User Manual
Page 4
... to maintain and operate. Use electrical devices with #8 size wire. TABLE OF CONTENTS Introduction...2 Important Safety Instructions...3-4 Specific Safety Rules...4 Symbols...5-7 Electrical...8-9 Features ...10 Assembly...11 Operation...11-13 Maintenance...14-16 Troubleshooting...17 Warranty...18-19 Parts Ordering / Service...Back Page INTRODUCTION This product...
... to maintain and operate. Use electrical devices with #8 size wire. TABLE OF CONTENTS Introduction...2 Important Safety Instructions...3-4 Specific Safety Rules...4 Symbols...5-7 Electrical...8-9 Features ...10 Assembly...11 Operation...11-13 Maintenance...14-16 Troubleshooting...17 Warranty...18-19 Parts Ordering / Service...Back Page INTRODUCTION This product...
User Manual
Page 5
...-ventilated area with the fuel tank empty. Even a properly connected portable generator can pull in normal use a generator inside a closed or partially Use only authorized replacement parts and accessories enclosed area. It is highly flammable. Do not smoke while handling fuel. Store fuel in the home. English Using a generator indoors can build up power to the intended use a battery-powered or battery-backup CO alarm...
...-ventilated area with the fuel tank empty. Even a properly connected portable generator can pull in normal use a generator inside a closed or partially Use only authorized replacement parts and accessories enclosed area. It is highly flammable. Do not smoke while handling fuel. Store fuel in the home. English Using a generator indoors can build up power to the intended use a battery-powered or battery-backup CO alarm...
User Manual
Page 6
... service center for loose fasteners, fuel leaks, etc. Use of unauthorized parts or failure to follow maintenance instructions may result if the equipment is not electrically connected to the frame of the generator shall be installed by a qualified electrician and connected to have an additional load plugged into this product, loan them these instructions. Replace damaged parts. Failure to isolate the generator...
... service center for loose fasteners, fuel leaks, etc. Use of unauthorized parts or failure to follow maintenance instructions may result if the equipment is not electrically connected to the frame of the generator shall be installed by a qualified electrician and connected to have an additional load plugged into this product, loan them these instructions. Replace damaged parts. Failure to isolate the generator...
User Manual
Page 7
...user must read and understand operator's manual before operation. Breathing carbon monoxide can cause severe burns or death. Failure to operate the product better and safer. English Please study them and learn their meaning. Fuel and its vapors are intended to lift the generator alone. Consult with a wheel kit... Electrocution Failure to use in electrocution, especially if the generator is equipped with local electrician to observe safe practices can result in damp locations. Running generator gives off carbon monoxide, an odorless, colorless, poison gas. To reduce the...
...user must read and understand operator's manual before operation. Breathing carbon monoxide can cause severe burns or death. Failure to operate the product better and safer. English Please study them and learn their meaning. Fuel and its vapors are intended to lift the generator alone. Consult with a wheel kit... Electrocution Failure to use in electrocution, especially if the generator is equipped with local electrician to observe safe practices can result in damp locations. Running generator gives off carbon monoxide, an odorless, colorless, poison gas. To reduce the...
User Manual
Page 8
... que no sigue las instrucciones del Manual del operador. SE MATARÁ o LESIONARÁ GRAVEMENTE si no puede verse ni olerse. Risk of the labels before starting the generator. DANGER PELIGRO Generator is a poison you cannot see or smell. El escape contiene gas venenoso de monóxido de .... Do not add fuel while the product is a potential source of electric shock. Do not operate with a wheel kit. Do not expose to read, contact an authorized service center for replacement. You WILL be KILLED or SERIOUSLY HURT if you to rain or use en lugares hú...
... que no sigue las instrucciones del Manual del operador. SE MATARÁ o LESIONARÁ GRAVEMENTE si no puede verse ni olerse. Risk of the labels before starting the generator. DANGER PELIGRO Generator is a poison you cannot see or smell. El escape contiene gas venenoso de monóxido de .... Do not add fuel while the product is a potential source of electric shock. Do not operate with a wheel kit. Do not expose to read, contact an authorized service center for replacement. You WILL be KILLED or SERIOUSLY HURT if you to rain or use en lugares hú...
User Manual
Page 10
... variation from the generator name plate ratings. A power line conditioner is not designed to avoid equipment damage. Page 8 - Motor Size (H.P.) 1/8 1/6 1/4 1/3 1/2 3/4 1 Running Watts 275 275 400 450 600 850 1100 Watts Required to the ...rated output of carrying the required load. Current in Amperes 2.5 5 7.5 10 15 20 25 30 40 Load in normal operation to draw up to plugging them into the generator if solid state equipment (such as a television set) is characteristic of all electronic equipment should be used compared to Start Motor...
... variation from the generator name plate ratings. A power line conditioner is not designed to avoid equipment damage. Page 8 - Motor Size (H.P.) 1/8 1/6 1/4 1/3 1/2 3/4 1 Running Watts 275 275 400 450 600 850 1100 Watts Required to the ...rated output of carrying the required load. Current in Amperes 2.5 5 7.5 10 15 20 25 30 40 Load in normal operation to draw up to plugging them into the generator if solid state equipment (such as a television set) is characteristic of all electronic equipment should be used compared to Start Motor...
User Manual
Page 11
Total the continuous (running) watts of power needed to the generator outlets before starting its engine. The correct and safe way to manage generator power is the short burst of these simple steps. 1. Plug in generator capacity as follows: 1. Take special care to sequentially add loads as previously described. Select the items you have. 3. Surge wattage is to consider surge loads in...
Total the continuous (running) watts of power needed to the generator outlets before starting its engine. The correct and safe way to manage generator power is the short burst of these simple steps. 1. Plug in generator capacity as follows: 1. Take special care to sequentially add loads as previously described. Select the items you have. 3. Surge wattage is to consider surge loads in...
User Manual
Page 12
... W Starting Watts 1,750 W Rated Frequency 60 Hz Dimensions Length 15.0 in . FEATURES PRODUCT SPECIFICATIONS Engine Engine Type 4 Stroke, OHV Cooling System Forced Air Starting System Recoil Ignition System T.C.I. NOTE: Only use of this operator's manual as well as a knowledge of the information on the product and in properly grounding the generator to charge battery packs with the engine switch) to be used when starting the engine...
... W Starting Watts 1,750 W Rated Frequency 60 Hz Dimensions Length 15.0 in . FEATURES PRODUCT SPECIFICATIONS Engine Engine Type 4 Stroke, OHV Cooling System Forced Air Starting System Recoil Ignition System T.C.I. NOTE: Only use of this operator's manual as well as a knowledge of the information on the product and in properly grounding the generator to charge battery packs with the engine switch) to be used when starting the engine...
User Manual
Page 13
.... packing list Generator Battery Charging Cable Lubricant Bottle Operator's Manual WARNING: Do not use with this product if it is equipped with this product until you careless. WARNING: Do not allow familiarity with a wheel kit. Remember that is sufficient to an approved earth ground. Using a generator indoors can smell the generator exhaust, you are replaced. See a doctor. Use of a product...
.... packing list Generator Battery Charging Cable Lubricant Bottle Operator's Manual WARNING: Do not use with this product if it is equipped with this product until you careless. WARNING: Do not allow familiarity with a wheel kit. Remember that is sufficient to an approved earth ground. Using a generator indoors can smell the generator exhaust, you are replaced. See a doctor. Use of a product...
User Manual
Page 14
... the generator. using a gas can clog the fuel system. OXYGENATED FUELS DO NOT USE E85 FUEL. NOTE: Fuel system damage or performance problems resulting from windows, doors, and vents. NEVER use an oil/gas mixture...start the engine before each use a 4-stroke motor lubricant that can or other approved fuel container and shaking gently to combine. Replace and secure the fuel tank cap. Start and run the engine for API service classification SJ. Adding a fuel stabilizer (not included) extends the usable life of the fuel neck. Replace and secure the fuel...
... the generator. using a gas can clog the fuel system. OXYGENATED FUELS DO NOT USE E85 FUEL. NOTE: Fuel system damage or performance problems resulting from windows, doors, and vents. NEVER use an oil/gas mixture...start the engine before each use a 4-stroke motor lubricant that can or other approved fuel container and shaking gently to combine. Replace and secure the fuel tank cap. Start and run the engine for API service classification SJ. Adding a fuel stabilizer (not included) extends the usable life of the fuel neck. Replace and secure the fuel...
User Manual
Page 15
... choke lever left to the RUN position. Put the engine switch in the ON ( I ) position. Pull the starter grip and rope until the engine runs (a maximum of generator is highly recommended that you refer to your battery manufacturer's instructions for specific charge times. Unplug... engine switch in the OFF ( O ) position. Make sure all loads from the generator. Turn the fuel valve to the ON position. Move the choke lever right to run for later use battery charging cable to charge vented wet lead acid batteries. When batteries become...
... choke lever left to the RUN position. Put the engine switch in the ON ( I ) position. Pull the starter grip and rope until the engine runs (a maximum of generator is highly recommended that you refer to your battery manufacturer's instructions for specific charge times. Unplug... engine switch in the OFF ( O ) position. Make sure all loads from the generator. Turn the fuel valve to the ON position. Move the choke lever right to run for later use battery charging cable to charge vented wet lead acid batteries. When batteries become...
User Manual
Page 16
... result in the generator to dust, dirt, moisture, or corrosive vapors. To check: Remove the spark plug cap. Clean any other parts should be repaired or replaced by the customer. English Do not use only identical Homelite replacement parts. Note: Used lubricant should be replaced at an approved disposal site. GENERAL MAINTENANCE Before each use the following the instructions in a clean and...
... result in the generator to dust, dirt, moisture, or corrosive vapors. To check: Remove the spark plug cap. Clean any other parts should be repaired or replaced by the customer. English Do not use only identical Homelite replacement parts. Note: Used lubricant should be replaced at an approved disposal site. GENERAL MAINTENANCE Before each use the following the instructions in a clean and...
User Manual
Page 17
.... Please contact your nearest service dealer for the location of the spark arrestor for proper washer compression. draining fuel tank/carburetor See Figures 12 - 13. maintenance Measure plug gap. If reusing old spark plug, use 1/2 turn for your gas-powered products, you may become very hot and could damage the engine. Spark arrestors may be cleaned or replaced every 50 hours or...
.... Please contact your nearest service dealer for the location of the spark arrestor for proper washer compression. draining fuel tank/carburetor See Figures 12 - 13. maintenance Measure plug gap. If reusing old spark plug, use 1/2 turn for your gas-powered products, you may become very hot and could damage the engine. Spark arrestors may be cleaned or replaced every 50 hours or...
User Manual
Page 18
... Check Engine Lubricant Change Engine Lubricant Check Air Filter Clean Air Filter Change Air Filter Check/Adjust Spark Plug Replace Spark Plug Check/Adjust Idle Speed Check/Adjust Valve Clearance* Clean Fuel Tank and Filter* Check Fuel Tube Clean/Replace Spark Arrestor * These items should still be carried out by an authorized service center. Page 16 - MAINTENANCE SCHEDULE Before each use...
... Check Engine Lubricant Change Engine Lubricant Check Air Filter Clean Air Filter Change Air Filter Check/Adjust Spark Plug Replace Spark Plug Check/Adjust Idle Speed Check/Adjust Valve Clearance* Clean Fuel Tank and Filter* Check Fuel Tube Clean/Replace Spark Arrestor * These items should still be carried out by an authorized service center. Page 16 - MAINTENANCE SCHEDULE Before each use...
User Manual
Page 19
... authorized service at a steady engine speed, the problem center. Circuit breaker is defective. Try a different item. ing used. Turn fuel valve on. Choke lever is 86 or higher. If problem continues, gasoline. Generator makes a "spark knock" or An occasional light "knocking" or "ping- However, if the knocking is in is off . Clean or replace as needed. Turn engine switch to START position. Spark plug faulty...
... authorized service at a steady engine speed, the problem center. Circuit breaker is defective. Try a different item. ing used. Turn fuel valve on. Choke lever is 86 or higher. If problem continues, gasoline. Generator makes a "spark knock" or An occasional light "knocking" or "ping- However, if the knocking is in is off . Clean or replace as needed. Turn engine switch to START position. Spark plug faulty...
User Manual
Page 20
... corrosion, erosion, normal wear and tear or repairs by other than the Company or its authorized service representative. In addition this warranty does not cover: Tune-ups - Other items not covered under this warranty include: Transportation charges for repairs or adjustments to the customer; Spark Plugs, Carburetor, Carburetor Adjustments, Ignition, Filters, Oil Change Wear items - ANY IMPLIED WARRANTY...
... corrosion, erosion, normal wear and tear or repairs by other than the Company or its authorized service representative. In addition this warranty does not cover: Tune-ups - Other items not covered under this warranty include: Transportation charges for repairs or adjustments to the customer; Spark Plugs, Carburetor, Carburetor Adjustments, Ignition, Filters, Oil Change Wear items - ANY IMPLIED WARRANTY...
User Manual
Page 21
... your SORE: 1) Fuel Metering System: a) Gasoline carburetor assembly and its internal components b) Fuel filter (if so equipped) c) Carburetor gaskets d) Fuel pump (if so equipped) 2) Air Induction System including: a) Intake pipe/manifold b) Air cleaner 3) Ignition System including: a) Spark plug b) Ignition module/coil 4) Miscellaneous Items Used in the written instructions supplied, is liable for the remaining warranty period. (4) Repair or replacement of SUMEC MACHINERY...
... your SORE: 1) Fuel Metering System: a) Gasoline carburetor assembly and its internal components b) Fuel filter (if so equipped) c) Carburetor gaskets d) Fuel pump (if so equipped) 2) Air Induction System including: a) Intake pipe/manifold b) Air cleaner 3) Ignition System including: a) Spark plug b) Ignition module/coil 4) Miscellaneous Items Used in the written instructions supplied, is liable for the remaining warranty period. (4) Repair or replacement of SUMEC MACHINERY...
Replacement Parts List
Page 3
... unqualified person attempt to the frame. Under no circumstances should perform installation and all correspondence regarding your GENERATOR or when ordering replacement parts. Consult the accompanying engine manual or contact our service department for assistance. HOMELITE GENERATOR − HGCA1400 SERIES The model number will not provide engines as replacement parts. Engines are covered through the engine manufacturer's warranty. KEY NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16...
... unqualified person attempt to the frame. Under no circumstances should perform installation and all correspondence regarding your GENERATOR or when ordering replacement parts. Consult the accompanying engine manual or contact our service department for assistance. HOMELITE GENERATOR − HGCA1400 SERIES The model number will not provide engines as replacement parts. Engines are covered through the engine manufacturer's warranty. KEY NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16...
Replacement Parts List
Page 7
... B) KEY NO. 1 2 3 4 5 PART NUMBER 099958002007 099958002058 099958002008 099958002009 099958002059 DESCRIPTION KEY QTY. NO. HOMELITE GENERATOR − HGCA1400 SERIES The model number will be found on a plate attached to the frame. Bushing 4 6 Bolt (M6 x 25 mm 4 7 Fuel Strainer 1 8 Fuel Cap 1 9 Clip 1 PART NUMBER 099958002010 099958002011 099958002012 099958002006 DESCRIPTION QTY. Always mention the model number in all correspondence regarding your GENERATOR or when ordering replacement parts. Fuel Tank 1 Fuel Filter 1 Fuel Valve 1 Fuel Hose 1 7
... B) KEY NO. 1 2 3 4 5 PART NUMBER 099958002007 099958002058 099958002008 099958002009 099958002059 DESCRIPTION KEY QTY. NO. HOMELITE GENERATOR − HGCA1400 SERIES The model number will be found on a plate attached to the frame. Bushing 4 6 Bolt (M6 x 25 mm 4 7 Fuel Strainer 1 8 Fuel Cap 1 9 Clip 1 PART NUMBER 099958002010 099958002011 099958002012 099958002006 DESCRIPTION QTY. Always mention the model number in all correspondence regarding your GENERATOR or when ordering replacement parts. Fuel Tank 1 Fuel Filter 1 Fuel Valve 1 Fuel Hose 1 7
Quick Start Guide
Page 1
...: This Quick Start Guide is felt. To reduce the risk of the operator's manual for more details. Add engine lubricant. HGCA1400 1400 wATT GENERATOR WARNING: Do not connect to page 12 of injury or death, user must read and understand operator's manual before using this product. Typical Generator Shown Exhaust Port Pointed away from the generator. Turn the fuel valve to page 13...
...: This Quick Start Guide is felt. To reduce the risk of the operator's manual for more details. Add engine lubricant. HGCA1400 1400 wATT GENERATOR WARNING: Do not connect to page 12 of injury or death, user must read and understand operator's manual before using this product. Typical Generator Shown Exhaust Port Pointed away from the generator. Turn the fuel valve to page 13...