Hayward HCF Cartridge Filters Support and Manuals
Get Help and Manuals for this Hayward item
This item is in your list!
View All Support Options Below
Free Hayward HCF Cartridge Filters manuals!
Problems with Hayward HCF Cartridge Filters?
Ask a Question
Free Hayward HCF Cartridge Filters manuals!
Problems with Hayward HCF Cartridge Filters?
Ask a Question
Popular Hayward HCF Cartridge Filters Manual Pages
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 1
ISC7031HCF
HCF CARTRIDGE FILTER
MODEL
HCF7030C
EFFECTIVE FILTRATION RATE
DESIGN FLOW RATE Commercial
FT2
M2
GPM
LPM
700
63.2
150
568
MAXIMUM WORKING PRESSURE 50 PSI (3.45 BAR)
ATTENTION INSTALLER: THIS MANUAL CONTAINS IMPORTANT INFORMATION ON THE OPERATION, AND SAFE USE OF THIS EQUIPMENT.
THIS MANUAL IS INTENDED FOR THE END USER OF THIS PRODUCT. Model: HCF7030C
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 2
...9. Service and Repairs
10. Characteristics and Dimensions
3.1 Before Starting the Pump
4. Operation
4.1 4.2 4.3
Filtering Maintaining Your Filter Removing Cartridges
5. Replacement Part Drawings and Numbers
11. Product Registration
13. General
2.1 Installation
3. Manual Air Relief Valve
7.1 7.2
Removing the Manual Air Relief Valve Re-Installation of...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 3
..., and be installed and serviced only by young children. Severe personal injury or death can result in severe personal injury or death. Non-Hayward components may fail in use or climb on -ground pools) advises that all system valves are set in the area of injury, do not stand over or near filter. • If...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 4
...replace damaged, broken, cracked, missing, or not securely attached suction outlet components. • The CPSP as well as the ICC International Residential Code Part IX, Appendix G, Section AG106 specifies
the installation... on seating areas or on local electrical codes for
bonding requirements. • Verify water discharge from the filter manual air relief valve is potential for jewelry,...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 5
...SIDE
"B" ABOVE
IN CM IN CM
18 46 28 71
2.1 Installation WARNING
Manual Air
B
Relief Valve
(MAR)
26 " 66 CM
This product should be installed and serviced only by gravity. UPPER FILTER BODY
1.
Do not locate pump controls over or near filter.
9. General Information
Your Hayward HCF cartridge filter combines superior water filtration with minimum care. With filtration ratings to...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 6
... ONLY Hayward clamp system components; Verify that the filter manual air relief body is discharged from the filter to return to CLOSE manual air relief valve only when a steady stream of water (not air or, air and water mix) is in OPEN position. (See Fig 2)
3.2 Starting the Pump
1. Reassemble the clamp system per the instructions on...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 7
...starting pressure with the new filter cartridge elements, the filter cartridge elements should be replaced the next time the gauge arrow reaches the red arrow.
4.2 Maintaining Your Filter
WARNING
DE2422Z2 METAL REINFORCED SEAL
MANIFOLD
WARNING: This product should be installed and
serviced only by
lifting over the upper filter body. FILTER DISASSEMBLY INSTRUCTIONS
LOWER BODY SEAL SURFACE...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 8
... lifting up. 3. You may not have been removed with a garden hose. Remove the filter cartridge elements by washing inside and outside with hosing. Clean filter cartridge elements.
4.4 Cleaning Cartridges
The Cartridge filter element can damage the filter element.
After hosing cartridge, for best results, carefully brush the pleated surface to remove fine particles. OPERATION
8 Remove...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 9
... manual air relief area.
3.
WARNING
WARNING: This product should be installed and serviced only by a qualified pool professional.
9 FILTER RE-ASSEMBLY INSTRUCTIONS
5. Flush any petroleum solvents
to clean filter components. • Do not lubricate DEX2422Z2 seal. Filter Re-Assembly Instructions
5.1 Re-Installing Cartridges
WARNING
1.
Carefully replace the cartridges...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 11
...REMOVING CARTRIDGES per FILTER RE-ASSEMBLY INSTRUCTIONS. 5. Check the o-ring seals, replace as needed. 2. In areas where subfreezing temperatures can be expected, the filter should be disassembled and the filter cartridges elements cleaned or replaced. 2.
Remove all
electric power on top of the Manual Air Relief Valve
This product should be installed and serviced only...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 12
... restrictions in proper range (adjust as required. 2.
Service and Repairs
Consult your local authorized Hayward dealer or service center. Check for air leak in pool and
super-chlorinate as required. 2.
Be sure flow rate through filter is sufficient. 3. No returns may be made directly to 80 ppm
(Cyanuric Acid)
PROBLEM SOLVING LIST
LOW WATER FLOW 1. SHORT...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 13
...DRAWING AND NUMBERS
10. Replacement Part Drawing and Numbers
Model HCF7303C
# Description
Hayward Part #
1 Pressure Gauge
ECX2712B1
2 O-Ring Kit (Set of 2)
DEX2420Z8A
3 Air Relief Valve Nut
CCX1000N
4 Manual Air Relief w/O-Ring
CCX1000V
5 Manual Air Relief Assembly
DE2420MAR2
6 Upper Filter Body HCF7030C DEX7220B3C
7 Clamp Bolt & Nut
DEX2421J2
Clamp System-including: Clamp, Clamp...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 14
... warranty gives you specific legal rights, and you . Parts that fail or become defective during the warranty period shall be responsible for a period of ONE (1) year from freezing, negligence, improper installation, improper use or care or any other such costs incurred in obtaining warranty replacements or repair. Hayward shall not be repaired or replaced, at www.haywardcommercialpool...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 15
... Replacement ___ Installation for your warranty online at http://www.haywardcommercialpool.com Please Print Clearly:
HCF Cartridge Filter
First Name Last Name Street Address City State___________ Zip Phone Number Purchase Date E-Mail Address Serial Number (10-17 digit number Model Number Pool Capacity U.S. Gallons) ___ Please include me on all e-mail communications regarding Hayward...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 16
... Visit us at: www.haywardcommercialpool.com Total System: Pumps I Filters I Heating I Cleaners I Sanitization I Automation I Lighting I Safety I White Goods I Flow Control
Hayward is ready to serve you in :
1-800-657-2287
Our toll-free line will put you . HCF CARTRIDGE FILTER
Hayward Commercial is a registered trademark of Hayward Industries, Inc. © 2012 Hayward Industries, Inc.
Hayward HCF Cartridge Filters Reviews
Do you have an experience with the Hayward HCF Cartridge Filters that you would like to share?
Earn 750 points for your review!
We have not received any reviews for Hayward yet.
Earn 750 points for your review!