Hayward TracVac Support and Manuals
Get Help and Manuals for this Hayward item
This item is in your list!
View All Support Options Below
Free Hayward TracVac manuals!
Problems with Hayward TracVac?
Ask a Question
Free Hayward TracVac manuals!
Problems with Hayward TracVac?
Ask a Question
Hayward TracVac Videos
Popular Hayward TracVac Manual Pages
TracVac Owners Manual - Page 1
... Park Dr., Suite 400
Charlotte, NC 28203 Phone: (908) 355-7995
www.hayward.com USE ONLY HAYWARD GENUINE REPLACEMENT PARTS ISSCTV100 RevA
TracVac
Suction-Side Pool Cleaner
Owner's Manual
Safety Information 1 Overview 2 Installation 3 Maintenance 6 Troubleshooting 7 Warranty 10
W3HSCTRACCU
Scan the QR code and follow the link to view helpful videos showing how to setup and operate your new...
TracVac Owners Manual - Page 2
...SAVE THESE INSTRUCTIONS
1 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS The cover should always be stored straight. DO NOT coil the hoses. • Keep away from your local pool store and install it must ...; REMOVE the cleaner before attempting to clean or service the pool vacuum. • DO NOT use .
IMPORTANT SAFETY INSTRUCTIONS
Basic safety precautions should conform to IAPMO SPS4-99A...
TracVac Owners Manual - Page 3
... fully navigate the entire pool.
This steering system has 6 different programmed turns settings at various degrees that the cleaner can easily negotiate main drains, uneven surfaces,... FLOW MAXIMUM FLOW
Regulator Cap
TracVac Double Hose Clip
Float Hose Cone Adaptor
Connector Hoses (11 sections) Leader Hose
2 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
This ensures the pool system ...
TracVac Owners Manual - Page 4
... cleaner requires a minimum & maximum rate of flow to maximize cleaner pool coverage.
3 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS If the variable speed pump has multiple speeds programmed, use . By using the Flow Regulator Valve and adjusting pump speed manually to calibrate the recommended flow rate at the highest preset speed. Perform a backwash or clean...
TracVac Owners Manual - Page 5
.... IMPORTANT: Turn OFF Pool Pump before you begin the next steps.
Use the Hose Cone Adapter to Skimmer Only Connection.
4
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Dedicated Suction Port Connection
1. Install one from your local pool store and have a dedicated suction port, go to make a proper seal, if necessary. IMPORTANT: Ensure that your dedicated...
TracVac Owners Manual - Page 6
... Hose
Skimmer
Flow Regulator
Knob
Flow Regulator Valve
Connecting the Hoses
Hose Cone Adapter
1. Hose Connection
5 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Skimmer Only Connection
If your pool does not have a dedicated suction port, install one section of hose into the skimmer together with the Flow Regulator Valve, as needed to reach the farthest...
TracVac Owners Manual - Page 7
... Hose. Remove the Double Hose Clip and Flow Gauge from the Leader Hose. Cleaner installation is now complete.
6
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Turn off the pump. This will form a loop in the pool as shown below. Submerge the TracVac cleaner to remove all air.
2.
Leader Hose
Suction Source in Center of Pool
Leader...
TracVac Owners Manual - Page 8
...again.
7
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Note that the pool's system is configured in a manner to determine when it by the filter getting dirty. To do this, raise the TracVac
off of the pool floor...steering and can
measure the TracVac's speed as an indication for proper operation, you want to
keep the cleaner under the surface so that has been set with debris. In these ...
TracVac Owners Manual - Page 9
... manual....Install the turbine cover back onto the chassis by reversing Step 4.
7. Firmly push the top cover backwards to TroubleShooting...TracVac from the TracVac, perform the
Lid
following:
1. ward. If the wheels rotate smoothly there probably
is most likely a blockage.
3. If adjustments are ineffective, refer to fully engage the tabs.
8
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
TracVac Owners Manual - Page 10
Troubleshooting
IMPORTANT: Always disconnect cleaner before servicing.
Problem
Solution
...the locking buckle on page 8. do not exceed the maximum Flow Gauge setting.
• Check the Leader Hose for prime. The float may be... to be sure that pump is installed.
9 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
You may need assistance from a pool professional.
Check to increase ...
TracVac Owners Manual - Page 11
...8226;
The left drive gear are worn or damaged. The hose is behaving erratically while installed on these type of the cleaner, redirect to recover
•
if on its side. ....
10 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Reposition leaf canister if installed. Verify that the hose is interfering with the path of the return line water flow. Remove TracVac when not in sunlight...
TracVac Owners Manual - Page 13
...Set of 2) Front Small Wheel Kit (Set of 2, including bearings and mushroom insert) Rear Large Wheel Kit (Set of 2, including bearings and mushroom insert) Roller Kit (Set of 4 rollers) Roller Bar kit (Set... Drive gear Kit (3x drive side gears) Bearing kit (Set of 8) SS Shaft Kit (5x) SS Screw Kit ...kit (Chassis with balancing weights & latch spring installed) Side Covers (2x), Left-Right Accessory Kit...
TracVac Owners Manual - Page 16
Hayward is a registered trademark of their respective owners. All other trademarks not owned by those third parties.
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS For further information or consumer technical support, visit our website at
www.hayward.com
Hayward is not in any way affiliated with or endorsed by Hayward are the property of Hayward Industries, Inc. © 2023 Hayward Industries...
Hayward TracVac Reviews
Do you have an experience with the Hayward TracVac that you would like to share?
Earn 750 points for your review!
We have not received any reviews for Hayward yet.
Earn 750 points for your review!