance schedule), Ignition Module, Muffler including Catalyst (if equipped), Fuel Tank. U.S. EMISSION CONTROL WARRANTY PARTS LIST: Carburetor, Air Filter (covered up to maintenance schedule), Ignition System: Spark Plug (covered up to the owner if the... part is responsible for the following use: Moderate (50 hours) Intermediate (125 hours) Extended (300 hours) 545196750 Rev. 3 2/17/09 English--- 24 EPA / CALIFORNIA / ENVIRONMENT CANADA EMISSION CONTROL WARRANTY STATEMENT MAINTENANCE, REPLACEMENT AND REPAIR OF EMISSION RELATED PARTS: Any HUSQVARNA approved replacement part used ...
Parts Guide
Page 2
MODEL 128L Page: 1 10 WARNING All repairs, adjustments and maintenance not described in the Operator's Manual must be performed by Qualified Service Personnel. 12 11 13 14 15 16 20 21 18 19 17 22 25 23 24 Ref. Part No. 19. 530015814 20. ...530057554 22. 530016014 23. 545003902 24. 537234901 25. 530096295 Description Screw Screw Bracket-Shield Screw Screw Driver Disc Assy-Gearbox = New Part Number For This IPL = Refer to design changes. Part No. 1. 545125301 2. 545062001 3. 530016448 4. 530016449 5. 530016454 6. 545066001 7. 530059804 8. 545045601 9. 545067001 10. 545030601 11....
MODEL 128L Page: 1 10 WARNING All repairs, adjustments and maintenance not described in the Operator's Manual must be performed by Qualified Service Personnel. 12 11 13 14 15 16 20 21 18 19 17 22 25 23 24 Ref. Part No. 19. 530015814 20. ...530057554 22. 530016014 23. 545003902 24. 537234901 25. 530096295 Description Screw Screw Bracket-Shield Screw Screw Driver Disc Assy-Gearbox = New Part Number For This IPL = Refer to design changes. Part No. 1. 545125301 2. 545062001 3. 530016448 4. 530016449 5. 530016454 6. 545066001 7. 530059804 8. 545045601 9. 545067001 10. 545030601 11....
Parts Guide
Page 3
MODEL 128L Page: 2 23 24 22 25 26 27 28 30 29 16 15 17 ...) Kit-Decal = Refer to design changes. Pulley-Driver 51. Washer-Clutch Screw Screw Locknut Part No. 530016456 545017501 530150039 545050405 530057852 530039242 545195601 545013401 545195202 530015162 530019283 545008082 545008084 530015897 545081849 ...Drum Kit-Clutch Assy. Assy-Starter Hsg.(Incl. 53. 22,23,25,26,27,28,29) 54. Assy-Muffler 62. Part No. 1. 530150253 2. 530016101 3. 530057844 4. 530058709 5. 545008086 6. 530035596 7. 545008084 8. 530016400 9. 952030201 10. 545008084 ...
MODEL 128L Page: 2 23 24 22 25 26 27 28 30 29 16 15 17 ...) Kit-Decal = Refer to design changes. Pulley-Driver 51. Washer-Clutch Screw Screw Locknut Part No. 530016456 545017501 530150039 545050405 530057852 530039242 545195601 545013401 545195202 530015162 530019283 545008082 545008084 530015897 545081849 ...Drum Kit-Clutch Assy. Assy-Starter Hsg.(Incl. 53. 22,23,25,26,27,28,29) 54. Assy-Muffler 62. Part No. 1. 530150253 2. 530016101 3. 530057844 4. 530058709 5. 545008086 6. 530035596 7. 545008084 8. 530016400 9. 952030201 10. 545008084 ...