2005 Yamaha Motorsports Venture 600 Problems and Repair Information
Get Help and Support for Yamaha Motorsports
View All Support Options Below
Free 2005 Yamaha Motorsports Venture 600 manuals!
Problems with 2005 Yamaha Motorsports Venture 600?
Ask a Question
Other Models
Free 2005 Yamaha Motorsports Venture 600 manuals!
Problems with 2005 Yamaha Motorsports Venture 600?
Ask a Question
Other Models
Popular 2005 Yamaha Motorsports Venture 600 Manual Pages
Owners Manual - Page 3
... IDENTIFICATION
Identification number records
A. KEY NUMBER: C
CZ-01E
Record the frame number, engine number (Primary ID), and key number in the spaces provided for assistance when ordering...frame number is the seventeen-digit number stamped on the frame of the snowmobile. (See fig. È.) 2 The engine number is stamped in the location as shown. (See fig. É.) 3 Key number (See fig. Ê.)...
Owners Manual - Page 4
It represents the high degree of craftsmanship and reliability that you and your Yamaha dealer pay close attention to the recommended maintenance schedules and operating instructions contained within this manual. This manual will give you have made Yamaha a leader in these fields.
SXV60K SXV60ERK VT60K OWNER'S MANUAL ©2004 by Yamaha Motor Corporation, U.S.A. 1st Edition...
Owners Manual - Page 5
...@
Particularly important information is any question concerning this manual, please consult a Yamaha dealer. BECOME ALERT! CAUTION... minor discrepancies between your snowmobile and this manual by the following notations. The Safety Alert Symbol means ATTENTION...This manual should be taken to avoid damage to make procedures easier or clearer. WARNING
@
PLEASE READ AND UNDERSTAND THIS MANUAL ...
Owners Manual - Page 6
...CORPORATION, U.S.A. SNOWMOBILE LIMITED WARRANTY ...1-1 YAMAHA EXTENDED SERVICE (Y.E.S.) ...1-4 LOCATION OF THE IMPORTANT LABELS ...2-1 SAFETY INFORMATION ...3-1 DESCRIPTION ...4-1 CONTROL FUNCTIONS ...5-1 Main switch...5-1 Starter lever (choke) ...5-2 Throttle lever...5-2 Throttle override system (T.O.R.S.) ...5-2 Speedometer unit ...5-4 High beam indicator light ...5-5 Fuel meter and grip/thumb...
Owners Manual - Page 7
... the engine...7-11 Transporting ...7-12 PERIODIC MAINTENANCE ...8-1 Periodic maintenance chart ...8-1 Tool kit ...8-4 Spark plug inspection ...8-4 Engine idle speed adjustment ...8-6 Throttle cable adjustment ...8-6 Oil pump cable ...replacement...8-29 TROUBLESHOOTING ...9-1 STORAGE ...10-1 SPECIFICATIONS ...11-1 Dimensions...11-1 Engine ...11-1 Chassis...11-2 Electric...11-3
WIRING DIAGRAM ...12-1
Owners Manual - Page 14
...For safety and proper care of the snowmobile, always perform the pre-operation checks on public streets, roads, or highways. Never drive the snowmobile with all labels before starting the engine. ESU00090
3-
Read the Owner's Manual and all of the following for your snowmobile, you...
3-1 This may result if you ignore any control or function you could collide with another vehicle. 3.
Owners Manual - Page 15
... careful where you ride off of the building. Hitting a rock or stump, or running or hot. 7. Handle fuel with extreme care. G Fill the fuel tank outdoors with care; Wear protective clothing. Do not run the engine indoors, except when starting , inspecting, or adjusting the snowmobile. Open the outside doors; exhaust fumes are dangerous...
Owners Manual - Page 21
is activated, make sure that the cause of the malfunction has been corrected and that the engine can be operated without a problem before restarting the engine. will not work properly. will operate
CA-01E
B
Item Throttle switch Carburetor switch Engine È É Ê 1 2 3 4 a b Idling/starting Running Trouble Carburetor switch Throttle switch Throttle cable Throttle valve...
Owners Manual - Page 24
... above problems by the self-diagnosis device of the grip/thumb warmer level indicator flashes once if the grip/thumb warmer adjustment switch is continually pressed at the minimum level. NOTE:
@
G
G
G
G
G
The grip warmer indicator 3 comes on and the display switches to the levels saved when the engine was stopped.
@
ESU00287
Fuel level...
Owners Manual - Page 25
...indicator and warning light warn the rider of the above problems by flashing continuously. (See the table below the ...Warning indicator and warning light flash continuously in the coolant reservoir. (See page 6-2.)
CAUTION:
@
Do not operate the engine if it overheats.
@
The coolant temperature warning indicator indicates a malfunctioning sensor, disconnected coupler, broken lead, or short...
Owners Manual - Page 26
...rider of the above problems by the self-diagnosis device of the snowmobile. Then, check that the wire harness couplers are connected properly in the engine compartment. ESU03970
Self-...detected by flashing continuously. If the self-diagnosis warning indicator and warning light flash after the engine has been started, note the flash pattern, and then have a Yamaha dealer inspect the...
Owners Manual - Page 35
... coolant level in the oil tank. Do not use boiled or distilled water, if soft water is not recommended. ESU00299
Engine oil
Make sure that snow or ice does not enter the fuel tank when refueling. If the coolant level is below the "COLD LEVEL" mark, add soft water until it reaches...
Owners Manual - Page 43
... For SXV60 2. ESU00112
7- Make sure that the engine stop switch is in the half-open (warm engine up the engine until it is returned to stall when the starter lever (choke) is engaged, then pull it does not run roughly or begin to the closed position.
@
Manual starting )
NOTE:
@
The starter lever (choke) is...
Owners Manual - Page 44
...rope on any one attempt.
@
ESU00248
Emergency engine starting
Manual starting model For SXV60 If the recoil starter system should be as short as ...engine" section items 1 and 2 for the "Manual starting model For SXV60ER/VT60 2. Turn the main switch to start, release the switch, wait a few seconds, then try again. After the engine starts, put the starter lever (choke) in the tool kit...
Owners Manual - Page 45
...@
Do not wind the emergency starter rope around your hand.
@
6. Warm up the engine until it does not run roughly or begin to stall when the starter lever is returned ... 1 Rope stopper 2 Primary sheave assembly edge
4.
3. After the engine starts, put the starter lever (choke) in the "Starting the engine" and "Manual starting model" sections.
7-3 Mesh the rope stopper with the moving ...
Owners Manual - Page 47
... the basic techniques well before attempting more reliable snowmobile.
Riding your new snowmobile can cause... Owner's Manual completely and understand the operation of time. To start the engine. With the engine idling, ...perform the preoperation checks listed on pages 3-1-3-3. ESU01272
Riding your snowmobile Getting to know your snowmobile
A snowmobile is a rider active vehicle...
Owners Manual - Page 58
..., there could indicate an intake track air leak or carburetion problem for a snowmobile that the tool kit is firmly seated in the holder and is secured with the engine. A
ESU01430
Tool kit
The owner's tool kit has the tools which are sufficient for inspection and possible repairs. The condition of the spark plug can indicate the...
Owners Manual - Page 64
... reduces the performance of a gasoline engine to be ...problems are the most of the problems found in high altitude riding. To overcome operating with proper carburetion. Less air means less oxygen available for the altitude where you plan to operate your snowmobile may also require different settings for every 305 m (1,000 ft) of elevation. This is because there is less horsepower...
Owners Manual - Page 85
... filled the crankcase when the vehicle has been transported...Remove the spark plugs and turn the engine over several times with the ignition off to inspect. 2. E. Engine constantly backfires or misfires 1. Malfunctioning V-belt clutch ...Ask a Yamaha dealer to expel excess fuel. Loose or broken engine mount ...Ask a Yamaha dealer to inspect. 3. Problem with the correct V-belt...
Owners Manual - Page 89
ESU00228
1-
SPECIFICATIONS
SXV60/SXV60ER/...Engine oil type Carburetor type Fuel
SXV60/SXV60ER/VT60 Liquid cooled 2-stroke, 7-port Parallel 3-cylinder 593 cm3 65.0 × 59.6 mm (2.56 × 2.35 in) 1,600 ± 100 r/min YAMALUBE 2-cycle oil MIKUNI, TM31 × 3 Unleaded gasoline R+M ; 88 or higher 2 Manual with recoil starter: SXV60 Electric and manual with recoil starter: SXV60ER/VT60 Pump...
2005 Yamaha Motorsports Venture 600 Reviews
We have not received any reviews for the 2005 Yamaha Motorsports Venture 600 yet.